Multiquip EGC1500C - Manual
Multiquip EGC1500C – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Diesel Generator Set; Engine Electrical System; Exhaust System; Amperage; Alternator Features; Alternator Specifications
- Page 3 – Fuel System; DGC2020 Digital Genset Controller; Monitoring; Cooling System
- Page 4 – Weight and Dimensions; MQ POWER; Generator Set; Optional Features and Accessories; Container
1500 kW Containerized
Diesel Generator Set
Standard Features
Model
Emissions
Standby Rating
Prime Rating
EGC1500C
EPA Certified
60 Hz
1500kW (1875kVA)
1250kW (1562kVA)
Cummins Heavy Duty Diesel Engine
4-cycle design, turbocharged, aftercooled, direct injection
Polymide blade cooling fan
Engine coolant heater
Meets Tier 2 EPA emissions standards
Fuel System
1000 gallon, single wall fuel tank
Electric fuel priming system
Fuel/water separators & drip pan
Electric fuel run pump
External fuel fill
30 micron RACOR
®
fuel/water separator with drip pan assembly
Alternator
Brushless, 4-pole, synchronous, WYE connection
Class H insulation system conforms to NEMA MG1-22, BS5000,
CSA-C22-2, IEC-34-1 standards for temperature rise
Separate excitation for fast recovery from block loads and motor
starting
Drip-proof, self-venting, amortisseur windings
Epoxy impregnated windings with tropical insulation for increased
environmental protection and long life
Automatic Voltage Regulator
Circuitry senses true RMS voltage rather than average for superior
load regulation
1500 KW
Full Load Acceptance
Accepts 100% of standby nameplate rating in one step, in compliance
with NFPA110 Standards
Generator Control Panel
BASLER™ vibration-isolated controller
Manual or remote engine start/stop
RS485/Modbus communication support
Safety shutdowns
Externally mounted emergency stop switch
Generator mainline circuit breaker, electronically operated, UL listed
Specially Designed Container
■
40 ft. ISO container, sound-attenuated, foam-lined for extremely
quiet operation
■
Isolated operator control room
Solidly mounted battery rack and cooling system
Intregral vibration isolators
Exterior polyurethane coating system provides long life in extreme
operating conditions
Interior DC lights and timer switch
Crankcase filtration system
Critical grade silencer with heat blankets
Warranty
Engine-generator sets are covered by an express written, one-year
limited warranty
(Shown with 40 ft. container optional ISO trailer chassis)
EGC1500C Rev 6
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
1500 kW Containerized Diesel Generator Set Engine Electrical System Batter y Charging Alternator Ground Type Negative Volts 24 VDC Ampere Rating 45A Star ter Motor Rated Voltage 24 VDC Minimum Recommended Battery for 0 °C / Cold Cranking Performance 1800 CCA Exhaust System Exhaust Temperature at Rat...
1500 kW Containerized Diesel Generator Set Fuel System Recommended Fuel ASTM-D975/No.1 or No.2-D Fuel Pump Maximum Lift 6.0 ft. (1.8 m) Filter Micron Size - 98% Efficiency 2 Total Fuel Flow 183 gal/hr (693 L/hr) Fuel Consumption (Prime Power) At % of Load gal/hr (L/hr) 25% 29.2 (111) 50% 47.6 (180) ...
1500 kW Containerized Diesel Generator Set Backfeed to a utility system can cause electrocution and/or property damage. Donot connect to any building’s electrical system except through an approved device.Features and specifications are subject to change without notice. Your MQ Power dealer is: © COP...
