Multiquip EGC-500C - Manual
Multiquip EGC-500C – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Diesel Generator Set; APPLICATION DATA; Alternator Features; Engine Specifications; Engine Electrical System; Alternator Specifications; Amperage; Derating
- Page 3 – Lubrication System; DGC-2020 Digital Genset Controller; Monitoring; Cooling System; Fuel System
- Page 4 – MQ POWER; Weight and Dimensions; Generator Set; Optional Features and Accessories; Container
500kW Containerized
Diesel Generator Set
Model
Emissions
Standby Rating
Prime Rating
EGC-500C
EPA Certified
60 Hertz
500kW (625kVA)
450kW (562.5kVA)
Standard Features
Cummins Heavy Duty Diesel Engine
4-cycle design, turbocharged, aftercooled, direct injection
Polymide blade cooling fan
Engine coolant heater
Meets EPA Tier 2 emissions standards
Fuel System
800 gallon, single wall fuel tank
Fuel priming system
Fuel/water separators and drip pan
Electric fuel run pump
External fuel fill
30 micron Racor
®
fuel filter system
Alternator
Brushless, 4-pole, synchronous, WYE connection
Class H insulation system conforms to NEMA MG1-22, BS5000,
CSA-C22-2, IEC-34-1 standards for temperature rise
Drip-proof, self-venting, amortisseur windings
Epoxy impregnated windings with tropical insulation for increased
environmental protection and long life
Electronic Voltage Regulator
Electronic automatic voltage regulator provides precise regulation
Separate three-phase excitation for fast recovery from block loads
and motor starting
Full Load Acceptance
Accepts 100% of standby nameplate rating in one step, in compliance
with NFPA, para 5-13.2.6
Generator Control Panel
Basler vibration-isolated controller
Manual or remote engine start/stop
RS485/Modbus communication support
Safety shutdowns
Externally mounted emergency stop switch
Generator mainline circuit breaker, 100% rated, electronically
operated, UL listed
Specially Designed Container
20 ft. ISO container, sound-attenuated, foam-lined for extremely quiet
operation
Solidly mounted battery rack and cooling system
Intregral vibration isolators
Exterior polyurethane coating system provides long life in extreme
operating conditions
Interior DC lights and timer switch
Crankcase filtration system
Critical grade silencer with heat blankets
Warranty
Engine-generator sets are covered by an express written, one-year
limited warranty
(Shown with optional ISO trailer chassis)
EGC500C Rev 0
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
500kW Containerized Diesel Generator Set APPLICATION DATA ■ All ratings tested per MIL-STD-705 as applicable. ■ Generator protection for overload and short circuit. ■ Generator is designed and built within NEMA, IEEE andANSI standards for temperature rise. ■ PMG exciter for superior regulation and r...
500kW Containerized Diesel Generator Set Lubrication System Type Full Pressure System Oil Filters Spin-on, Full Flow Oil Pan Capacity 22 gal. (83.0 L) Oil Capacity with Filters 24 gal. (91.0 L) Oil Pressure at Rated Speed (minimum) 20 psi (138 kPa) Exhaust System Exhaust Temperature at Rated kW 875 ...
500kW Containerized Diesel Generator Set Backfeed to a utility system can cause electrocution and/or propertydamage. Do not connect to any building’s electrical system exceptthrough an approved device. Specifications are subject to changewithout notice. Your MQ Power dealer is: © COPYRIGHT 2007, MQ ...
