Mr. Heater HS25NG/LP - Manual

Mr. Heater HS25NG/LP

Mr. Heater HS25NG/LP – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
Page: / 48

Table of Contents:

  • Page 2 – WARNINGS; TABLE OF CONTENTS
  • Page 3 – CHAPTER I; PURPOSE OF EQUIPMENT
  • Page 4 – GENERAL INFORMATION; See Tables 1 and 2 for heater specifications:; Table 1. BTU Ratings and Supply Pressures
  • Page 5 – CHAPTER II; GENERAL INSTALLATION INFORMATION; Figure 2. Installation Clearances to Combustible Surfaces
  • Page 6 – HEATER MOUNTING INSTRUCTIONS
  • Page 7 – Figure 3. Heater Mounting Information
  • Page 8 – Figure 4. Connection Diagram
  • Page 9 – WARNING; Figure 7. Typical Piping Installation
  • Page 10 – Figure 9. Gas Valve Components; CHAPTER III; OPERATING SAFETY INSTRUCTIONS; FIGURE 8. THERMOSTAT CONTROLS
  • Page 12 – CHAPTER IV; ADJUSTING THE PILOT FLAME; 3 mm) of the tip of the thermocouple or generator.; Figure 12. Top View of Standard Capacity Gas Control
  • Page 13 – Table 4. Trouble Shooting Chart; SYMPTOMS; REPLACING THE GAS VALVE UNIT; Intermittent use
  • Page 14 – IF SERVICE IS REQUIRED; PLEASE DO NOT RETURN THIS APPLIANCE TO YOUR STORE
  • Page 15 – ALL WARRANTY CLAIMS REQUIRE PROOF OF PURCHASE; CHAPTER V
  • Page 16 – FOR INFORMATION REGARDING SERVICE OR PARTS:; FOR ADDITIONAL INFORMATION:; READ INSTRUC TIONS C AREFULLY:; Read and; OPERATING INSTRUCTIONS AND OWNER’S MANUAL
  • Page 17 – CALENTADOR INFRARROJO A GAS PARA TALLER; ADVERTENCIA; LEA LAS INSTRUCCIONES DETENIDAMENTE:; Lea y siga todas las instrucciones. Guarde las; INSTRUCCIONES DE fUNCIONAMIENTO y MANUAL DEL USUARIO; HEATSTAR; LANGUAGES
  • Page 18 – ADVERTENCIAS
  • Page 19 – CAPÍTULO I
  • Page 20 – INFORMACIÓN GENERAL; Consulte las especificaciones del calentador; Tabla 1. Índices en BTU y presiones de suministro; Tabla 2. Dimensiones del calentador y tamaños de orificio
  • Page 21 – CAPÍTULO II; INFORMACIÓN Y REQUISITOS GENERALES
  • Page 22 – INSTRUCCIONES DE MONTAJE DEL
  • Page 23 – CONEXIÓN DEL CALENTADOR AL SUMINISTRO DE; Figura 3. Información de montaje del calentador
  • Page 24 – Figura 4. Diagrama de conexión
  • Page 25 – ENCENDIDO DEL CALENTADOR
  • Page 26 – Figura 9. Componentes de la válvula de gas; CAPÍTULO III; INSTRUCCIONES DE FUNCIONAMIENTO; FIGURA 8. CONTROLES DEL TERMOSTATO
  • Page 27 – NOTA; CAPÍTULO IV; REPARACIÓN DE AVERÍAS
  • Page 28 – AJUSTE DE LA LLAMA DEL PILOTO; La llama del piloto debe envolver 3/8 a 1/2 pulgadas; Figura 11. Ajuste correcto de la llama; Tabla 4. Cuadro de reparación de; Figura 12. Vista superior del control de gas de capacidad estándar
  • Page 29 – Uso intermitente
  • Page 30 – NO DEVUELVA EL ARTEFACTO A LA TIENDA
  • Page 31 – CAPÍTULO V
  • Page 32 – PARA OBTENER INFORMACIÓN SOBRE REPARACIÓN O REPUESTOS:; LEA L AS INSTRUCCIONES DETENIDAMENTE:; INSTRUCCIONES DE FUNCIONAMIENTO Y MANUAL DEL USUARIO
  • Page 33 – RADIATEUR D’ATELIER À INFRAROUGE ALIMENTÉ AU GAZ; LISEZ SOIGNEUSEMENT LES INSTRUC TIONS :; Lisez et observez toutes les instructions. Conservez; NOTICE d’UTILISaTION ET GUIdE d’UTILISaTION
  • Page 34 – AVERTISSEMENTS
  • Page 35 – CHAPITRE I; Figure 1. Composants principaux du radiateur
  • Page 36 – RENSEIGNEMENTS GÉNÉRAUX; Voir les tableaux 1 et 2 pour la fiche technique; Tableau 1. Puissances en BTU et pressions d’alimentation; Tableau 2. Dimensions du radiateur et tailles des orifices
  • Page 37 – RENSEIGNEMENTS GÉNÉRAUX
  • Page 38 – INSTRUCTIONS DE MONTAGE DU; A. Déterminez comment vous désirez installer
  • Page 39 – Figure 3. Directives de montage du radiateur
  • Page 40 – Figure 4. Schéma de câblage
  • Page 42 – Figure 9. Composants de la soupape de gaz; DÉMARRAGE DU RADIATEUR; A. Ouvrez le ou les robinets d’alimentation; CHAPITRE III; CONSIGNES DE SÉCURITÉ; FIGURE 8. COMMANDES DU
  • Page 43 – REMARQUE; ARRÊT DU RADIATEUR
  • Page 44 – CHAPITRE IV; RÉGLAGE DE LA FLAMME DE LA VEILLEUSE; La flamme de la veilleuse doit envelopper 10 à; Figure 12. Commande de gaz de capacité standard – vue; Tableau 4. Tableau de dépannage
  • Page 45 – Usage intermittent; Environnement poussiéreux, humide ou corrosif.; A. Elle ne fonctionne pas correctement lors de
  • Page 46 – SI UNE RÉPARATION EST NÉCESSAIRE; NE RETOURNEZ PAS CET APPAREIL À VOTRE MAGASIN
  • Page 47 – TOUTES LES RÉCLAMATIONS EN VERTU DE LA GARANTIE REQUIÈRENT UNE
  • Page 48 – INFORMATIONS SUR L A COMMANDE DE PIÈCES :; POUR OBTENIR DES INFORMATIONS SUR LE SERVICE; NOTICE D’UTILISATION ET GUIDE D’UTILISATION
Loading the manual

E1

Installation instructions and Owner’s Manual

Model # MH25NG/LP

HS25NG/LP

GAS FIRED INFRA-RED WORKSHOP HEATER

MR. HEATER, INC., 4560 W. 160

TH

ST., CLEVELAND, OHIO 44135 · 216-916-3000

WARNING:

If the information in this manual is not followed exactly, a fire or explosion may result causing

property damage, personal injury, or loss of life.

- Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

- WHAT TO DO IF YOU SMELL GAS

• Shut off gas supply

• Do not try to light any appliance

• Do not touch an electrical switch; do not use any phone in your building.

• Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

• If you cannot reach your gas supplier, call the fire department.

- Installation and service must be performed by a qualified installer, service agency, or the gas supplier.

WARNING

: This is an unvented gas-fired heater. It uses air (oxygen) from the room in which it is installed.

Provisions for adequate combustion and ventilation air must be provided. Refer to Fresh Air for Combustion

and Ventilation section on page 3 of this manual.

WARNING

: Improper installation, adjustment, alteration, service or maintenance can cause property damage,

injury or death. Read the installation, operation, and maintenance instructions thoroughly before installing or

servicing this equipment. For assistance or additional information consult a qualified installer, service agency,

or gas supplier.

18672 Rev. D 04/10

Installer: Leave this manual with the appliance. Consumer: Retain this manual for future reference.

READ INSTRUC TIONS C AREFULLY:

Read and

follow all instructions. Place instructions in a
safe place for future reference. Do not allow
anyone who has not read these instructions to
assemble, light, adjust or operate the heater.

MH25NG
MH25LP

M

ODEL

M

ODEL

OpERATINg INSTRUCTIONS AND OwNER’S MANUAL

MR. HEATER

HEATSTAR

HS25NG
HS25LP

LANGUAGES

ENGLISH

Pages E1 — E16

SPANISH

Pages S1 — S16

FRENCH

Pages F1 — F16

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - WARNINGS; TABLE OF CONTENTS

E2 Installation instructions and Owner’s Manual Model # MH25NG/LP HS25NG/LP WARNINGS WARNING : Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death. Read the installation, operation, and maintenance instruc - tions thoroughly before install...

Page 3 - CHAPTER I; PURPOSE OF EQUIPMENT

E3 Installation instructions and Owner’s Manual Model # MH25NG/LP HS25NG/LP GAS CONTROL VALVE POWERPILE GENERATOR EXHAUST VENT BASIC HEATER WALL MOUNTING BRACKET THERMOSTAT CABLE THERMOSTAT CHAPTER I INTRODUCTION 1. EQUIPMENT This heater is the consumer version of our highly suc - cessful, thoroughl...

Page 4 - GENERAL INFORMATION; See Tables 1 and 2 for heater specifications:; Table 1. BTU Ratings and Supply Pressures

E4 Installation instructions and Owner’s Manual Model # MH25NG/LP HS25NG/LP 3. GENERAL INFORMATION • Your heater comes fully assembled and is tested at the factory with the appropriate type of gas and at the input pressures stated on the name - plate. • Upon receipt and prior to attempting installat...

Other Mr. Heater Models

All Mr. Heater Other