Majestic RDV4136 - Manual

Table of Contents:

• Page 2 – RDV4136 Series Direct Vent Gas Fireplace; Table of Contents
• Page 3 – CAUTION: Due to high glass surface temperature chil-; Installation & Operating Instructions; Proposition 65 Warning:; Certified To; Vented Gas Fireplace Heaters; OFF
• Page 4 – “GAS VENT DIRECTLY BELOW, KEEP; MANUFACTURER REQUIREMENTS; Gas Equipment Venting System NOT Provided
• Page 5 – Fireplace Dimensions; Fireplace specifications and framing dimensions.
• Page 6 – Locating Your Fireplace; Appliance; Concentric sections of DV Vent; Clearance to Combustibles; Combustible mantel leg minimum installation.; Mantel Chart; Combustible mantel minimum installation.; Mantels
• Page 7 – Cold climate installation recommendation:; Flange; Flange Location for; Drywall flange location.
• Page 8 – Typical gas supply installation.; TP; Remote switch; Remote switch wiring diagram for RN/RP models.
• Page 10 – • Horizontal venting which incorporates the twist lock; General Venting; There must not be any obstruction
• Page 11 – General Venting Information - Termination Location; Canadian Installations
• Page 12 – Termination clearances.; General Information on Assembling Vent Pipes; Canadian Installations:; Flex Vent Pipes; flex vent; Apply high temperature sealant to 4” and 7” pipes.; Termination Clearances; of Caps
• Page 13 – How to Use the Vent Graph; From the point of this intersection, draw a vertical; DV Graphic; ertical dimension from the fl; Twist Lock Pipes
• Page 14 – Support straps for horizontal runs.; Horizontal vent run.; Vertical Sidewall Applications; According to the chart the maximum
• Page 15 – Maximum vent run with elbows.; Vertical Sidewall Installation; Maximum number of elbow degrees.; When using flex vent, the opening will have to; Noncombustible Walls:; Vent Opening; Vent Opening for Combustible Wall; Locate vent opening on wall.; Adjustable zero clearance sleeve.
• Page 16 – Vertical height requirement.
• Page 17 – Vertical Sidewall Installation; spacer springs; Install spacer springs.; Install the 4” flex then 7” flex to the termination.; Bend flex vent at 90° so horizontal portion is 6; Below Grade Installations; Ensure sidewall venting clearances are observed.; pipe coming through the wall.
• Page 18 – Top Vent; Below grade installation.; This Gas Fireplace has been approved for:; Snorkel; Snorkel installation, recessed foundation.; ceiling above and mark position.
• Page 19 – Typical offset application.; Typical ceiling/roof support; Typical Roof Support; Roof and ceiling supports.; Minimum termination to roof clearance.; Install appropriate pipe sections until the venting is
• Page 20 – Vent Components; Vent components; Elbow
• Page 21 – Tilt the glass frame out slightly at the bottom, lift the; Operating Instructions; Glass Information; Remove valve access panel.; Window frame assembly removal.; Glass Cleaning
• Page 22 – Installation of Logs, Lava Rock & Ember Material; Log Installation; Logs
• Page 23 – Place ember material on
• Page 24 – Flame Characteristics; Correct pilot flame appearance.
• Page 25 – FOR YOUR SAFETY READ BEFORE LIGHTING; Follow the gas supplier’s instructions.; To Turn Off Gas To Heater; Lighting and Operating Instructions; Lighting Instructions; Euro SIT; For Fireplaces Equipped with the SIT 820 Valve
• Page 26 – Lighting & Operating Instructions; For Your Safety, Read the Following Warnings; result, causing property damage, personal injury and loss of life.; DO NOT; Valve in the; “ON”; position
• Page 27 – Troubleshooting
• Page 28 – Troubleshooting AF4000 Valve; Pilot will not light/stay lit; A proper ground is essential to spark
• Page 29 – Verify the gas supply is turned on.; Main flame will not light
• Page 30 – Troubleshooting - Honeywell VS8421
• Page 31 – Conversions must be completed by qualified personnel; “OFF”; Remove rubber cap and adjust gas type marker.; Remove mounting; SIT; Burner Orifice Conversion
• Page 32 – Pilot Orifice Conversion; pilot hood; Reinstall pilot hood and be sure to align with index; air shutter conversion; Air shutter setting.; AF pilot orifice; Remove pilot orifice.; Table 1 Injector Orifice Size Matrix
• Page 33 – Maintenance; Burner and Burner Compartment; Cleaning the Standing; If repair is necessary, it should be per-
• Page 34 – b. Left Cross Log
• Page 36 – Fuel Conversion Kits; Conversion Kit, NG to LP
• Page 37 – Optional Accessories; Fan placement; Side View; FK12 Fan Kit placement.; WIRING DIAGRAM; Fan Kits; Remove the burner tray from the fireplace by first tilt-; FK24 fan placement.; Wiring Instructions; Secure fan to cold air box with two (2) washers and
• Page 38 – Ceramic Refractory Panels; rear ceramic panel; Rear refractory panel installation.; Ceramic panels; Ceramic panel installation.; Porcelain Steel Back
• Page 39 – IF WARRANTY SERVICE IS NEEDED...; ) Contact your supplier. Make sure you have your warranty,; LIMITED LIFETIME WARRANTY; PRODUCT COVERED BY THIS WARRANTY
• Page 40 – Efficiency Ratings; Model; CFM Corporation