Page 2 - Hardware Replacement Guide
Hardware Replacement Guide 31041387_K3_HRG_EN_V1.1.indd 1 2009.10.23 10:29:53 AM
Page 3 - Contents
Contents Overview ..................................................................................... 1 Chapter 1 Locations ................................................................ 4 Locating components and connectors ...........................................4 Identifying parts on the sy...
Page 4 - Overview; Safety information for replacing CRUs
Hardware Replacement Guide Overview This guide is intended to be used by customers who are replacing Customer Replaceable Units (CRUs) as well as trained service personnel who are replacing Field Replaceable Units (FRUs). In this guide, CRUs and FRUs will often be referred to as parts. Note: Trained...
Page 5 - Additional information resources; Handling static-sensitive devices
Hardware Replacement Guide Additional information resources If you have Internet access, the most up-to-date information for your computer is available from the World Wide Web. You can find the following information: • CRU removal and installation information • Publications • Troubleshooting informa...
Page 7 - Locations; Chapter; Locating components and connectors; Internal components
Hardware Replacement Guide Locations Chapter This chapter provides illustrations to help locate the various connectors, controls and components of the computer. To remove the computer cover, refer to “Removing the computer cover”. Locating components and connectors The following illustrations will h...
Page 8 - Front view
Hardware Replacement Guide Power supply PCI Express adapter card System fan Memory modules Microprocessor fan and heat sink Hard disk drive PCI Express adapter connector Optical drive Front view The following illustrations show the location of connectors on the front of the computer. 9 8 3 12 4 56 7...
Page 9 - Rear view
Hardware Replacement Guide Optical drive (Some models are equipped with only one optical drive.)Power Dial switch Rear view The following illustration shows the location of connectors on the rear of the computer. 8 11 121314 9 10 7 1 2 3 4 5 6 Voltage selection switch (selected models only)Power con...
Page 10 - Identifying parts on the system board
Hardware Replacement Guide PCI Express x16 graphics adapter connector (Some models are equipped with this connector. For more information about the graphics adapter, see the description below).WiFi antenna connector (This connector only equipped on the model with WiFi card. For more information abou...
Page 12 - General information; Pre-disassembly instructions; Removing the computer cover; To remove the computer cover:; Replacing hardware
Hardware Replacement Guide Attention: Do not remove the computer cover or attempt any repair before reading the “Important safety information” in the Safety and Warranty Guide that was included with your computer or in the Hardware Maintenance Manual (HMM) for the computer. To obtain copies of the S...
Page 14 - Removing the front bezel; To remove the front bezel:
Hardware Replacement Guide Removing the front bezel To remove the front bezel: 1. Remove the computer cover. Refer to “Removing the computer cover”. Note: For this procedure, it helps to lay the computer on its side. 2. Remove the front bezel by releasing the three plastic tabs inside the chassis an...
Page 15 - Replacing a memory module; To replace a memory module:
Hardware Replacement Guide Replacing a memory module Attention: Do not remove the computer cover or attempt any repair before reading the “Important safety information” in the Safety and Warranty Guide that was included with your computer or in the Hardware Maintenance Manual (HMM) for the computer....
Page 16 - Replacing the hard disk drive; To replace the hard disk drive:
Hardware Replacement Guide Replacing the hard disk drive Attention: Do not remove the computer cover or attempt any repair before reading the “Important safety information” in the Safety and Warranty Guide that was included with your computer or in the Hardware Maintenance Manual (HMM) for the compu...
Page 17 - Replacing an optical drive; To replace an optical drive
Hardware Replacement Guide 7. Refer to the “Completing the installation”. Replacing an optical drive Attention: Do not remove the computer cover or attempt any repair before reading the “Important safety information” in the Safety and Warranty Guide that was included with your computer or in the Har...
Page 18 - Replacing the system fan assembly; To replace the system fan assembly:
Hardware Replacement Guide 5. Slide the new optical drive into the bay from the front until it snaps into position. 6. Connect the data and power cables to the drive.7. Install the front bezel. Refer to the steps 3 of the “Removing the front bezel”.8. Install the computer cover. Refer to “Completing...
Page 21 - Replacing the heat sink assembly; To replace the heat sink assembly:
Hardware Replacement Guide Replacing the heat sink assembly Attention: Do not remove the computer cover or attempt any repair before reading the “Important safety information” in the Safety and Warranty Guide that was included with your computer or in the Hardware Maintenance Manual (HMM) for the co...
Page 23 - Replacing a PCI or AGP adapter; To replace an adapter:
0 Hardware Replacement Guide Replacing a PCI or AGP adapter Attention: Do not remove the computer cover or attempt any repair before reading the “Important safety information” in the Safety and Warranty Guide that was included with your computer or in the Hardware Maintenance Manual (HMM) for the co...
Page 25 - Please remove the plastic bracket first as the following:
Hardware Replacement Guide Note 1: Replacement of some models equipped with graphic adapter bracket is different. Please remove the plastic bracket first as the following: 1. Remove the two screws that secure the plastic bracket at the bottom of the chassis. 2. Lift the plastic bracket out of the ch...
Page 27 - Please remove the bracket first as the following:
Hardware Replacement Guide Note 2: Replacement of some models equipped with graphic adapter bracket is different. Please remove the bracket first as the following: 1. Remove the screw that secures the bracket at the side of the chassis.2. Press the pin on one end of the metal bracket and pull the me...
Page 29 - Replacing the CPU; To replace an CPU
Hardware Replacement Guide Replacing the CPU Attention: Do not remove the computer cover or attempt any repair before reading the “Important safety information” in the Safety and Warranty Guide that was included with your computer or in the Hardware Maintenance Manual (HMM) for the computer. To obta...
Page 32 - Replacing the keyboard; To replace the keyboard:
Hardware Replacement Guide Replacing the keyboard To replace the keyboard: 1. Remove any media (diskettes, CDs, or memory cards) from the drives, shut down your operating system, and turn off all attached devices and the computer. 2. Unplug all power cords from electrical outlets. 3. Locate the conn...
Page 33 - Replacing the mouse; To replace the mouse:
0 Hardware Replacement Guide Replacing the mouse To replace the mouse: 1. Remove any media (diskettes, CDs, or memory cards) from the drives, shut down your operating system, and turn off all attached devices and the computer. 2. Unplug all power cords from electrical outlets. 3. Locate the connecto...
Page 34 - Replacing the External speaker; Completing the installation; To complete the part installation:
Hardware Replacement Guide Replacing the External speaker 1. Remove any media (diskettes, CDs, or memory cards) from the drives, shut down the computer, and turn off all attached devices. 2. Unplug all power cords from electrical outlets. 3. Locate the Speaker. Refer to “Locating connectors on the r...
Page 36 - Statement
Hardware Replacement Guide Appendix. Statement Thanks for using Lenovo products. Carefully read all of the documents shipped with your computer before you install and use the product for the first time. Lenovo will not assume responsibility for damage that results from failure to operate the product...
