Lennox RDV33/40 - Manual

Lennox RDV33/40

Lennox RDV33/40 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
Page: / 30

Table of Contents:

  • Page 2 – TABLE OF CONTENTS; USING THIS MANUAL
  • Page 5 – ). Choisissez la langue qui est principale­; COLOCACIóN DE ADVERTENCIAS DE; ) o en el termostato de pared; LENNOX HEARTH PRODUCTS; WARNINGS; ). The warnings should already have been; LENNOX HEARTH PRODUCTS; Figure A
  • Page 6 – Fireplace Requirements; WARNING; THIS FIREPLACE HAS BEEN ALTERED TO
  • Page 7 – Certification
  • Page 9 – Insert Dimensions; Width of insert behind Surround Panels; CAUTIONS; RTV high temperature silicone is an approved; Figure 1; Minimum Fireplace Opening; * Top air duct will need to be removed for short ZC applications.
  • Page 10 – The letters below, E through J, correspond to; Hearth Protection; Figure 4A; the RDV40/SDVI40 mantel clearances as shown in; Figures 4A; and; Facing and
  • Page 11 – Venting Installation; current edition of the National Fuel Gas Code ANSI­Z223.1 (In Canada,; Direct-Vent Fireplace Insert Vent Requirements - Use liner; Vent Kits; INSTALLATION; Masonry and Factory Built Fireplaces; Figure 6a - Terminating Air Inlet in Chimney; Vertical Venting; Figure 6b
  • Page 12 – Zero Clearance Fireplace Installation; Note; Brick Panel and Log Set Installation; Retainer; RACK AND THE BURNER PAN.; Side Brick Panels; Figure 7; Screws
  • Page 13 – Face Installation; NEVER use brass polish to clean plated surfaces, this; Surround Installation; Packaging List; ) from the parts bag and install; Spring Handle Latches
  • Page 14 – Robertshaw Millivolt Gas Valve; Pressure Tap
  • Page 16 – ). To properly complete the installation of this; APPOSITION DES MISES EN GARDE; ) ou sur le thermostat; COLOCACIóN DE ADVERTENCIAS DE SEGURIDAD; ) y en el transmisor
  • Page 18 – TO TURN OFF GAS TO APPLIANCE; PILOT ASSEMBLY; IMPORTANT NOTE: When opening the lower door on the face
  • Page 19 – Flame Color and Behavior; Figure; Burner Flame Appearance; Paint Curing
  • Page 20 – Thermostat Wire; Millivolt Control Schematic
  • Page 21 – Turn off gas and electrical power to the fireplace; The viewing glass should be cleaned periodically (see Glass Main-
  • Page 22 – CAUTION
  • Page 23 – qualified service technician should perform the conversion.
  • Page 25 – Description; in poor performance and safety hazards.
  • Page 27 – complete face
  • Page 30 – WARRANTY; Natural Gas
Loading the manual

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

INSTALLATEUR: Laissez cette notice avec l'appareil.

CONSOMMATEUR: Conservez cette notice pour consul-

tation ultérieure.

- Do not store or use gasoline or other flammable vapors and

liquids in the vicinity of this or any other appliance.

- WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any

phone in your building.

• Immediately call your gas supplier from a neighbor’s

phone. Follow the gas supplier’s instructions.

• If you cannot reach your gas supplier, call the fire

department.

- Installation and service must be performed by a quali-

fied installer, service agency or the gas supplier.

WARNING: If the information in these instructions is

not followed exactly, a fire or explosion may result

causing property damage, personal injury or death.

- Ne pas entreposer ni utilizer d’essence ni d’autres

vapeurs ou liquides inflammables dans le voisinage

de cet appareil ou de tout autre appareil.

- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:

• Ne pas tenter d’allumer d’appareil.

• Ne touchez à aucan interrupteur. Ne pas vous servir

des téléphones se trouvant dans le bâtiment où vous

trouvez.

• Appelez immédiatement votre fournisseur de gaz

depuis un voisin. Suivez les instructions du fournis-

seur.

• Si vous ne pouvez rejoindre le fournisseur de gaz,

appelez le service des incindies.

- L’installation et l’entretien doivent être assurés par un

installateur ou un service d’entretien qualifié ou par

le fournisseur de gaz.

AVERTISSEMENT: Assurez-vous de bien suivre les

instructions données dans cette notice pour réduire

au minimum le risque d’incindie ou d’explosion ou

pour éviter tout dommage matériel, toute blessure

ou la mort.

INSTALLATION AND OPERATION

Ce manuel d’installation est disponible en francais, s implement en faire
la demande. Numéro de la pièce 775218CF.

MODELS

US

Portland

P/N 775218M REV. E 09/2011

Direct

-V

ent

RAVENNA™

This appliance may be installed in an aftermarket permanently located, manufactured home (USA only) or mobile

home, where not prohibited by local codes. This appliance is only for use with the type of gas indicated on the rating

plate. This appliance is not convertible for use with other gases, unless a certified kit is used.

WARNING AVERTISSEMENT

UNE SURFACE VITRÉE CHAUDE PEUT

CAUSER DES BRÛLURES.

LAISSER REFROIDIR LA SURFACE

VITRÉE AVANT D'Y TOUCHER.

NE PERMETTEZ JAMAIS À UN ENFANT

DE TOUCHER LA SURFACE VITRÉE.

HOT GLASS WILL

CAUSE BURNS.

DO NOT TOUCH GLASS

UNTIL COOLED.

NEVER ALLOW CHILDREN TO

TOUCH GLASS.

RDV33/40

SDVI33/40

This fireplace insert is factory equipped for 40,000 BTU input and can be convert-

ed to 33,000 using a smaller orifice (provided in optional orifice kit P/N H5924).

OTL Report No. 050-S-15c-5

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - TABLE OF CONTENTS; USING THIS MANUAL

2 CONGRATULATIONS! When you purchased your new gas fireplace insert, you joined the ranks of thousands of individuals whose answer to their home heating needs reflects their concern for aesthetics, efficiency and our environment. We extend our continued support to help you achieve the maximum benefi...

Page 5 - ). Choisissez la langue qui est principale­; COLOCACIóN DE ADVERTENCIAS DE; ) o en el termostato de pared; LENNOX HEARTH PRODUCTS; WARNINGS; ). The warnings should already have been; LENNOX HEARTH PRODUCTS; Figure A

5 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. APPOSITION DES MISES EN GARDE RELATIVES À LA SÉCURITÉ D’UTILISATION Votre foyer a été livré avec des étiquettes de sécurité qui doivent être collées à côté des dispositifs de contrôle du foyer...

Page 6 - Fireplace Requirements; WARNING; THIS FIREPLACE HAS BEEN ALTERED TO

6 For altitudes above 2,000 feet (In Canada 4,500 FT/1370 M), the orifice should be de­rated by 4% for every 1,000 feet to maintain the proper ratio of gas to air. Improper orifice sizing may result in damage and unsafe conditions. Changing the orifice should only be done by a quali­ fied service te...

Other Lennox Models

All Lennox Other