Lennox MPB4035CNE-B - Manual

Lennox MPB4035CNE-B

Lennox MPB4035CNE-B – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
Page: / 28

Table of Contents:

  • Page 2 – TAbLE OF CONTENTS; please read and understand these; pACKAGING LIST; GENERAL INFORmATION; WARNING
  • Page 3 – 0 - latest edition, or the Canadian Electrical; Table 1
  • Page 4 – Tables 3 and 4; REQUIREmENTS FOR THE COmmON-; NOTE: Flame appearance will diminish 4% per; Flame Height; SIT Millivolt Gas Valve; Figure 2; - Honeywell Electronic Gas Valve; Table 2; Table 5
  • Page 5 – Figure 3 - Typical Installations; Note: When the unit is installed with one side flush; • An
  • Page 6 – Termination Heights For Vents
  • Page 7 – Table 6; ” Clearance; Figure 6; *Note: See Figures 7 and 8 on Page 8 for clearance requirements to; mINImUm CLEARANCES TO COmbUSTIbLES; in Table 6 with the following exception:; When the unit is installed with; Figure 5 - Minimum Mantel Clearances; MANTEL CLEARANCES
  • Page 8 – Attach Safety in Operation; FRAmING; All framing details must allow for a minimum; dO NOT; dETAILEd INSTALLATION STEpS; TYpICAL INSTALLATION SEQUENCE; Figure 8; Side Nailing Flanges
  • Page 9 – FRAmING SpECIFICATIONS; materials, calculations will need to be made.; Header; ti; mm; Figure 9
  • Page 10 – FIREpLACE SpECIFICATIONS
  • Page 11 – ROUTE GAS SUppLY LINE; Figure 11 - Route Gas Line; Right Side Front; Table 7; proper Sizing of Gas Line
  • Page 12 – Note: Refer to the vent manufacturers instal-; CAUTION; This appliance cannot be vented; General Information; Approved Vent Components; on
  • Page 13 – Figures 17 or; Verify proper operation after servicing.; Note: The electronic appliance must be con-; BLOWER CONTROL CIRCUIT WIRING; Junction Box Wiring
  • Page 14 – Showing the Blower Wiring for the Optional; Showing the blower Wiring for the Optional; Step 6. CONNECTING GAS LINE; 0 illustrates two methods for connecting the; AIR bLOWER KIT; Note: The tab connecting the receptacles of
  • Page 15 – tive leak test solution but it is not recommended,; Step 7. OUTSIdE AIR KITS; Never use an open flame to
  • Page 16 – TION; Note: Instructions are also found on the litera-; Electronic Appliance Checkout; Shown with control; ELECTRONIC pILOT ASSEmbLY
  • Page 17 – Handle logs carefully to prevent; Glowing Embers, Vermiculite, decorative Volcanic Stone And Log; Note: This appliance is provided with enough Glowing Embers for; Glowing Embers; Bag of Glowing
  • Page 21 – INSTALLING OR REMOVING GLASS dOOR; Note: When installing the glass door, ensure the
  • Page 22 – Step 11. bURNER AdJUSTmENTS; • If there is smoke or soot present, first check; WARNINGS; burner Air Shutter Adjustment
  • Page 23 – Step 12. VENT OpERATION TEST; - Close all doors and windows in the room.
  • Page 24 – Detail A; Limit; HOOd INSTALLATION; On louvered face units; FINISHING REQUIREmENTS; Wall Details; This area must remain clear; Detail B
  • Page 25 – COLOCACIóN dE AdVERTENCIAS dE; LENNOX HEARTH pROdUCTS; LENNOX HEARTH pROdUCTS; Figure A
  • Page 26 – GAS CONVERSION KITS; Millivolt; this installation assumes responsibility for this conversion.; AVERTISSEmENT; assume les responsabilités liées à la conversion.; CAUTION: THE GAS SUppLY SHALL bE; Figure 21. Access the control compartment.
  • Page 27 – Table 8
Loading the manual

OTL Report No. 116-F-36-5

US

Portland

MODELS

This appliance may be installed in an aftermarket permanently located, manufactured home (USA only) or mobile

home, where not prohibited by local codes. This appliance is only for use with the type of gas indicated on the rating

plate. This appliance is not convertible for use with other gases unless a certified kit is used.

INSTALLATION INSTRUC

TIONS

MPB B-Vent

Gas Fireplaces

mpb3328CNm-b
mpb3328Cpm-b
mpb3530CNm-b

mpb3530Cpm-b

mpb4035CNm-b
mpb4540CNm-b

mILLIVOLT:

mpb3328CNE-b
mpb3530CNE-b

mpb4035CNE-b
mpb4540CNE-b

ELECTRONIC:

p/N 850033m Rev. G 01/2011

This manual is one of a set of two supporting this product.

Refer to P/N 875031M for Care and Operation Instructions.
Ce manuel est disponible en francais, simplement

en faire la demande. Numéro de la pièce 850033CF.

AVERTISSEMENT : Assurez-vous de bien suivre les

instructions données dans cette notice pour réduire au

minimum le risque d’incindie ou d’explosion ou pour

éviter tout dommage matériel, toute blessure ou la mort.

- Ne pas entreposer ni utilizer d’essence ni d’autres vapeurs

ou liquides inflammables dans le voisinage de cet appareil

ou de tout autre appareil.

- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ :

• Ne pas tenter d’allumer d’appareil.
• Ne touchez à aucan interrupteur. Ne pas vous servir des

téléphones se trouvant dans le bâtiment où vous trouvez.

• Appelez immédiatement votre fournisseur de gaz depuis

un voisin. Suivez les instructions du fournisseur.

• Si vous ne pouvez rejoindre le fournisseur de gaz,

appelez le service des incindies.

- L’installation et l’entretien doivent être assurés par un

installateur ou un service d’entretien qualifié ou par le

fournisseur de gaz.

WARNING: If the information in these instructions

is not followed exactly, a fire or explosion may

result, causing property damage, personal injury,

or death.

-

vapors and liquids in the vicinity of this or any other

appliance.

- WHAT TO DO IF YOU SMELL GAS:

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any

phone in your building.

• Immediately call your gas supplier from a

neighbor’s phone. Follow the gas supplier’s

instructions.

•

department.

- Installation and service must be performed by a

WARNING / AVERTISSEMENT / AVISO

• HOT GLASS WILL CAUSE

BURNS.

• DO NOT TOUCH GLASS

UNTIL COOLED.

• NEVER ALLOW CHILDREN

TO TOUCH GLASS.

• UNE SURFACE VITRÉE CHAUDE

PEUT CAUSER DES BRÛLURES.

• LAISSER REFROIDIR LA SURFACE

VITRÉE AVANT D'Y TOUCHER.

• NE PERMETTEZ JAMAIS À UN ENFANT

DE TOUCHER LA SURFACE VITRÉE.

• EL VIDRIO CALIENTE

CAUSARÁ QUEMADURAS.

• USTED DEBE NUNCA

TOCAR EL VIDRIO CALIENTE.

• LOS NIÑOS DEBEN NUNCA

TOCAR EL VIDRIO.

INSTALLER:

Leave this manual with the appliance.

CONSUmER:

Retain this manual for future reference.

INSTALLATEUR :

Laissez cette notice avec l'appareil.

CONSOmmATEUR :

Conservez cette notice pour

consultation ultérieure.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - TAbLE OF CONTENTS; please read and understand these; pACKAGING LIST; GENERAL INFORmATION; WARNING

2 TAbLE OF CONTENTS Packaging .........................................Page 2Introduction ......................................Page 2General Information ..........................Page 2Massachusetts and New York Requirements ................................ Page 4Cold Climate Insulation ..............

Page 3 - 0 - latest edition, or the Canadian Electrical; Table 1

3 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. WARNING Improper installation, adjust- ment, alteration, service or maintenance can cause injury or property damage. Refer to this manual. For assistance or additional information consult a qualified installer, service agency or the gas supplier...

Page 4 - Tables 3 and 4; REQUIREmENTS FOR THE COmmON-; NOTE: Flame appearance will diminish 4% per; Flame Height; SIT Millivolt Gas Valve; Figure 2; - Honeywell Electronic Gas Valve; Table 2; Table 5

4 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. manifold Gas Supply pressure (all models) Fuel # Low (millivolt only) High Natural Gas (Lo) 2.2" WC (0.55 kpa) (Hi) 3.5" WC (0.87 kpa) propane (Lo) 6.3" WC (1.57 kpa) (Hi) 10.0" WC (2.49 kpa) Table 4 Inlet Gas Supply pressure (al...

Other Lennox Models

All Lennox Other