Lennox EDVI25 - Manual

Lennox EDVI25

Lennox EDVI25 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
Page: / 24

Table of Contents:

  • Page 3 – INTRODUCTION; Exhaust: Use 3” diameter UL1777 listed; GENERAL INFORMATION; TABLE OF CONTENTS; CONGRATULATIONS ON THE PURCHASE OF YOUR NEW GAS APPLIANCE MANU-; that will ensure years of trouble-free warmth and pleasure.; Table 1; It is imperative that the control compart-; Table 2 shows the units' gas orifice size for; Table 2; Tables 3 and 4; Table 3
  • Page 4 – IMPORTANT; Keep your house well ventilated; Lighting Millivolt Appliances; Figure 4; CONTROL COMPARTMENT ACCESS; Figure 3; Variable Flame Height Adjustment; Figure 1; Figure 2; MODEL EDVI5; must be isolated; equal to; must be disconnected; greater
  • Page 5 – WARNING; O P E R AT I O N A N D C A R E O F Y O U R; MAINTENANCE; Page; CAUTION; Check Burner Flame Appearance; Glass Cleaning; Note: Clean glass after first two weeks of opera-; Servicing Blower; Refer to blower wiring diagram on; Procedure For; Figure 5; Remove 4 Screws; mounting screws and remove the blower; Figure 6; Remove screws around parimeter of
  • Page 6 – Small Area Paint Touch-up; Label all wires prior to discon-; Figure 7
  • Page 7 – Figure 19 on Page 8 and verify the flame pattern; MAINTENANCE SCHEDULE
  • Page 8 – PROCEDURE FOR REMOVING THE STANDARD GLASS DOOR; Pull door hook forward until it releases; Door hook is located below glass door; Swing bottom of; Burner Flame Appearance; BURNER ADJUSTMENT; Flame Appearance and Sooting; air shutter may require adjustment.
  • Page 9 – Burner Adjustment Procedure; Table 5; (For EDVI35 Log Installation Instructions, see; Installation Instructions
  • Page 10 – Rear Log
  • Page 11 – Figure; LOGS, VERMICULITE AND EMBERS - Model EDVI35
  • Page 12 – IMPORTANT: The quantity and placement of the ember material can
  • Page 13 – MILLIVOLT APPLIANCE CHECKOUT; Pages 16 or 17 of this manual.; WIRING DIAGRAMS; Red
  • Page 14 – Millivolt Wiring Diagram; Remote Control Receiver
  • Page 16 – LIGHTING INSTRUCTIONS – MILLIVOLT GAS VALVE; FOR YOUR SAFETY, READ BEFORE LIGHTING; WHAT TO DO IF YOU SMELL GAS; TO TURN OFF GAS TO APPLIANCE; Knob cannot be turned from “PILOT” to “OFF”; Millivolt Pilot
  • Page 17 – INSTRUCTIONS D’ALLUMAGE – VANNE GAZ MILLIVOLT; INSTRUCTIONS D'ALLUMAGE; VOICI CE QUE VOUS DEVEZ FAIRE SI VOUS DÉCELEZ UNE ODEUR; Il est impossible de tourner le bouton de “PILOT” à “OFF” à; POUR FERMER LE GAZ QUI ALIMENTE L’APPAREIL; Honeywell Vanne
  • Page 18 – REPLACEMENT PARTS LIST; Gas Controls
  • Page 19 – REPLACEMENT PARTS DIAGRAMS
  • Page 20 – TROUBLESHOOTING THE MILLIVOLT GAS CONTROL SYSTEM; in the “ON” position.; SYMPTOM
  • Page 24 – LENNOX HEARTH PRODUCTS; Natural Gas
Loading the manual

Report No. 116-F-14-5

CARE AND OPERATION INSTRUCTIONS

Direct-Vent Gas

Fireplace Heater Inserts

Do not store or use gasoline or other flammable

vapors or liquids in the vicinity of this or any other

appliance.

WHAT TO DO IF YOU SMELL GAS:
• Do not light any appliance.

• Do not touch any electrical switch; do not

Use any phone in your building.

• Immediately call your gas supplier from a

neighbor’s phone. Follow your gas supplier's

instructions.

• If your gas supplier cannot be reached, call

the fire department.

Installation and service must be performed by a quali-

fied installer, service agency or the gas supplier

.

POUR VOTRE SÉCURITÉ: Ne pas entreposer ni utiliser

d’essence ni d’autre vapeurs ou liquides inflammables dans

le voisinage de cet appareil ou de tout autre appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez une odeur

de gaz:
• Ne pas tenter d’allumer d’appareil.

• Ne touchez à aucun interrupteur. Ne pas vous servir

des téléphones se trouvant dans le batiment où vous

vous trouvez.

• Evacuez la piéce, le bâtiment ou la zone.

• Appelez immédiatement votre fournisseur de gaz depuis

un voisin. Suivez les instructions du fournisseur.

• Si vous ne pouvez rejoindre le fournisseur de gaz,

appelez le service dos incendies.
L’installation et service doit être exécuté par un qualifié instal-

leur, agence de service ou le fournisseur de gaz.

WARNING: If the information in this manual is not

followed exactly, a fire or explosion may result

causing property damage, personal injury or loss

of life.

AVERTISSEMENT: Assurez-vous de bien suivre les

instructions donné dans cette notice pour réduire au

minimum le risque d’incendie ou pour éviter tout dom-

mage matériel, toute blessure ou la mort.

Models: EDVI25, EDVI30 & EDVI35

US

P/N 775,157M Rev. J, 12/2007

WARNINGS

• Hot! Do not touch! The glass and surfaces of this appliance will be hot during operation and will

retain heat for a while after shutting off the appliance. Severe burns may result.

• Carefully supervise children in the same room as appliance.

• If small children are present in the home, it is recommended that this appliance be fitted with a

screen door or screen panel kit. See

Page 14

for ordering information.

• Suitable for installation into masonry or factory built fireplaces.

•

Lennox™ gas-burning appliances are designed for use as a supplemental heater. They are not intended for

continuous use as a primary heat source.

A French manual is available upon request. Order P/N 775,157CF.

Ce manuel d’installation est disponible en francais, simplement

en faire la demande. Numéro de la pièce 775,157CF.

Installer: Leave This Manual With The Appliance.

Consumer: Retain This Manual For Future Reference.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 3 - INTRODUCTION; Exhaust: Use 3” diameter UL1777 listed; GENERAL INFORMATION; TABLE OF CONTENTS; CONGRATULATIONS ON THE PURCHASE OF YOUR NEW GAS APPLIANCE MANU-; that will ensure years of trouble-free warmth and pleasure.; Table 1; It is imperative that the control compart-; Table 2 shows the units' gas orifice size for; Table 2; Tables 3 and 4; Table 3

3 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE INTRODUCTION The Insert models covered in this manual are Direct-Vent sealed combustion gas heaters designed for residential application for install ion into an existing masonry or factory built solid-fuel fireplace. The required liners for the a...

Page 4 - IMPORTANT; Keep your house well ventilated; Lighting Millivolt Appliances; Figure 4; CONTROL COMPARTMENT ACCESS; Figure 3; Variable Flame Height Adjustment; Figure 1; Figure 2; MODEL EDVI5; must be isolated; equal to; must be disconnected; greater

NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE 4 IMPORTANT Keep your house well ventilated during the curing process. The odor and haze emitted by the curing process can be quite noticeable and may set off a smoke detector. Lighting Millivolt Appliances To light millivolt appliances refer to th...

Page 5 - WARNING; O P E R AT I O N A N D C A R E O F Y O U R; MAINTENANCE; Page; CAUTION; Check Burner Flame Appearance; Glass Cleaning; Note: Clean glass after first two weeks of opera-; Servicing Blower; Refer to blower wiring diagram on; Procedure For; Figure 5; Remove 4 Screws; mounting screws and remove the blower; Figure 6; Remove screws around parimeter of

5 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE WARNING Turn off gas and electrical power before servicing the appliance. IMPORTANT Always verify proper operation after servicing. O P E R AT I O N A N D C A R E O F Y O U R APPLIANCE Appliance operation may be controlled through a remotely loca...

Other Lennox Models

All Lennox Other