Husqvarna 6522SL Manual — Free PDF Download

Page 2 - Safe Operation Practices for Walk-Behind Mowers; SAFETY RULES; IV. SAFE HANDLING OF GASOLINE

2 WARNING: Battery posts, terminals and related ac ces so ries contain lead and lead compounds, chemicals known to the State of Cal i for nia to cause can cer and birth defects or oth er re pro duc tive harm. Wash hands after handling. WARNING: Engine exhaust, some of its con stit u ents, and certai...

Page 3 - PRODUCT SPECIFICATIONS; CUSTOMER RESPONSIBILITIES; TABLE OF CONTENTS

3 SAFETY RULES ......................................................... 2-3PRODUCT SPECIFICATIONS ....................................... 3CUSTOMER RESPONSIBILITIES................................. 3ASSEMBLY .................................................................... 4OPERATION ..............

Page 4 - ASSEMBLY; TO RE MOVE LAWN MOW ER FROM CAR TON; HOW TO SET UP YOUR LAWN MOW ER; TO INSTALL ATTACHMENTS

4 ASSEMBLY Read these instructions and this man u al in its entirety before you attempt to assemble or operate your new lawn mow er. IMPORTANT: THIS LAWN MOWER IS SHIPPED WITH- OUT OIL OR GASOLINE IN THE ENGINE. Your new lawn mower has been as sem bled at the factory with the ex cep tion of those pa...

Page 5 - KNOW YOUR LAWN MOWER; MEETS CPSC SAFETY REQUIREMENTS; OPERATION

5 KNOW YOUR LAWN MOWER READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR LAWN MOWER. Compare the illustrations with your lawn mower to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. MEETS CPSC SAFETY REQUIREMENTS Our r...

Page 6 - TO CONVERT MOWER; HOW TO USE YOUR LAWN MOWER; ENGINE SPEED

6 FIG. 4 LEVER BACKWARD TO LOWER MOWER LEVER FORWARD TO RAISE MOWER PLATE TAB LEVER TO CONVERT MOWER Your lawn mower was shipped ready to be used as a mulcher. To convert to bagging or discharging: REAR BAGGING (See Fig. 5)• Open rear door and remove mulcher plug. Store mulcher plug in a safe place....

Page 7 - BEFORE STARTING ENGINE

7 OPERATION BEFORE STARTING ENGINE ADD OIL (See Fig. 8) Your lawnmower is shipped without oil in the engine. For type and grade of oil to use, see “EN GINE” in the Maintenance section of this manual. CAUTION: DO NOT overfi ll engine with oil, or it will smoke on startup. 1. Be sure lawnmower is leve...

Page 8 - TO STOP ENGINE

8 MOWING TIPS CAUTION: Do not use de-thatcher blade attachments on your mower. Such at-tachments are hazardous, will damage your mower and could void your warranty. • Under certain conditions, such as very tall grass, it may be necessary to raise the height of cut to reduce pushing effort and to kee...

Page 9 - MAINTENANCE; LUBRICATION CHART; BEFORE EACH USE

9 Check for Loose FastenersClean / Inspect Grass Catcher *Check TiresCheck Drive Wheels ***Clean Lawn Mower ****Clean under Drive Cover ***Check Drive Belt / Pulleys ***Check / Sharpen / Replace BladeLubricationClean and Recharge Battery ** Check Engine Oil levelChange Engine OilClean Air FilterInsp...

Page 10 - LAWN MOWER; TIRES; GEAR CASE

10 LAWN MOWER Always observe safety rules when performing main te nance. TIRES • Keep tires free of gasoline, oil, or insect control chem- i cals which can harm rubber. • Avoid stumps, stones, deep ruts, sharp objects and other hazards that may cause tire damage. DRIVE WHEELS Check front drive wheel...

Page 11 - LUBRICATION; CLEANING; CLEAN UNDER DRIVE COVER

11 TO CLEAN AIR FILTER1. Loosen screw and tilt cover to re move. 2. Carefully remove cartridge. 3. Clean by gently tapping on a fl at surface. If very dirty, replace car tridge. CAUTION: Pe tro leum solvents, such as ker o sene, are not to be used to clean car tridge. They may cause de te ri o ra ti...

Page 12 - TO ADJUST CUTTING HEIGHT; SERVICE AND ADJUSTMENTS

12 MOWING POSITION MOWING POSITION HIGH POSITION LOW POSITION HANDLE BRACKET HAIRPIN COTTER MOUNTING PIN FIG. 15 LAWN MOWER TO ADJUST CUTTING HEIGHT See “TO ADJUST CUTTING HEIGHT” in the Operation section of this manual. REAR DEFLECTOR The rear defl ector, attached between the rear wheels of your mo...

Page 14 - FUEL SYSTEM; STORAGE; CYLINDER; OTHER

14 ENGINE FUEL SYSTEM IMPORTANT: IT IS IMPORTANT TO PREVENT GUM DEPOSITS FROM FORMING IN ESSENTIAL FUEL SYSTEM PARTS SUCH AS CARBURETOR, FUEL FILTER, FUEL HOSE, OR TANK DURING STORAGE. ALCOHOL BLENDED FUELS (CALLED GASOHOL OR USING ETHANOL OR METHANOL) CAN ATTRACT MOISTURE WHICH LEADS TO SEPARATION ...

Page 15 - TROUBLESHOOTING POINTS

15 Does not start 1. Dirty air fi lter. 1. Clean/replace air fi lter. 2. Out of fuel. 2. Fill fuel tank. 3. Stale fuel. 3. Empty fuel tank and refi ll tank with fresh, clean gasoline. 4. Water in fuel. 4. Empty fuel tank and refi ll tank with fresh, clean gasoline. 5. Spark plug wire is disconnected...