Huffy AWLH4030 - Manual

1

05/03

P/N

214945B

WARNING

FAILURE TO FOLLOW THESE WARNINGS MAY RESULT

IN SERIOUS INJURY AND/OR PROPERTY DAMAGE.

Owner must ensure that all players know and follow

these rules for safe operation of the system.

• DO NOT HANG on the rim or any part of the system

including backboard, support braces or net.

• During play, especially when performing dunk type

activities, keep player's face away from the backboard, rim
and net. Serious injury could occur if teeth/face come in
contact with backboard, rim or net.

• Do not slide, climb, shake or play on base and/or pole.
• After assembly is complete, fill system completely with

water or sand and stake to the ground. Never leave system
in an upright position without filling base with weight, as
system may tip over causing injuries.

• When adjusting height or moving system, keep hands and

fingers away from moving parts.

• Do not allow children to move or adjust system.
• During play, do not wear jewelry (rings, watches, necklaces,

etc.). Objects may entangle in net.

• Surface beneath the base must be smooth and free of

gravel or other sharp objects. Punctures cause leakage and
could cause system to tip over.

• Keep organic material away from pole base. Grass, litter,

etc. could cause corrosion and/or deterioration.

• Check pole system for signs of corrosion (rust, pitting,

chipping) and repaint with exterior enamel paint. If rust has
penetrated through the steel anywhere, replace pole
immediately.

• Check system before each use for proper ballast, loose

hardware, excessive wear and signs corrosion and repair
before use.

• Check system before each use for instability.
• Do not use system during windy and/or severe weather

conditions; system may tip over. Place system in the
storage position and/or in an area protected from the wind
and free from personal property and/or overhead wires.

• Never play on damaged equipment.
• See instruction manual for proper installation and

maintenance.

• When moving system, use caution to keep mechanism from

shifting.

• Keep pole top covered with cap at all times.
• Do not allow water in tank to freeze. During sub-freezing

weather add non-toxic antifreeze, sand or empty tank
completely and store. (Do not use salt.)

• Use extreme caution if placing system on sloped surface.

System may tip over more easily.

201241

2/99

In the U.S.:1-800-558-5234 and Canada: 1-800-284-8339

Toll-Free Customer Service Number for U.S:

1-800-558-5234,

For Canada:

1-800-284-8339

, For Europe:

00 800 555 85234

(Sweden:

009 555 85234

),

For Australia:

1-800-632-792 -

Internet Address:

http://www.huffysports.com

Most injuries are caused by misuse and/or not following instructions.

Use caution when using this system.

• If using a ladder during assembly, use extreme caution.
• Two (2) people are recommended for this operation.
• Check base regularly for leakage. Slow leaks could cause system to

tip over unexpectedly.

• Seat the pole sections properly (if applicable). Failure to do so could

allow the pole sections to separate during play and/or transport of the
system.

• Climate, corrosion or misuse could result in system failure.
• Minimum operational height is 6'6" (1.98 m) to the bottom of

backboard.

• This equipment is intended for home recreational use only and NOT

excessive competitive play.

• Read and understand the warning label affixed to pole. Label is

shown on page 1.

• The life of your basketball pole depends on many conditions. The

climate, placement of the pole, the location of the pole, exposure to
corrosives such as pesticides, herbicides or salts are all important.

• If technical assistance is required, contact Huffy Sports.
• Adult supervision is recommended when adjusting height.

FAILURE TO FOLLOW THESE SAFETY INSTRUCTIONS MAY

RESULT IN SERIOUS INJURY, PROPERTY DAMAGE AND WILL

VOID WARRANTY.

Owner must ensure that all players know and

follow these rules for safe operation of the system.

To ensure safety, do not attempt to assemble this system without
following the instructions carefully. Proper and complete assembly,
use and supervision is essential for proper operation and to reduce
the risk of accident or injury. A high probability of serious injury
exists if this system is not installed, maintained, and operated
properly. Check entire box and inside all packing material for parts
and/or additional instructional material. Before beginning
assembly, read the instructions and identify parts using the
hardware identifier and parts list in this document

.

For more information on assembly, placement, proper use and
maintenance, visit The American Basketball Council website at
http://www.smarthoops.com.

SAFETY INSTRUCTIONS

36

REQUIRED TOOLS AND

MATERIALS:

• Two People
• Tape Measure
• Wood Board (Scrap)
• Wrenches: (Two of Each) 7/16”,

1/2”, 9/16”, 3/4” or Large and
Small Adjustable Wrenches

• Sawhorse or Support Table
• Garden Hose or Sand (300 lb.)

(136 kg)

• Hammer
• Tape
• Phillips Screwdriver
• 1/2” & 9/16” Extended Deep

Socket w/ Extension
Recommended

©
COPYRIGHT

2002

by
HUFFY

SPORTS

WRITE IN YOUR MODEL NUMBER:

___________

Customer Service Center • N53 W24700 South Corporate Circle • Sussex, WI 53089 • U.S.A.

A Huffy Company

Portable Basketball System with Elevator-

Owners Manual

I M P O R T A N T !

In U.S. and Canada only:

Have questions?...don’t go back to the store!

We appreciate your purchasing one of our many fine products. We are sure that you will be very satisfied with your selection. Although great care and effort have been taken, occasionally problems may occur. To

ensure prompt and correct handling of any problems, or to answer any questions, please contact our Toll-Free Customer Service Number listed below. Service will be quicker if you have your Model Number

(found on carton) and assembly instructions ready when calling. PLEASE WRITE YOUR MODEL NUMBER IN THE SPACE PROVIDED ABOVE.

NOTICE TO ASSEMBLERS

ALL

Huffy Sports basketball Systems,

including those used for

DISPLAYS

,

MUST

be assembled and ballasted with

sand or water according to instructions.
Failure to follow instructions could result
in

SERIOUS INJURY

. It is

NOT

acceptable to devise a makeshift weight
system.

The NBA and individual NBA member team identifications reproduced on this product are
trademarks and copyrighted designs, and/or other forms of intellectual property, that are the
exclusive property of NBA Properties, Inc. and the respective NBA member teams and may not
be used, in whole or in part, without the written consent of NBA Properties, Inc.

WRITE IN YOUR SERIAL

NUMBER:

___________