GE ZMC1090BV Manual - Free PDF Download

Page 2 - CAUTION; Consumer Information Ser vice at; Design Information; Contents

Before you begin—Read these instructions completely and carefully.IMPORTANT: Save these instructions for local inspector’s use. IMPORTANT: OBSERVE ALL GOVERNING CODES AND ORDINANCES.NOTE TO INSTALLER: Be sure to leave these instructions with the Consumer.NOTE TO CONSUMER: Keep these instructions wit...

Page 3 - Double oven; B u i l t - I n O v e n s; cated black or glistening white.; Single oven

Modelsavailable ZEK757WW White double convection oven ZEK757BW Black double convection oven ZEK737WW White single convection oven ZEK737BW Black single convection oven Dimensionsand clearances Double oven A - 20 " (508 mm) B - 23 -1/2" (597 mm) C - 26 -13/16" (681 mm) D - 50 -3/4" (1...

Page 4 - Whenever

Cabinet styleoptions Design Information B u i l t - I n O v e n s Front Framed Partial Overlay Door Front Framed Full Overlay Door Frameless Monogram ovens are installed directly into a wall orwall oven cabinetr y, 27" minimum width. The frontsur face of the ovens will be nearly flush with sur-r...

Page 5 - • Install a single oven alone or below any Monogram

Installationoptions Single Oven Installed Below A ZMC1090WV/ZMC1090BV Microwave Oven Single Oven Installed Below A ZEM200WV Microwave Oven Design Information B u i l t - I n O v e n s • Install a single oven alone or below any Monogram microwave oven. • For an integrated look, install a single oven ...

Page 6 - Cabinetr y; upon user preference.

Cabinetr y B u i l t - I n O v e n s • 2" x 4" lumber for runners • Saw • Level • Phillips screwdriver and wood screws or other hardware for installing runners or shelf to support oven. Ovens are designed for installation in a cabinet 27" min. wide. • Cut 2" x 4" runners of appro...

Page 8 - Installation in a recessed

Recessedinstallation:Front framedcabinetswithinset doorsand drawers Cabinetr y B u i l t - I n O v e n s Front FramedInset Flush Door 8 Rough opening for single and double ovens:• Depth 24-1/2" min. from inside back to front of cabinet frame.– If the cabinet is not 24-1/2" deep, the back of ...

Page 9 - – Frameless cabinet inside width may be up to

Framelesscabinets Frameless Use the information in this dimension drawing fortypical frameless cabinets. The front face of the ovenwill be flush with cabinetr y doors or drawers. Whenever possible, order 27" frameless cabinet withthe cutout sized to fit the oven. If you are using stockcabinets, ...

Page 12 - Cabinetr y Modification Suggestions

Provideoven supports The ovens may be supported by either a solid bottomor 2 x 4 r unners.• The support must be level and rigidly mounted, flush with the bottom edge of the cutout. • The entire weight of the oven is supported by 2 x 4 r unners or the solid floor and must be capable ofsupporting 200 ...

Page 13 - Cabinetr y Modifications Suggestions

Determineneed forfiller panels Filler panelconstruction If the cabinets being used have an opening that istaller than the maximum dimensions indicated forthe ovens, filler panels can be made to fill the gaps.Stock filler strips are usually available or for largergaps order an extra drawer front. Dra...

Page 16 - Installation; • Outlet box; Do not use an extension

Installation B u i l t - I n O v e n s 16 • Outlet box • Electrical cable—3-conductor or 4-conductor wire—as required by local codes • Flexible power cable connector • Electrician’s pliers Note: Do not use an extension cord with these appliances. Monogram built-in single and double ovens requirea se...

Page 17 - The lower front trim is packed separately and should not be; • Secure lower front trim to the front frame with 3; It is best that 2 people; • Insert oven 3/4 way into cabinet opening. Continue

Finalizeinstallation Caution: Do not lift oven or oven door by handle. Door glassbreakage or handle damage mayoccur. Glass surface of door face extends beyond door frame oneach side; be careful not toimpact this exposed glass. Caution: When door is removed and hinge arms are atstop position, do not ...

Page 18 - • Secure oven in place with screws furnished. (Use; Failure to do so could

Installation B u i l t - I n O v e n s 18 • Slide oven into cabinet opening.• Drill 3/32" pilot holes through mounting holes in oven front frame. (2 screw holes for single ovens,4 screw holes for double ovens.) • Secure oven in place with screws furnished. (Use dr ywall screws if cabinet is part...

Page 19 - B u i l t - I n O v e n s; Aluminum house wiring

Installation B u i l t - I n O v e n s 19 • When connecting to a 4-conductor branch circuit: – Connect oven red lead to branch circuit red lead.– Connect oven black lead to branch circuit black lead. – Break connection between oven white lead and oven bare copper conductor. – Connect oven white lead...