GE JVM3160DF5BB Installation Manual

Page 2 - Installation Instructions; CONTENTS; General information

2 Installation Instructions Outside Back Exhaust .......................... 21-24 Installation Overview .......................... 21 Preparing Rear Wall for Outside Back Exhaust ........................ 21 Attach Mounting Plate to Wall ...... 21, 22 Preparation of Top Cabinet ................ 22 Ad...

Page 3 - IMPORTANT SAFETY INSTRUCTIONS; ELECTRICAL REQUIREMENTS; WARNING; CAUTION

3 A qualified electrician must perform a ground continuity check on the wall receptacle before beginning the installation to ensure that the outlet box is properly grounded. If not properly grounded, or if the wall receptacle does not meet electrical requirements noted (under ELECTRICAL REQUIREMENTS...

Page 5 - HOOD EXHAUST

5 Installation Instructions HOOD EXHAUST NOTE: Read these next two pages only if you plan to vent your exhaust to the outside. If you plan to recirculate the air back into the room, proceed to page 6. Below are examples of Outside Top Exhaust and Outside Back Exhaust duct system layouts. Note the po...

Page 6 - Maximum duct length:

6 Installation Instructions EQUIVALENT NUMBER EQUIVALENT DUCT PIECES LENGTH x USED = LENGTH Rectangular-to-Round 5 Ft. x ( ) = Ft. Transition Adaptor* Wall Cap 40 Ft. x ( ) = Ft. 90° Elbow 10 Ft. x ( ) = Ft. 45° Elbow 5 Ft. x ( ) = Ft. 90° Elbow 25 Ft. x ( ) = Ft. 45° Elbow 5 Ft. x ( ) = Ft. Roof Ca...

Page 7 - ADDITIONAL PARTS; PART; INSTALLATION; PARTS INCLUDED; HARDWARE PACKET

7 PART QUANTITY Top Cabinet Template 1 Rear Wall Template 1 Installation Instructions and Owners Manual 1 1 Grease Filters 2 Exhaust Adaptor 1 Tray 1 Turntable Ring 1 Charcoal Filter (on some models) 1* Installation Instructions PARTS INCLUDED INSTALLATION INSTRUCTIONSOWNERS MANUAL ADDITIONAL PARTS ...

Page 9 - FINDING THE WALL STUDS; PLACEMENT OF THE MOUNTING PLATE

9 Installation Instructions Find the studs, using one of the following methods: A. Stud finder. OR B. Use a hammer to tap lightly across the mounting surface to find a solid sound. This will indicate a stud location. After locating the stud(s), find the center by probing the wall with a small nail t...

Page 10 - DETERMINING MOUNTING PLATE LOCATION UNDER YOUR CABINET; Plate Position – flat bottom cabinet

10 Installation Instructions DETERMINING MOUNTING PLATE LOCATION UNDER YOUR CABINET C Your cabinets may have decorative trim that interferes with the microwave oven installation. You may need to remove the decorative trim to install the microwave oven properly and to make it level. THE MICROWAVE OVE...

Page 11 - ALIGNING THE MOUNTING PLATE; Set the mounting plate aside.

11 Installation Instructions ALIGNING THE MOUNTING PLATE Wear gloves to avoid cutting fingers on sharp edges. Draw a vertical line on the wall at the center of the 30 s wide space. Use the mounting plate as the template for the rear wall. Place the mounting plate on the wall, making sure that the ta...

Page 13 - INSTALLATION OVERVIEW

13 Installation Instructions USE TOP CABINET TEMPLATE FOR PREPARATION OF TOP CABINET A2 RECIRCULATING (Non-Vented Ductless) Popcorn Convenie nce Cook ing Express C ook Potato StartPause Cancel Off Beverag e Reheat Set Clock Turntabl e Surface Light Vent Add 30 Sec. PowerLevel 0 8 5 2 7 4 1 9 6 3 Coo...

Page 14 - ADJUST BLOWER MOTOR

14 Installation Instructions ADJUST BLOWER MOTOR A3 Remove the screws holding the blower unit and the screws securing the blower plate. Remove the blower plate from the outer case by sliding it toward the back of the microwave and pulling up. 1 Blower Plate Blower Motor Screws Blower Motor Screw 2 C...

Page 15 - A5 MOUNT THE MICROWAVE OVEN; INSTALLING THE

15 Installation Instructions A5 MOUNT THE MICROWAVE OVEN NOTE: When mounting the microwave, thread power cord through hole in bottom of top cabinet. Keep it tight throughout Steps 1–3. Do not pinch cord or lift microwave oven by pulling cord. Lift microwave, tilt it forward, and hook slots at back b...

Page 17 - OUTSIDE TOP EXHAUST; ATTACH THE MOUNTING

17 OUTSIDE TOP EXHAUST (Vertical Duct) Insert the toggle wings into the holes in the wall and place the mounting plate against the wall. NOTE: Before tightening toggle bolts and wood screw, make sure the tabs on the mounting plate touch the bottom of the cabinet when pushed flush against the wall an...

Page 19 - MOUNT THE MICROWAVE OVEN

19 Installation Instructions MOUNT THE MICROWAVE OVEN B5 CAUTION To avoid the risk of personal injury (back injury or other injuries due to excessive weight of the microwave) or property damage, you will need two people to install this microwave. IMPORTANT: Do not grip or use handle during installat...

Page 20 - CONNECTING DUCTWORK

20 CONNECTING DUCTWORK 3 Popcor n Conv enien ce Co oking Expre ss Co ok Potat o StartPause Canc el Off Bever age Rehea t Set Clock Turnt able Surfa ce Light Vent Add 30 Se c. Powe r Level 0 8 5 2 7 4 1 9 6 3 CookTime Defro st Weig ht/Tim e Timer On/O ff Cabinet Front Cabinet Bottom Shelf Filler Bloc...

Page 21 - OUTSIDE BACK EXHAUST

21 OUTSIDE BACK EXHAUST (Horizontal Duct) PREPARING THE REAR WALL FOR OUTSIDE BACK EXHAUST C1 Popcorn Convenience Cooking Express Coo k Potato StartPause Cancel Off Beverage Reheat Set Clock Turntable Surface Light Vent Add 30 Sec. Power Level 0 8 5 2 7 4 1 9 6 3 CookTime Defrost Weight/Tim e Timer ...

Page 24 - MOUNT THE MICROWAVE

24 Popcor n Conv enien ce Co oking Expre ss Co ok Potato StartPause Canc el Off Bever age Rehea t Set Clock Turnt able Surfa ce Light Vent Add 30 Se c. Powe r Level 0 8 5 2 7 4 1 9 6 3 CookTime Defro st Weig ht/Tim e TimerOn/O ff Installation Instructions MOUNT THE MICROWAVE OVEN (cont.) C5 5 Cabine...

Page 25 - BEFORE YOU USE YOUR MICROWAVE OVEN

25 KEEP INSTALLATION INSTRUCTIONS FOR THE LOCAL INSPECTOR’S USE. 120 V Models: Plug power cord into a dedicated 15- to 20-amp electrical outlet. 7 Read the Owner’s Manual. 6 Replace house fuse or turn breaker back on. 4 Remove all packing material from the microwave oven. 2 Make sure the microwave o...