Ford D-213-20 - Manual

Ford D-213-20

Ford D-213-20 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
Page: / 28

Table of Contents:

  • Page 2 – FOREWORD; © 2003 VORTECH ENGINEERING, LLC; ii
  • Page 3 – iii; Table Of Contents
  • Page 4 – iv; DISCLAIMER; * Only applies to vehicles equipped with automatic transmissions.; NOTE: This listing is provided solely for informational purposes.
  • Page 5 – factory ECM calibration.; IMPORTANT NOTES; to an improperly installed/mishandled ECM module or ECM.
  • Page 6 – The engine must have stock compression ratio.; TOOL & SUPPLY REQUIREMENTS; Installation Instructions
  • Page 7 – vii; PARTS LIST
  • Page 8 – viii
  • Page 9 – COMPONENT REMOVAL AND PREPARATION; Remove the passenger side front kick panel from
  • Page 10 – DRIVER’S
  • Page 11 – OIL DRAIN; To provide a proper oil drain for the supercharger it is; OIL PAN; • Using a light amount of oil on the threads for lubrication,; x #4 fitting into the threaded; • Reassemble the oil filter base and bracket and secure
  • Page 12 – FRONT VIEW; VIEW FROM PASSENGER SIDE; NOTE: This method of rolling over the lip of the
  • Page 13 – CRANKSHAFT PULLEY/SUPERCHARGER DRIVE PULLEY; Remove the rubber inspection plug on the left rear of; NOTE: This process can be done with the fan
  • Page 14 – FUEL PUMP; NOTE: Due to the various fuel tank configurations and
  • Page 15 – FUEL PUMP RELAY; NOTE: Double check that all wires are con-; nected to their proper relay lug.
  • Page 16 – WIRE SUPPORT
  • Page 17 – NOTE: The use of blue Loctite is recommended
  • Page 18 – NOTE: The most forward mounting boss; mended for all idler bolts.
  • Page 19 – H. Install the supplied support strap between the back of; Attach the supplied power steering reservoir bracket; K. Extend the stock power steering return hose using
  • Page 20 – EGR CONTROL MOUNTING AND MAIN MOUNTING PLATE SUPPORT
  • Page 21 – FUEL MANAGEMENT UNIT
  • Page 22 – NOTE: The oil drain line must be routed in a
  • Page 23 – M. Connect the oil drain hose down to the oil pan tube previ-
  • Page 25 – MASS AIR FLOW SENSOR REMOVAL, MOUNTING AND ASSEMBLY; AIR TEMPERATURE
  • Page 27 – PLEASE TAKE SPECIAL NOTE: Operating the vehicle; ceived back from Vortech with the ECM mod-
Loading the manual

P/N: 4FM020-010
© 2003 Vortech Engineering, LLC
All Rights Reserved. Intl. Copr. Secured
20OCT03

v3.1 4.6/5.4Exped/Nav(4FM v3.1)

Ford 4.6/5.4 2V

F-150/F-250

Expedition/Navigator

1997-200

3 Model Y

ears

50 State Smog Legal per CARB EO #D-213-

20

Super

char

ger System

Installation Instructions

ENGINEERING, LLC

1650 PACIFIC AVENUE • CHANNEL ISLANDS, CA 93033-9901 • (805) 247-0226

FAX (805) 247-0669 • www.vortechsuperchargers.com • M-F 8:00 AM - 4:30 PM PST

®

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - FOREWORD; © 2003 VORTECH ENGINEERING, LLC; ii

P/N: 4FM020-010© 2003 Vortech Engineering, LLCAll Rights Reserved. Intl. Copr. Secured20OCT03 v3.1 4.6/5.4Exped/Nav(4FM v3.1) Proper installation of this supercharger kit requires general automotive mechanicknowledge and experience. Please browse through each step of this instruction manualprior to ...

Page 3 - iii; Table Of Contents

P/N: 4FM020-010 © 2003 Vortech Engineering, LLC All Rights Reserved. Intl. Copr. Secured 20OCT03 v3.1 4.6/5.4Exped/Nav(4FM v3.1) iii Table Of Contents FOREWORD ..................................................................................................................................... ii TAB...

Page 4 - iv; DISCLAIMER; * Only applies to vehicles equipped with automatic transmissions.; NOTE: This listing is provided solely for informational purposes.

P/N: 4FM020-010© 2003 Vortech Engineering, LLCAll Rights Reserved. Intl. Copr. Secured20OCT03 v3.1 4.6/5.4Exped/Nav(4FM v3.1) iv SUPERCHARGED F-150/F-250/EXPEDITION/NAVIGATOR DISCLAIMER Towing, racing performance driving, hard accelerations, and other heavy/severe duty drivingactivities place extra ...

Other Ford Models