England's Stove Works PELLET STOVES - Manual
England's Stove Works PELLET STOVES – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – A letter from our Technical Support department:; IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN IT TO THE DEALER.
- Page 3 – If you see smoke coming out of your unit into the room; If you see smoke coming out of your unit into the room and; Remain calm
- Page 4 – IMPORTANT INFORMATION; Read and comply with the instructions in this manual.; Your stove is designed to burn Premium Wood Pellets only.; Be sure your pellets are not damp or wet. Keep sawdust out of the unit.
- Page 5 – Basement Installation:; UNIT PREPARATION; We highly recommend a surge
- Page 6 – Visit our web site at
- Page 7 – FLUE SYSTEM; through combustible walls and ceilings.; Be sure to check local codes in your area.; NOTE: See the installation drawing later in this manual (; Pellet Vent Pipe; Do not; Do not install a flue damper of any kind in this
- Page 8 – Illustration 1; in this manual. It is
- Page 9 – Freestanding Pellet Installation; Outside Air is mandatory for proper safe operation.; FLOOR AND WALL PROTECTION; Floor Protection
- Page 10 – OPERATING INSTRUCTIONS; CAUTION: DO NOT OPERATE WITH THE DOOR OPEN.; Illustration 2; This stove is using solid fuel and will not restart automatically.
- Page 12 – DAILY OPERATION
- Page 13 – especially important; burn-back and can damage your unit and/or void your warranty.; ASH REMOVAL AND DISPOSAL; Daily Ash Maintenance; Twice each week: Shut the unit down by pressing; Illustration 6; remove any ash build-
- Page 14 – Monthly Ash Removal; behind the burn pot (refer to the; pellets are fed into the burn pot from the Bottom Auger Tube (see
- Page 15 – MAINTENANCE; CAUTION: UNPLUG THE UNIT PRIOR TO ANY SERVICE WORK!; on the flat side of the gear shaft; Auger Bearings and Auger Shafts
- Page 17 – Control Board; not; Caution
- Page 18 – Illustration 4 PU-CB04; CAUTION: Moving Parts May Cause Injury.; IMPORTANT SAFETY NOTE:; If the unit or chimney connector pipe “glows” red (or
- Page 19 – Adjusting your Hopper Lid Latches; wrench and a 1⁄2 inch socket.; Important: Hopper Lid Latches must be checked periodically and; Illustration 5
- Page 20 – ACCESSORY ITEMS; unit cool down before adding any accessories.; Thermostats; Accessories can be ordered from the factory at:
- Page 21 – REPLACEMENT PARTS, ACCESSORIES AND OPTIONS; with
- Page 22 – Dimensions of your pellet unit:; Pellet Stove – Exploded View Diagram
- Page 23 – TROUBLE-SHOOTING GUIDE; Problem
- Page 24 – from the date of purchase.; Conditions and Exclusions:; WARRANTY IS NOT TRANSFERABLE
- Page 25 – WARRANTY REGISTRATION for England’s Stove Works; DEALER INFORMATION; How did you first hear about our product? (please check one); Technical Support Department
INSTALLATION & OPERATION MANUAL
MODEL NUMBERS:
25-PDV
55-SHP22
55-TRP22
25-PDVE
55-SHP22E
55-TRP22E
Thank you for purchasing this product from a fine line of heating equipment.
We wish you many years of safe heating pleasure with your new heating appliance.
Save These Instructions.
IMPORTANT: IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN IT TO
THE DEALER. CONTACT TECHNICAL SUPPORT @ 1-800-245-6489.
Mobile Home Use:
These freestanding pellet units are approved for mobile home or doublewide installation with
outside combustion air hook-up. See “Flue System” section of manual.
Mobile home installation should be in accordance with the Manufactured Home and Safety
Standard (HUD), CFR 3280, Part 24.
WARNING: Do Not Install in Sleeping Room
CAUTION:
The structural integrity of the mobile home floor, wall and ceiling/roof must
be maintained.
Please Note the Following Precautionary Statements:
NOTE: WE DO NOT RECOMMEND PELLET STOVES AS YOUR ONLY SOURCE OF HEAT.
England’s Stove Works highly recommends the use of smoke detectors and
Carbon Monoxide detectors with any hearth product, including this unit. Follow all
manufacturer’s instructions when using smoke or Carbon Monoxide detectors.
CAUTION: Please read this entire manual before installation and use of this pellet
fuel burning room heater.
Keep children, furniture, fixtures, and all combustible materials away
from any heating appliance. Refer to this owner’s manual for all
clearances to combustible materials.
WARNING: USE OF OUTSIDE AIR IS MANDATORY WITH THIS UNIT
.
DO NOT OPERATE UNIT WITH HOPPER OPEN. LID MUST BE SHUT AND TIGHTLY SECURED.
DO NOT OPERATE WITH DOOR OPEN
SAFETY NOTICE
FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN PROPERTY DAMAGE,
BODILY INJURY OR EVEN DEATH. FOR YOUR SAFETY AND PROTECTION, FOLLOW ALL
THE INSTALLATION INSTRUCTIONS. CONTACT YOUR LOCAL BUILDING OR FIRE
OFFICIALS FOR RESTRICTIONS AND INSTALLATION INSPECTION REQUIREMENTS
(INCLUDING PERMITS) IN YOUR AREA.
Questions? Need Parts or Options?
Rev.
1/07
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
A letter from our Technical Support department: Thank you for purchasing this fine product from England’s Stove Works! England's Stove Works was started, and is still owned by, a family that believes strongly in a "Do It Yourself" spirit – that’s one reason you found this product at your fav...
BEFORE RE-STARTING YOUR UNIT Every time before pressing “ON” to start your unit – Be sure to remove all ashes (burnt or partially burnt) from your burn pot area! Wearing protective gloves and with the unit cool, remove the Wear Plate and dump the ashes, ensuring that the air holes are clear from deb...
IMPORTANT INFORMATION 1. Check local installation codes for your area. Call your Homeowner’s Insurance representative for inspection of your stove’s installation. 2. Read and comply with the instructions in this manual. 3. This unit should be tested (dry run) before loading pellets for 20 minutes. T...
