England's Stove Works 55-TRP22 - Manual
England's Stove Works 55-TRP22 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – A letter from our Technical Support department:; IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN IT TO THE DEALER.
- Page 3 – Your stove is designed to burn Premium Pellets.; IMPORTANT INFORMATION
- Page 4 – and save them for future reference.; Basement Installation:; We recommend basement installation be performed only by a; vertical rise before terminating your vent pipe.; UNIT PREPARATION; Important: Also check
- Page 5 – cutout notch facing upwards.
- Page 6 – FLUE SYSTEM; Be sure to check local codes in your area.; Pellet Vent Pipe; Do not; Do not install a flue damper of any kind in this system, and
- Page 8 – FLOOR AND WALL PROTECTION; Floor Protection; Outside Air is mandatory for proper safe operation.; Illustration 1; Freestanding Pellet Installation
- Page 9 – OPERATING INSTRUCTIONS; CAUTION: DO NOT OPERATE WITH THE DOOR OPEN.; “Heat Range”; touch pad will; Horizontal Feed System; your outlet (we do recommend a surge protector with our unit).; Before; your first fire; dry run your unit (with no pellets in the hopper); ,” which means the unit failed to start normally. After this code is; Manually Starting Your Unit
- Page 10 – This will allow any smoke; S D
- Page 11 – DAILY OPERATION; closing. Be sure to close and latch hopper
- Page 12 – ASH REMOVAL AND DISPOSAL; schedule below, or more often if needed.; Twice each week: Shut the unit down by; and; remove any ash; Monthly Ash Removal; behind the burn pot (refer to; burn-back and can damage your unit and/or void your warranty.; Bottom Auger Tube
- Page 13 – Annual Cleaning; MAINTENANCE; CAUTION: UNPLUG THE UNIT PRIOR TO ANY SERVICE WORK!; SEE EXPLODED DIAGRAM (ILLUSTRATION 4) FOR PARTS REFERENCE; Rear Panel Removal; ” head) set bolt in front; Auger Bearings and Auger Shafts
- Page 15 – Control Board; not
- Page 16 – Illustration 2b; gravity air inlet into any building.; If the unit or chimney connector pipe “glows” red (or
- Page 17 – ACCESSORY ITEMS; the unit cool down before adding any accessories.; Thermostats; Accessories can be ordered from the factory at:
- Page 18 – REPLACEMENT PARTS, ACCESSORIES AND OPTIONS; with
- Page 19 – Illustration 4; Pellet Stove – Exploded View Diagram
- Page 21 – TROUBLE-SHOOTING GUIDE; Problem
- Page 22 – The manufacturer extends the following warranties:; Conditions and Exclusions:; WARRANTY IS NOT TRANSFERABLE
- Page 23 – WARRANTY REGISTRATION for England’s Stove Works; DEALER INFORMATION; How did you first hear about our product? (please check one); Customer Service Department
INSTALLATION & OPERATION MANUAL
MODEL NUMBERS:
25-PDV, 55-SHP22, and 55-TRP22
25-PDVE, 55-SHP22E, and 55-TRP22E
Thank you for purchasing this product from a fine line of heating equipment. We wish you many
years of safe heating pleasure with your new heating appliance.
Save These Instructions.
IMPORTANT: IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN IT TO
THE DEALER. CONTACT CUSTOMER SERVICE @ 1-800-245-6489.
Please Note the Following Precautionary Statements:
NOTE: WE DO NOT RECOMMEND PELLET STOVES AS YOUR ONLY SOURCE OF HEAT.
CAUTION: Please read this entire manual before installation and use of this
pellet fuel burning room heater.
Keep children, furniture, fixtures and all combustibles away from any heating appliance.
WARNING: USE OF OUTSIDE AIR IS MANDATORY WITH THIS UNIT
.
DO NOT OPERATE UNIT WITH HOPPER OPEN. LID MUST BE SHUT AND TIGHTLY SECURED.
DO NOT OPERATE WITH DOOR OPEN
SAFETY NOTICE
FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN PROPERTY DAMAGE,
BODILY INJURY OR EVEN DEATH. FOR YOUR SAFETY AND PROTECTION, FOLLOW ALL
THE INSTALLATION INSTRUCTIONS. CONTACT YOUR LOCAL BUILDING OR FIRE
OFFICIALS FOR RESTRICTIONS AND INSTALLATION INSPECTION REQUIREMENTS
(INCLUDING PERMITS) IN YOUR AREA.
Questions? Need Parts or Options?
www.englandsstoveworks.com
Rev. 10/05
England’s Stove Works highly recommends the use of smoke detectors and
Carbon Monoxide detectors with any hearth product, including this unit. Follow all
manufacturer’s instructions when using smoke or Carbon Monoxide detectors.
Mobile Home Use:
These freestanding pellet units are approved for mobile home or doublewide installation with
outside combustion air hook-up. See “Flue System” section of manual.
Mobile home installation should be in accordance with the Manufactured Home and Safety
Standard (HUD), CFR 3280, Part 24.
WARNING: Do Not Install in Sleeping Room
CAUTION:
The structural integrity of the mobile home floor, wall and ceiling/roof must
be maintained.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
A letter from our Technical Support department: Thank you for purchasing this fine product from England’s Stove Works! England's Stove Works was started, and is still owned by, a family that believes strongly in a "Do It Yourself" spirit – that’s one reason you found this product at your fav...
1. Check local installation codes for your area. Call your Homeowner’s Insurance representative for inspection of your stove’s installation. 2. Read and comply with the instructions in this manual. 3. This unit should be tested (dry run) before loading pellets for 20 minutes. The stove should automa...
13. This unit should be turned off and allowed to cool prior to cleaning. Any ashes should be kept in an airtight metal container and not disposed of until they are completely cooled. 14. Read the instructions thoroughly, including instructions concerning the digital control board, and save them for...
