England's Stove Works 49-TRC22 - Manual

England's Stove Works 49-TRC22

England's Stove Works 49-TRC22 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
Page: / 31

Table of Contents:

  • Page 2 – A letter from our Technical Support department:; IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN IT TO THE DEALER.
  • Page 3 – IMPORTANT INFORMATION; Read and comply with the instructions in this manual.
  • Page 4 – Basement Installation:; rise before terminating your vent pipe.
  • Page 5 – UNIT PREPARATION; Visit our web site at; IMPORTANT INFORMATION – READ BEFORE OPERATING
  • Page 6 – IMPORTANT: DO NOT BURN “TREATED” SEED CORN IN YOUR STOVE.; Seed corn; Burning
  • Page 7 – combustible shielding or guards may be required.
  • Page 8 – TIGHT! Follow the vent manufacturer’s installation instructions.; DO NOT CONNECT TO ANY AIR DISTRIBUTION DUCT OR SYSTEM.
  • Page 9 – BURNING SOLID FUELS; Seed corn is treated; WOOD PELLETS; due to foreign objects in the fuel supply.; SETTING THE STIRRER; Bodily Injury can occur!
  • Page 10 – FLUE SYSTEM; Be sure to check local codes in your area.; Corn Vent Pipe; Do not; Through the Wall
  • Page 11 – IMPORTANT SAFETY NOTE:
  • Page 12 – Outside Air is mandatory for proper safe operation.; Freestanding Corn/Pellet Installation; Floor Protection
  • Page 13 – OPERATING INSTRUCTIONS; CAUTION: DO NOT OPERATE WITH THE DOOR OPEN.; “Heat Range”; START- UP PROCEDURES; flammable liquid to start the fire.; after
  • Page 14 – Remove the stirrer shaft (; See Illustration 2; in the Heat Range; PELLET START-UP PROCEDURE; Illustration 2; To remove the stirrer for burning pellets; COLD; back
  • Page 15 – wait; ” indicates “No Error”; until the room air blower begins to operate.; This will allow; S D
  • Page 16 – DAILY OPERATION; NOTE: DO NOT TRY TO RESTART THE UNIT HOT
  • Page 17 – ASH REMOVAL AND DISPOSAL; Daily Ash Maintenance
  • Page 18 – MAINTENANCE; on the flat side of the gear shaft
  • Page 19 – you feel the auger lock.
  • Page 20 – Control Board; ) is a digital read-out board. This board offers a wide variety; Illustration 4; Recommended Heat Ranges:; CAUTION: Moving Parts May Cause Injury.
  • Page 21 – CIRCUIT BOARD FUNCTIONS; Illustration 5
  • Page 22 – ACCESSORY ITEMS; unit cool down before adding any accessories.; Thermostat; An external wall thermostat (such as our Part #
  • Page 23 – REPLACEMENT PARTS, ACCESSORIES AND OPTIONS; ITEM; (See Item numbers on Exploded Diagram for part location); Customer Service Department
  • Page 24 – Corn Stove – Exploded View Diagram
  • Page 25 – Adjusting your Hopper Lid Latch; wrench and a 1⁄2 inch socket.; Important: Hopper Lid Latch must be checked periodically and; Illustration 7
  • Page 26 – Illustration 9; DIRECTIONS FOR INSTALLATION OF; (Stove must be cooled and all ashes cleaned out); To install pedestal:
  • Page 27 – TROUBLE-SHOOTING GUIDE; Problem Cause Solution
  • Page 28 – PROBLEM; Flue or intake is restricted.; CAUSE: Firepot burns out; NOTE: Negative pressure in a home is a serious issue.
  • Page 29 – The manufacturer extends the following warranties:; covered for 1 year from the date of purchase.; Conditions and Exclusions:; NOTE; WARRANTY IS NOT TRANSFERABLE
  • Page 31 – WARRANTY REGISTRATION for England’s Stove Works; DEALER INFORMATION; How did you first hear about our product? (please check one); IMPORTANT NOTICE; Visit
Loading the manual

INSTALLATION & OPERATION MANUAL

MODEL NUMBERS: 10-CDV 49-TRC22 49-SHC22

Thank you for purchasing this product from a fine line of heating equipment.

We wish you many years of safe heating pleasure with your new heating appliance.

Save These Instructions.

IMPORTANT: IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN IT TO

THE DEALER. CONTACT CUSTOMER SERVICE @ 1-800-245-6489.







Mobile Home Use:

These freestanding corn/pellet units are approved for mobile home or doublewide installation

with outside combustion air hook-up. See “Flue System” section of manual.

Mobile home installation should be in accordance with the Manufactured Home and Safety

Standard (HUD), CFR 3280, Part 24.

WARNING: Do Not Install in Sleeping Room

CAUTION:

The structural integrity of the mobile home floor, wall and ceiling/roof

must be maintained.

Please Note the Following Precautionary Statements:

NOTE: WE DO NOT RECOMMEND CORN/PELLET STOVES AS YOUR ONLY SOURCE OF HEAT.



CAUTION: Please read this entire manual before installation and use of this

corn/pellet/ fuel burning room heater.
Keep children, furniture, fixtures and all combustibles away from
any heating appliance.

WARNING: USE OF OUTSIDE AIR IS MANDATORY WITH THIS UNIT

.

DO NOT OPERATE UNIT WITH HOPPER OPEN. LID MUST BE SHUT AND TIGHTLY SECURED.

DO NOT OPERATE WITH DOOR OPEN

SAFETY NOTICE

FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN PROPERTY DAMAGE,
BODILY INJURY OR EVEN DEATH. FOR YOUR SAFETY AND PROTECTION, FOLLOW ALL THE
INSTALLATION INSTRUCTIONS. CONTACT YOUR LOCAL BUILDING OR FIRE OFFICIALS FOR
RESTRICTIONS AND INSTALLATION INSPECTION REQUIREMENTS (INCLUDING PERMITS) IN
YOUR AREA.

Questions? Need Parts or Options?

www.englanderstoves.com

Rev. 1/07

England’s Stove Works highly recommends the use of smoke detectors and

Carbon Monoxide detectors with any hearth product, including this unit. Follow all

manufacturer’s instructions when using smoke or Carbon Monoxide detectors.



"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - A letter from our Technical Support department:; IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN IT TO THE DEALER.

A letter from our Technical Support department: Thank you for purchasing this fine product from England’s Stove Works! England's Stove Works was started, and is still owned by, a family that believes strongly in a "Do It Yourself" spirit – that’s one reason you found this product at your fav...

Page 3 - IMPORTANT INFORMATION; Read and comply with the instructions in this manual.

3 IMPORTANT INFORMATION 1. Installation of this pellet/corn unit should be performed by a professional only. Check local installation codes for your area. Call your Homeowner’s Insurance representative for inspection of your stove’s installation. 2. Read and comply with the instructions in this manu...

Page 4 - Basement Installation:; rise before terminating your vent pipe.

12. Horizontal runs should not exceed four feet (4’) with a maximum vertical flue height of thirty five feet (35’). At fifteen feet (15’), the pipe should be increased to four inch (4”) corn vent pipe. 13. This unit should be turned off and allowed to cool prior to cleaning. Any ashes should be kept...

Other England's Stove Works Models

All England's Stove Works Other