England's Stove Works 10-CPM - Manual

England's Stove Works 10-CPM

England's Stove Works 10-CPM – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
Page: / 35

Table of Contents:

  • Page 2 – A letter from our Technical Support department:; IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN IT TO THE DEALER.
  • Page 3 – IMPORTANT INFORMATION; Read and comply with the instructions in this manual.
  • Page 4 – Read the instructions thoroughly; , including instructions concerning the digital control; save them for future reference; rise before terminating your vent pipe.
  • Page 5 – UNIT PREPARATION; Must be a 15A circuit; IMPORTANT INFORMATION – READ BEFORE OPERATING; (Proper venting practices must be; Visit our web site at
  • Page 6 – Corn with over 12% moisture has a lower BTU value
  • Page 7 – GUIDELINES FOR EXHAUST VENTING SYSTEMS DESIGN; or guards may be required.; NOTE: YOUR UNIT MUST BE INSTALLED BY A QUALIFIED
  • Page 8 – TIGHT! Follow the vent manufacturer’s installation instructions.; DO NOT CONNECT TO ANY AIR DISTRIBUTION DUCT OR SYSTEM.
  • Page 9 – BURNING SOLID FUELS; due to foreign objects in the fuel supply.; SHELLED CORN; IMPORTANT: DO NOT BURN “TREATED” SEED CORN IN YOUR STOVE.; Seed corn is treated; Burning; CHERRY PITS; This type is usually bleached or over-dried.
  • Page 10 – FLUE SYSTEM; through combustible walls and ceilings.; Be sure to check local codes in your area.; Corn Vent Pipe; Do not; Do not install a flue damper of any kind in this
  • Page 11 – Through the Ceiling; may inhibit your draft by up to 30% per elbow.; Outside Air (Outside Combustion Air Intake); Outside air is mandatory for this unit to operate properly; Mobile Home Installation; to install the unit in a sleeping room of the home.; Important Notes Concerning Installation:; IMPORTANT SAFETY NOTE:
  • Page 12 – FLOOR AND WALL PROTECTION; Floor Protection; Illustration 1; Outside Air is mandatory for proper safe operation.
  • Page 13 – OPERATING INSTRUCTIONS; CAUTION: DO NOT OPERATE WITH THE DOOR OPEN.; “Heat Range”; touch pad will control the heat output; NOTE; installed. See page 26 – Thermostat instructions.; START- UP PROCEDURES; SETTING THE STIRRER; Bodily Injury can occur!; after
  • Page 14 – If the unit does not start,
  • Page 15 – If the unit does not start or maintain a fire, you will receive an; To remove the Stirrer for cleaning; While the unit is; COLD; back; Hitch Pin
  • Page 16 – FUEL CHANGE PROCEDURE
  • Page 17 – ” indicates “No Error”; OPERATIONAL NOTES; at least
  • Page 18 – WARNING: NEVER SHUT DOWN THIS UNIT BY UNPLUGGING IT; Refer to the following instructions:; S D; Technical Support Department
  • Page 19 – DAILY OPERATION; NOTE: DO NOT TRY TO RESTART THE UNIT HOT
  • Page 20 – ASH REMOVAL AND DISPOSAL; NOTE: There are two handles just above the ash pan.; Down cycle; BEFORE; beginning. Be aware that metal parts in the firebox can remain; HOT; long after; EVEN; after the Shut-Down cycle is complete. Always use extreme caution
  • Page 21 – MAINTENANCE; or
  • Page 22 – Replacing the Stirrer Drive Motor; flat side; Replacing the Stirrer Drive Shaft; Illustration 5 - Motor, Shaft and Sprockets
  • Page 23 – Gaskets; door gasket; Finish
  • Page 24 – Control Board; not; CAUTION: Moving Parts May Cause Injury.; Recommended Heat Ranges:; Illustration 6
  • Page 25 – CIRCUIT BOARD FUNCTIONS; Illustration 7 Control Board Diagram (Wiring)
  • Page 26 – ACCESSORY ITEMS; unit cool down before adding any accessories.; Thermostat; ACCESSORIES AND OPTIONS; PART NUMBER
  • Page 27 – REPLACEMENT PARTS; ITEM
  • Page 28 – (See Item numbers on Exploded Diagram for part location); CAUTION: UNPLUG THE UNIT PRIOR TO ANY SERVICE WORK!; Dimensions of your corn/pellet/multi fuel unit: 27
  • Page 29 – Adjusting your Hopper Lid Latch; Illustration 9
  • Page 30 – TROUBLE-SHOOTING GUIDE; ELECTRICAL SHOCK ALWAYS DISCONNECT THE UNIT FROM THE POWER; Problem Cause Solution; NOTE: Negative pressure in a home is a serious issue.
  • Page 33 – LIMITED 5 YEAR WARRANTY; The manufacturer extends the following warranties:; Conditions and Exclusions:; WARRANTY IS NOT TRANSFERABLE
  • Page 35 – WARRANTY REGISTRATION for England’s Stove Works; DEALER INFORMATION; How did you first hear about our product? (Please check one); IMPORTANT NOTICE; Visit
Loading the manual

INSTALLATION & OPERATION MANUAL

MODEL NUMBERS: 10-CPM 49-TRCPM 49-SHCPM

Thank you for purchasing this product from a fine line of heating equipment.

We wish you many years of safe heating pleasure with your new heating appliance.

Save These Instructions.

IMPORTANT: IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN IT TO

THE DEALER. CONTACT TECHNICAL SUPPORT @ 1-800-245-6489.







Please Note the Following Precautionary Statements:

NOTE: WE DO NOT RECOMMEND PELLET/CORN/MULTI-FUEL STOVES AS YOUR ONLY SOURCE OF HEAT.



CAUTION: Please read this entire manual before installation and use of this

Pellet/Corn/Multi-fuel burning room heater.
Keep children, furniture, fixtures and all combustibles away from
any heating appliance.

WARNING: USE OF OUTSIDE AIR IS MANDATORY WITH THIS UNIT

.

DO NOT OPERATE UNIT WITH HOPPER OPEN. LID MUST BE SHUT AND TIGHTLY SECURED.

DO NOT OPERATE WITH DOOR OPEN

SAFETY NOTICE

FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN PROPERTY DAMAGE,
BODILY INJURY OR EVEN DEATH. FOR YOUR SAFETY AND PROTECTION, FOLLOW ALL THE
INSTALLATION INSTRUCTIONS. CONTACT YOUR LOCAL BUILDING OR FIRE OFFICIALS FOR
RESTRICTIONS AND INSTALLATION INSPECTION REQUIREMENTS (INCLUDING PERMITS) IN
YOUR AREA.

Questions? Need Parts or Options?

www.englanderstoves.com



Rev. 4/19/2012

England’s Stove Works highly recommends the use of smoke detectors and

Carbon Monoxide detectors with any hearth product, including this unit. Follow all

manufacturers’ instructions when using smoke or Carbon Monoxide detectors.

Mobile Home Use:

These freestanding Pellet/Corn/Multi-fuel units are approved for mobile home or doublewide

installation with outside combustion air hook-up. See “Flue System” section of manual.

Mobile home installation should be in accordance with the Manufactured Home and Safety

Standard (HUD), CFR 3280, Part 24.

WARNING: Do Not Install in Sleeping Room.

CAUTION:

The structural integrity of the mobile home floor, wall and ceiling/roof

must be maintained.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - A letter from our Technical Support department:; IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN IT TO THE DEALER.

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED. ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT, OR DUE TO UNSAFE INSTALLATION OR USAGE O...

Page 3 - IMPORTANT INFORMATION; Read and comply with the instructions in this manual.

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED. ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT, OR DUE TO UNSAFE INSTALLATION OR USAGE O...

Page 4 - Read the instructions thoroughly; , including instructions concerning the digital control; save them for future reference; rise before terminating your vent pipe.

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED. ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT, OR DUE TO UNSAFE INSTALLATION OR USAGE O...

Other England's Stove Works Models

All England's Stove Works Other