Empire Comfort Systems DVF-36IP-2 - Manual
Empire Comfort Systems DVF-36IP-2 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – • Due to high temperatures the appliance should be located; Section; IMPORTANT WARNINGS
- Page 3 – occur if there is rust inside the storage tank or in iron gas pipes.; SAFETY INFORMATION FOR USERS OF LP-GAS; Close all gas tank or cylinder supply valves.; SOME POINTS TO REMEMBER; That's your signal to go into immediate action!
- Page 4 – SPECIFICATIONS; Model; Figure 1
- Page 6 – Warning: This unit is not for use with solid fuel.; Installation of any damaged fireplace or vent system component.; Introduction
- Page 7 – Figure 5; Planning Your Installation
- Page 8 – Figure 8; Acceptable vertical and horizontal vent run.; Installation; allow for finished face when setting the depth of the frame.; Figure 9
- Page 11 – Vertical Sidewall Application (Figures 19 and 20)
- Page 12 – Elbows
- Page 13 – Service Notes
- Page 14 – Termination Clearances; Venting terminals shall not be recessed into wall or siding.
- Page 16 – inch inner flue joints do not require any sealant.
- Page 18 – NOTE: Termination cap should pass through the wall firestop from; F on its outside edge too, so as to make a seal to the exterior wall.; NOTE: Wood screws can and should be replaced with appropriate
- Page 19 – Installing the Vent System in a Chase; Leak Testing Gas Line
- Page 20 – Log Placement; Refer to Figure 38 for the following warning.; REAR LOG; Placement of glowing embers.
- Page 21 – top. Push downward to lock the top louver into position.; Standing Pilot Operating Instructions; Follow the SAFETY and LIGHTING INSTRUCTIONS for standing
- Page 22 – RECOMMENDED WIRE GAUGES; Maximum
- Page 23 – Standing Pilot Wiring Diagram (Figure 43)
- Page 24 – causing property damage, personal injury or loss of life.; LIGHTING INSTRUCTIONS
- Page 25 – STANDING PILOT-TROUBLE SHOOTING; Spark ignitor will not light pilot after repeated triggering of; b. Thermopile may not be generating sufficient millivolts.; The pilot and main burner extinguish while in operation.; —Replace if necessary.; Flame burns blue and lifts off main burner.
- Page 26 – Intermittent Pilot Operating Instructions; to decrease; Intermittent Pilot Wiring Diagram (Figure 46)
- Page 27 – Electrical Junction Box Connection; NEUTRAL
- Page 28 – FOR YOUR SAFETY READ BEFORE OPERATING
- Page 29 – INTERMITTENT PILOT; SEQUENCE OF OPERATION; to Fireplace
- Page 30 – with the Sequence of Operation; IP SYSTEM TROUBLESHOOTING SEQUENCE; INSET A
- Page 31 – Maintenance and Service; PLEASE NOTE
- Page 32 – How To Order Repair Parts; Fireplace Number
- Page 34 – Installing Optional Fan Kit; right screw that attaches bottom louver to fireplace side.; OPTIONAL
- Page 35 – Parts List
- Page 36 – TOP VIEW
- Page 37 – Figure 5 Caulk and Install Duct Termination; Figure 4 Example of Installation; PARTS LIST; CAULKING
- Page 38 – ACCESSORY PARTS
- Page 39 – BRICK LINER KIT; INSTALLING OPTIONAL SIMULATED BRICK PANELS
R-5627
Page 1
INSTALLATION INSTRUCTIONS
AND
OWNER'S MANUAL
DIRECT VENT
GAS FIREPLACE
MODELS
DVF-36-2
DVF-42-2
DVF-36IP-2
DVF-42IP-2
EFFECTIVE DATE
NOVEMBER, 2000
WARNING: If not installed, operated and
maintained in accordance with the manu-
facturer's instructions, this product could
expose you to substances in fuel or from
fuel combustion which can cause death or
serious illness.
WARNING: If the information in this
manual is not followed exactly, a fire
or explosion may result causing prop-
erty damage, personal injury or loss
of life.
— Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS
•
Do not try to light any appliance.
•
Do not touch any electrical switch;
do not use any phone in your build-
ing.
•
Immediately call your gas supplier
from a neighbor's phone. Follow
the gas supplier's instructions.
•
If you cannot reach your gas sup-
plier, call the fire department.
— Installation and service must be per-
formed by a qualified installer, service
agency or the gas supplier.
This appliance may be installed in an
aftermarket permanently located, manu-
factured (mobile) home, where not pro-
hibited by state or local codes.
This appliance is only for use with the
type of gas indicated on the rating plate.
This appliance is not convertible for use
with other gases, unless a certified kit is
used.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
Page 2 R-5627 Section Page THIS IS A HEATING APPLIANCE WHEN HEATER BAFFLE IS INSTALLED, SEE PAGE 5 Do Not Operate This Appliance Without Glass Front Panel Installed. • Due to high temperatures the appliance should be located out of traffic and away from furniture and draperies. • The glass front or ...
R-5627 Page 3 Some people cannot smell well. Some people cannot smell theodor of the chemical put into the gas. You must find out if youcan smell the odorant in propane. Smoking can decrease yourability to smell. Being around an odor for a time can affect yoursensitivity or ability to detect that od...
Page 4 R-5627 Accessories for All DVF-36 & DVF-42 ModelsFRBC-1 Battery Operated Remote Control FRBTC-1 Battery Operated Remote Control with Thermostat (Only used when fireplace is converted into a heater. See Page 5.) FREC-1 Electric Remote Control FWS-1 Wall Switch DVF-VKT-1 Direct Vent Firepla...
