Empire Comfort Systems VFSV-16-3 - Manuals

Page 2 - TABLE OF CONTENTS

Page 2 18954-0-0705 Section Page Important Safety Information .........................................................................................................................3Safety Information for Users of LP Gas ................................................................................

Page 4 - SAFETY INFORMATION FOR USERS OF LP-GAS

Page 4 18954-0-0705 Some people cannot smell well. Some people cannot smell the odor of the chemical put into the gas. You must ﬁnd out if you can smell the odorant in propane. Smoking can decrease your ability to smell. Being around an odor for a time can affect your sensitivity or ability to detec...

Page 5 - INTRODUCTION

Page 5 18954-0-0705 Attention: During initial use of log you will detect an odor as the log is cured. Notice: During initial ﬁring of this unit, its paint will bake out, and smoke will occur. To prevent triggering of smoke alarms, ventilate the room in which the unit is installed. WARNING: This appl...

Page 6 - GENERAL INFORMATION; WATER VAPOR: A BY-PRODUCT OF UNVENTED ROOM HEATERS

Page 6 18954-0-0705 This is an unvented gas-ﬁred heater. It uses air (oxygen) from the room in which it is installed. Provisions for adequate combustion and ventilation air must be provided.Keep room area clear and free from combustible materials, gasoline and other ﬂammable vapors and liquids.Unven...

Page 7 - PROVISIONS FOR ADEQUATE COMBUSTION & VENTILATION AIR; CLEARANCES

Page 7 18954-0-0705 PROVISIONS FOR ADEQUATE COMBUSTION & VENTILATION AIR Minimum Dimensions For Solid Fuel Burning Fireplaces UL127 Factory Built Fireplaces (Figure 2) Model A B C D VFSV-16 18" 11 1/2" 24" 18" VFSR-16 18" 11 1/2" 24" 18" VFSV-18 17" 14" 28...

Page 11 - GAS SUPPLY

Page 11 18954-0-0705 GAS SUPPLY Check all local codes for requirements, especially for the size and type of gas supply line required. Recommended Gas Pipe Diameter Pipe Length Schedule 40 Pipe Tubing, Type L Inside Diameter Outside Diameter Nat. L.P. Nat. L.P. 0-10' 1/2" 3/8" 1/2" 3/8...

Page 13 - FOR YOUR SAFETY READ BEFORE LIGHTING; LIGHTING INSTRUCTIONS

Page 13 18954-0-0705 HI/LO REGULATOR CONTROL KNOB PIEZO IGNITOR FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not follow these instructions exactly, a ﬁre or explosion may result caus- ing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lighted...

Page 16 - PILOT FLAME CHARACTERISTICS

Page 16 18954-0-0705 Figures 16 and 19 show a correct pilot ﬂame pattern. The correct ﬂame will be blue and will extend beyond the thermocouple. The ﬂame will surround the thermocouple just below the tip. A slight yellow ﬂame may occur where the pilot ﬂame and main burner ﬂame meet. Figures 17 and 2...

Page 17 - CLEANING AND SERVICING

Page 17 18954-0-0705 Annual inspection and cleaning by your dealer or qualified service technician is recommended to prevent malfunction and/or sooting.TURN OFF HEATER AND ALLOW TO COOL BEFORE CLEANING. Remove logs, handling carefully by holding gently at each end. Gloves are recommended to prevent ...

Page 18 - WIRING

Page 18 18954-0-0705 WIRING Thermostats are not approved on vented decorative appliances. Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. Verify proper operation after servicing.16", 18", 24" and 30" Gas Logs (...

Page 19 - TROUBLESHOOTING

Page 19 18954-0-0705 If the gas quality is bad, your pilot may not stay lit, the burners may produce soot and the heater may backﬁre when lit. If the gas quality or pressure is low, contact your local gas supplier immediately. 1. When ignitor button is pressed, there is no spark at ODS/ pilot. a. Ig...

Page 20 - PARTS LIST

Page 20 18954-0-0705 Attention: When ordering parts, it is very important that part number and description of part coincide. USE ONLY MANUFACTURER'S REPLACEMENT PARTS. USE OF ANY OTHER PARTS COULD CAUSE INJURY OR DEATH. PARTS LIST Index No. Part Number Description COMMON PARTS 1 15425 REAR LOG SUPPO...

Page 21 - PARTS VIEW; HOW TO ORDER REPAIR PARTS

Page 21 18954-0-0705 PARTS VIEW Parts can be ordered only through your service person or dealer. For best results, the service person or dealer should order parts through the distributor. Parts can be shipped directly to the service person/dealer.All parts listed in the Parts List have a Part Number...

Page 22 - SERVICE NOTES