Empire Comfort Systems 2 - Manual

Empire Comfort Systems 2

Empire Comfort Systems 2 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
49 Page 49
50 Page 50
51 Page 51
52 Page 52
53 Page 53
54 Page 54
55 Page 55
56 Page 56
57 Page 57
58 Page 58
59 Page 59
60 Page 60
Page: / 60

Table of Contents:

  • Page 2 – Section Page; TABLE OF CONTENTS
  • Page 3 – IMPORTANT SAFETY INFORMATION
  • Page 4 – SAFETY INFORMATION FOR USERS OF LP GAS
  • Page 5 – REQUIREMENTS FOR MASSACHUSETTS; “GAS VENT DIRECTLY BELOW.
  • Page 6 – INTRODUCTION
  • Page 7 – SPECIFICATIONS
  • Page 8 – FIREPLACE DIMENSIONS
  • Page 9 – CLEARANCES
  • Page 10 – LOCATING FIREPLACE
  • Page 11 – GAS SUPPLY
  • Page 12 – REAR VENT CONVERSION; SPECIAL VENT SYSTEMS; Empire Horizontal Round Termination Kit DVVK-4RE, refer to Page 30
  • Page 13 – INSTALLATION
  • Page 18 – VENTING FIREPLACE - TOP
  • Page 19 – Firestop at
  • Page 21 – EXAMPLES - TOP VENT RUN
  • Page 22 – VENTING FIREPLACE - REAR
  • Page 23 – EXAMPLES - REAR VENT RUN
  • Page 24 – TERMINATION CLEARANCES
  • Page 25 – VENT CLEARANCES
  • Page 26 – VENT SYSTEM IDENTIFICATION
  • Page 27 – FRAMING AND FINISHING
  • Page 29 – HORIZONTAL TERMINATION
  • Page 30 – DVVK-4RE VENT KIT INSTALLATION INSTRUCTIONS
  • Page 33 – DVVK-4F FLEX VENT INSTRUCTIONS
  • Page 34 – VERTICAL TERMINATION
  • Page 38 – OPERATING INSTRUCTIONS
  • Page 40 – STANDING PILOT WIRING DIAGRAM
  • Page 41 – STANDING PILOT LIGHTING INSTRUCTIONS; FOR YOUR SAFETY READ BEFORE LIGHTING
  • Page 42 – STANDING PILOT TROUBLESHOOTING
  • Page 43 – DIRECT IGNITION WIRING DIAGRAM; OPTIONAL REMOTE CONTROL
  • Page 44 – DIRECT IGNITION LIGHTING INSTRUCTIONS
  • Page 45 – INITIAL START UP GAS LINE PURGE; PURGE PROCEDURE; DIRECT IGNITION TROUBLESHOOTING
  • Page 46 – DIRECT IGNITION PROPANE/LP GAS CONVERSION
  • Page 48 – MAINTENANCE AND SERVICE
  • Page 49 – PARTS LIST
  • Page 50 – PARTS VIEW
  • Page 51 – FBB4 OPTIONAL VARIABLE SPEED BLOWER INSTALLATION
  • Page 53 – 20V DIRECT IGNITION VALVE MODELS
  • Page 54 – ACCESSORIES
  • Page 55 – DECORATIVE ACCESSORIES
  • Page 57 – SERVICE NOTES
Loading the manual

Page 1

DIRECT VENT

GAS FIREPLACE HEATER

MODEL SERIES

MILLIVOLT

DVD32FP3(0,1,2,3)(N,P)-1

DVD36FP3(0,1,2,3)(N,P)-1

DVD42FP3(0,1,2,3)(N,P)-1

DVD48FP3(0,1,2,3)(N,P)-1

DIRECT IGNITION

DVD32FP5(0,1,2,3)N-2

DVD36FP5(0,1,2,3)N-2

DVD42FP5(0,1,2,3)N-2

DVD48FP5(0,1,2,3)N-2

UL FILE NO. MH30033

INSTALLATION INSTRUCTIONS

AND

OWNER’S MANUAL

WA R N I N G : I f n o t i n s t a l l e d , o p e r a t e d a n d

maintained in accordance with the manufacturer’s in-

structions, this product could expose you to substances

in fuel or from fuel combustion which can cause death

or serious illness.

This appliance may be installed in an aftermarket,

permanently located, manufactured home (USA only)

or mobile home, where not prohibited by state or local

codes.
This appliance is only for use with the type of gas

indicated on the rating plate. This appliance is not

convertible for use with other gases, unless a certified

kit is used.

The Tahoe Direct Vent Zero Clearance Gas

Fireplace Heater

GAS-FIRED

Installer: Leave this manual with the appliance.

Consumer: Retain this manual for future reference.

— Do not store or use gasoline or other flamma-

ble vapors and liquids in the vicinity of this or

any other appliance.

— WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not

use any phone in your building.

• Immediately call your gas supplier from a

neighbor’s phone. Follow the gas suppli-

er’s instructions.

• If you cannot reach your gas supplier, call

the fire department.

— Installation and service must be performed by

a qualified installer, service agency or the gas

supplier.

WARNING: If the information in these instruc-

tions are not followed exactly, a fire or explosion

may result causing property damage, personal

injury or loss of life.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - Section Page; TABLE OF CONTENTS

23552-4-0408 Page 2 Section Page TABLE OF CONTENTS Important Safety Information ............................................................................................................................ 3Safety Information for Users of LP Gas ..........................................................

Page 3 - IMPORTANT SAFETY INFORMATION

23552-4-0408 Page 3 DO NOT OPERATE THIS APPLIANCE WITHOUT GLASS FRONT PANEL INSTALLED Before enclosing the vent pipe assembly, operate the appliance to ensure it is venting properly. • Due to high temperatures the appliance should be located out of traffic and away from furniture and draperies. • The...

Page 4 - SAFETY INFORMATION FOR USERS OF LP GAS

23552-4-0408 Page 4 SOME POINTS TO REMEMBER NO ODOR DETECTED - ODOR FADE LP-GAS WARNING ODOR If a gas leak happens, you should be able to smell the gas because of the odorant put in the LP-Gas. That’s your signal to go into immediate action! SAFETY INFORMATION FOR USERS OF LP GAS Propane (LP-Gas) is...

Other Empire Comfort Systems Models

All Empire Comfort Systems Other