Edelbrock 70003 - Manual

Edelbrock 70003

Edelbrock 70003 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
Page: / 28

Table of Contents:

  • Page 2 – -Stage Performer RPM Nitrous System
  • Page 3 – Before You Install Your Edelbrock Nitrous System...; You should understand the following skills:
  • Page 4 – Do not
  • Page 5 – General Information; Horsepower and torque increases can vary with
  • Page 6 – Jet Map Information; “Ignition Timing and Nitrous” for more information on timing
  • Page 7 – Engine Operation Considerations; To ensure proper; Adequate Fuel Pressure and Delivery:
  • Page 9 – tube inside the bottle or the bottle valve itself.; Racing Vehicles
  • Page 10 – Bottle Orientation
  • Page 11 – Nitrous Bottle Installation; Street Car Installations
  • Page 12 – Do not use Teflon tape.; Solenoid Safety Information; Performer RPM Solenoid Assembly
  • Page 13 – Performer Solenoid Assembly; The assembly should look like the; Mounting Your Solenoids
  • Page 14 – Fuel and Nitrous Y-Fittings Installation
  • Page 15 – red
  • Page 16 – Quantity
  • Page 17 – Nitrous Electrical System
  • Page 19 – Arming Switch and Installation; instructions for further information.; Microswitch Installation and Wiring; as EGR risers or passageways.
  • Page 20 – Final Electrical Installation Recommendations; Double Check; of the throttle body linkage.
  • Page 21 – Make sure the nitrous; Nitrous System Check
  • Page 22 – Baseline Tuning Suggestions
  • Page 24 – Solenoid Inspection and Maintenance; Close valve on nitrous bottle.; Do not open pressurized fuel lines over a hot engine.; Remove coil and housing from nitrous solenoid base.; Do not use pliers on solenoid stem; damage to the stem will result.; Do not use an oil-based solvent to clean any part of the solenoid.; Use paint thinner
  • Page 26 – Symptom #4... No change in performance when system is activated.
  • Page 27 – Inadequate fuel delivery due to:; Symptom #7... High RPM misfire when system is activated.
Loading the manual

©2004 Edelbrock Corporation
Brochure No. 63-0190 - DC/mc

Rev. 03/04

Catalog #70003 & #70004

Page 1 of 28

2-STAGE PERFORMER RPM NITROUS SYSTEM

Catalog #70003 & #70004

Table of Contents

Page #

a.

Edelbrock General Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

b.

Before You Install Your Edelbrock Nitrous System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

c.

What is Nitrous Oxide? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

d.

Safety Tips for Working with Nitrous Oxide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

1.0 Introduction to your 2-Stage Perfomer RPM Nitrous System

1.1

General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

1.2

Jet Map Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

1.3

Engine Operation Considerations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

1.4

2-Stage Performer RPM Nitrous System Bill of Materials . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

2.0 Nitrous System Installation

2.1

Nitrous Bottle Mounting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

2.2

Bottle Orientation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

2.3

Nitrous Bottle Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

2.4

Nitrous Feed Line Mounting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

2.5

Solenoid Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

2.6

Mounting Your Solenoids . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-14

2.7

Fuel and Nitrous Y-Fittings Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

2.8

Nitrous Injection Plate Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

2.9

Jet and Plumbing Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

3.0

Electrical System Installation

3.1

Nitrous Electrical Components Bill of Materials . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

3.2

Nitrous Electrical System Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

3.3

Nitrous Electrical System Installation Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

3.4

Nitrous Relay and Fuse Holder Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

3.5

Arming Switch and Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

3.6

Microswitch Installation and Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19-20

3.7

Final Electrical Installation Recommendations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

4.0

Before You Run Your Vehicle Using Your Edelbrock Nitrous System

4.1

Fuel System Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

4.2

Nitrous System Check. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

5.0

Baseline Tuning Suggestions

5.1

Nitrous Bottle Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

5.2

Fuel Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

6.0

Ignition Timing and Nitrous

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

7.0

Solenoid Inspection and Maintenance

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

24

8.0

Troubleshooting Guide

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

25-28

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - -Stage Performer RPM Nitrous System

©2004 Edelbrock CorporationBrochure No. 63-0190 - DC/mc Rev. 03/04 Catalog #70003 & #70004 Page 2 of 28 Thank You….…for purchasing an Edelbrock Nitrous Oxide Injection System. Nitrous Oxide injection is one of the most exciting performance enhancements, for the dollar invested, on the market tod...

Page 3 - Before You Install Your Edelbrock Nitrous System...; You should understand the following skills:

©2004 Edelbrock CorporationBrochure No. 63-0190 - DC/mc Rev. 03/04 Catalog #70003 & #70004 Page 3 of 28 Caution!! Before You Install Your Edelbrock Nitrous System… Please read this Installation manual fully before installing this system. You will need to have available the following tools: Hand ...

Page 4 - Do not

©2004 Edelbrock CorporationBrochure No. 63-0190 - DC/mc Rev. 03/04 Catalog #70003 & #70004 Page 4 of 28 WHAT IS NITROUS OXIDE? Nitrous Oxide is a cryogenic gas composed of nitrogen and oxygen molecules. It is stored as a “gas over a liquid” which means thatboth liquid and gaseous nitrous oxide i...

Other Edelbrock Models

All Edelbrock Other