Page 2 - T A B L E O F C O N T E N T S
2 1. PREFACE AND INTRODUCTION ……..………………………………… 3 2. SAFETY NOTICE …………………………………………………………...…. 2.1 Before driving 2.2 While driving 2.3 Labeling 2.4 EMI 4 3. 4. PARTS INTRODUCTION ……………..……………….. ……………………. OPERATION ………………………………………………………………….... 4 .1 Control panel 4.2 How to operate your scooter 4.3...
Page 3 - . P R E F A C E A N D I N T R O D U C T I O N
3 P lease carefully read this owner’s manual before using the vehicle. Improper use of the vehicle could result in harm, injury or traffic accidents. To ensure that you get the most your scooter, please read this owner’s manual before using. ♦ This owner’s manual includes operation instructions for ...
Page 4 - . S A F E T Y N O T I C E; . 1 B E F O R E D R I V I N G; Practice operating your vehicle; Refer to the section entitled “DAILY CHECKING”
4 2 . S A F E T Y N O T I C E 2 . 1 B E F O R E D R I V I N G The user needs to be familiar with the usage and operation of this vehicle before driving. Therefore, please follow the commendations in this safety notice. ■ The same traffic rules apply to the use of this vehicle as apply to pedestrians...
Page 5 - Do not use your vehicle under the circumstances below.; Do not drive your vehicle in an “S” pattern or make erratic turnings.; About Mobile Phones and other electrical equipment; Please slow down when driving on roads with inclines.
5 2 . S A F E T Y N O T I C E 2.2 WHILE DRIVING ■ Do not use your vehicle under the circumstances below. ♦ On surfaces that are muddy, gravelly, bumpy, narrow, snowed over, icy, or canal towpaths not guarded by any fence or hedge. Keep away from places where you might get the wheels stuck. ♦ Do not ...
Page 6 - WARNING
6 lbs 8° 20 lbs 7° lbs 6° Figure 1. Maximum Recommended lncline Angles READ OWNER'S MANUAL AND CHARGE BATTERY BEFORE OPERATING WARNING Do not exceed recommended inclines or weight limits. scooter is motion. Never attempt to adjust the tiller while the tightened. certain the tiller adjustment knob is...
Page 7 - Caution; It can also permanently
7 2 . S A F E T Y N O T I C E 2.4 EMI This portion of the content will provide the user with basic information that describes the problems with EMI, known sources of EMI, protective measures either to lessen the possibility or exposure or to minimize the degree of exposure, and suggested action shou...
Page 8 - POWERED VEHICLE ELECTROMAGNETIC INTERFERENCE (EMI); coming close to them; IMPORTANT INFORMATION
8 2 . S A F E T Y N O T I C E 3. Long-range transmitters and transceivers, such as commercial broadcast transmitter (radio and TV broadcast antenna towers) and amateur (HAM) radios. Note: Other types of hand-held devices, such as cordless phones, laptop computers, AM/FM radios, TV sets, CD player, a...
Page 9 - . P A R T S I N T R O D U C T I O N; PARTS DESCRIPTION
9 3 . P A R T S I N T R O D U C T I O N PARTS DESCRIPTION 1. Control panel 2. Basket 3. Charger Socket 4. Tiller Adjustment Knob 5. Seat 6. Seat Rotation Lever 7. Battery Pack 8. Freewheel Lever 9. Anti-tip wheels 10. Seat Post Knob 11. Seat Height Adjustment Pin
Page 10 - . O P E R A T I O N; Speed Dial 2. Horn Button
10 4 . O P E R A T I O N 4.1 CONTROL PANEL 1. Speed Dial 2. Horn Button 3. Battery Indicator 4. Power Switch 5. Power Eye 4.2 HOW TO OPERATE YOUR SCOOTER ■ Power switch ♦ To switch the power on , turn the key clockwise in the ignition. The power eye should illuminate. ♦ To switch the power off, turn...
Page 11 - . O P E R A T I O N; Warning; Push the seat adjustment lever forward and swivel the seat.; Attention; Return the seat to the forward position before driving.; Battery indicator; recharge is necessary.
11 4 . O P E R A T I O N N Warning When on a gradient NEVER set the vehicle to the freewheel mode. The electromagnetic brakes will not be applied. This may result in injury or damage. ■ Seat ♦ The seat can be rotated and locked in position at 45 degrees intervals. ♦ Push the seat adjustment lever f...
Page 12 - Suggestion; How to adjust the seat height; Pin lock
12 4 . O P E R A T I O N & Suggestion 1. You should recharge the batteries after each time the vehicle is used to ensure maximum range. The batteries should be charged up at least once a week even if the scooter is not used. 2. After charging or replacing a new battery, drive the vehicle for 2-...
Page 13 - How to set to freewheel mode; Fig 4.1 Fig 4.2; Always pull UP FIRMLY for freewheel mode
13 4 . O P E R A T I O N 4.3 How to set to freewheel mode Fig 4.1 Fig 4.2 ◆ Engaged mode (Fig. 4.1): Push the lever completely and the scooter can be driven by motor power. ◆ Freewheel Mode (Fig 4.2) ： Pull the lever up and the scooter can be moved manually. N Warning Never operate the freewheel le...
Page 14 - Tiller Adjustment; Never attempt to adjust the tiller while the scooter is motion.
14 ■ Tiller Adjustment The tiller can be adjusted in to many different positions to suit each driver. 1. Loosen the knob to adjust the tiller to positions you want. (Fig. 4.3) 2. Once decide the position, tighten the knob to secure the tiller.( Fig.4.4) Fig. 4.3 Fig. 4.4 4 . O P E R A T I O N N War...
Page 15 - . D R I V I N G O N T H E R O A D; Starting and Driving
15 5 . D R I V I N G O N T H E R O A D ■ Starting and Driving 1. Make sure the seat is installed properly. 2. Make sure the tiller has been secured properly. 3. Fold down the armrests so you can rest your arms on them. 4. Turn the power switch to “ON”. 5. Check battery indicator to see whether there...
Page 16 - . B A T T E R Y C H A R G I N G A N D C A R E; CHARGING THE BATTERY
16 6 . B A T T E R Y C H A R G I N G A N D C A R E 6.1 CHARGING THE BATTERY ■ Method 1: On board Charging (see photograph overleaf) Follow the procedure below step by step: 1. Turn the power switch to (OFF) 2. Plug the charger’s power cord into the mains. 3. Open the charging socket cap on the rear ...
Page 17 - Charging Hours
17 6 . B A T T E R Y C H A R G I N G A N D C A R E ■ Charging Hours The charging duration is about 6 hours. To ensure optimum performance a 10-hour charge is recommended. But we do not recommend a charging more than 24 consecutive hours. ■ Batteries (Inside the Pack) 1. The PHOENIX HD 3/PHOENIX HD 4...
Page 18 - Cleaning the battery
18 6 . B A T T E R Y C H A R G I N G A N D C A R E ♦ The batteries carry a eight-month of manufacturer's warranty. This warranty only covers issues relating to manufacturing faults, and not faults relating to failure to recharge the batteries as instructed above. & Suggestion – How to maximize ...
Page 19 - Do not use the battery to charge telecom equipment or other items.
19 6 . B A T T E R Y C H A R G I N G A N D C A R E N Warning 1. The wiring system and charger are well situated in the battery pack while being assembled in plant. Do not attempt to re-locate the wiring system by yourself. The improper layout of wiring system may result in the wires pinched by batt...
Page 20 - . I N S P E C T I O N A N D M A I N T E N A N C E; REGULAR CHECKING RECORD
20 7 . I N S P E C T I O N A N D M A I N T E N A N C E 7.1 INSPECTION • Clean the scooter with a damp cloth and dust down approximately once a week to preserve the appearance of the scooter. • Adjust the tiller height and return to the original position and swivel the seat once a week to ensure the ...
Page 22 - Switch off the power with power key before moving.; DISASSEMBLING THE SCOOTER; Push the Seat Rotate Lever whilst pulling up on the seat to remove.
22 7 . I N S P E C T I O N A N D M A I N T E N A N C E 7.5 MOVING ABOUT ♦ Switch off the power with power key before moving. Always dismount from the scooter before moving. ♦ Lift the scooter by the chassis, and not by the shroud. Lifting the scooter by the bumper could cause damage or injury. ♦ For...
Page 23 - Knob lock
23 7 . I N S P E C T I O N A N D M A I N T E N A N C E N Warning Always unplug the rear section electrical connector before separating the two sections. Knob lock
Page 24 - ASSEMBLING THE SCOOTER; Position the front and rear sections of PHOENIX HD 3/PHOENIX HD 4.
24 7 . I N S P E C T I O N A N D M A I N T E N A N C E 7.7 ASSEMBLING THE SCOOTER & Suggestion The assembly process is essentially the disassembly process in reverse. First study the text and photographs in the disassembly procedure before re-assembling the scooter. 1. Position the front and re...
Page 25 - . T R O U B L E S H O O T I N G; TROUBLE SHOOTING
25 8 . T R O U B L E S H O O T I N G ■ TROUBLE SHOOTING If you have trouble with your scooter, you can inspect the following before taking you scooter to the dealer. If you cannot solve the problem, contact your dealer for assistance. Problem Symptom Remedy The scooter will not switch on • Batteries...
Page 26 - . S P E C I F I C A T I O N; S P E C I F I C A T I O N S
26 9 . S P E C I F I C A T I O N S P E C I F I C A T I O N S Model PHOENIX HD 3 PHOENIX HD 4 Dimension (L x W x H mm) (L x W x H inch) 980 × 550 × 1010mm (38.5" × 21.7" × 39.7") 1055 × 550 × 965mm (41.5" × 21.7" × 38.0") Base Weight 30.3kgs / 66.6lbs 35.3kgs / 77.6lbs Battery...
Page 27 - 0 . W A R R A N T Y
27 1 0 . W A R R A N T Y 9.1 WARRANTY There is a limited lifetime warranty on your new Bobcat Scooter. The warranty covers the scooter for parts only during this period. For more detail, please see the Warranty Conditions below. Warranty Conditions: Any work or replacement part installation must be ...
Page 28 - Warranty Application Form
28 1 0 . W A R R A N T Y 10.1 VIN (VEHICLE INDIFICATION NUMBER) To ensure the correct after sales service and warranty service support, please write down the vehicle identification number that is stuck on the back right-hand side of the frame. ……………………………………………………………………………………………………………………………… Warrant...
Page 29 - Drive Medical Design & Manufacturing; 9 Seaview Boulevard
29 Drive Medical Design & Manufacturing 99 Seaview Boulevard Port Washington, NY Tel: (516) 998-4600 Fax: (516) 566-2043 www.drivemedical.com
