COZY W506F - Manual
COZY W506F – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Page 2
- Page 3 – NATURAL GAS; CONTROLS
- Page 4 – COMBUSTION AND VENTILATION AIR
- Page 6 – VENTING
- Page 7 – FIGURE A
- Page 9 – INSTALLATION
- Page 10 – Label all wires prior to disconnection when; WIRING INSTRUCTIONS –; Failure to locate the thermostat properly
- Page 11 – property damage, personal injury or loss of life.; LIGHTING INSTRUCTIONS
- Page 12 – PILOT ADJUSTMENT; PILOT FLAME ADJUSTMENT; MAINTENANCE INSTRUCTIONS; BURNER FLAME ADJUSTMENT - STAINLESS STEEL BURNER; FLAME TOO SOFT
- Page 13 – BBSK INSTALLATION INSTRUCTIONS; NOTE: If you are replacing an existing wall
- Page 15 – BBSK KIT LIGHTING INSTRUCTIONS; FOR YOUR SAFETY READ BEFORE LIGHTING
- Page 16 – INSTALLATION INSTRUCTIONS
- Page 17 – WFF81-C WIRING SCHEMATIC
- Page 18 – INSTALLATION INSTRUCTIONS FOR GRAVITY VENTED WALL FURNACES; Part
- Page 20 – TROUBLE SHOOTING CHART for qualified serviceman - MAIN BURNER; SYMPTOM
- Page 21 – TROUBLE SHOOTING CHART - AUTOMATIC PILOT & VALVE
- Page 22 – GRAVITY WALL FURNACE; REAR REGISTER KIT; THERMOSTAT
- Page 25 – LIMITED WARRANTY; LOUISVILLE TIN & STOVE COMPANY; TABLE A
GAS-FIRED VENTED
GAS-FIRED VENTED
GAS-FIRED VENTED
GAS-FIRED VENTED
GAS-FIRED VENTED
W
W
W
W
WALL FURNACE
ALL FURNACE
ALL FURNACE
ALL FURNACE
ALL FURNACE
INSTALLATION AND
OPERATING INSTRUCTIONS
P/N 84502 / REV. 10/2008
NATURAL GAS
W255F, W355F, W505F
L.P. GAS
W256F, W356F, W506F
WARNING: Operation of this furnace when not connected to a properly installed and maintained venting
system can result in Carbon Monoxide (C.O.) poisoning and possible death. For your safety, this furnace and
the venting system should be inspected at least annually by a qualified service person.
This appliance is equipped with a blocked flue switch designed to protect against a blocked flue condition.
The coating selected to provide longer life to the heat exchanger may smoke slightly upon initial firing. Please
provide adequate ventilation if this occurs.
This heater may be installed without recessing into stud space by using optional FSK (Free Standing Kit).
This unit is not approved for installation in mobile homes, greenhouses, or environments involving dusty, wet,
corrosive, or explosive conditions. Such conditions will invalidate the warranty and may create unsafe conditions.
THIS UNIT IS NOT TO BE INSTALLED IN MOBILE HOMES.
R
R
-
Do not store or use gasoline or other flammable vapors and
liquids in the vicinity of this or any other appliance.
-
WHAT TO DO IF YOU SMELL GAS:
•••••
Do not try to light any appliance.
•••••
Do not touch any electrical switch; do not use any phone in
your building.
•••••
Immediately call your gas supplier from a neighbor’s phone.
Follow the gas supplier’s instructions.
•••••
If you cannot reach your gas supplier, call the fire department.
-
INSTALLATION AND SERVICE MUST BE
PERFORMED BY A QUALIFIED INSTALLER,
SERVICE AGENCY OR THE GAS SUPPLIER.
WARNING: If the information in this manual is not
followed exactly, a fire or explosion may result causing
property damage, personal injury or loss of life.
INSTALLER
: Leave this manual with the appliance.
CONSUMER
: Retain this manual for future reference.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
READ CAREFULLY BEFORE INSTALLING UNIT These installation instructions are a general guide, and do not supersede applicable local codes and ordinances. Before planning ormaking the installation, be sure it complies with all phases of the local heating codes. Or, in the absence of local codes, with th...
1” 11” 2” SAFETY RULES A) The wall furnace should be located near the center ofthe house for best heat distribution. B) Due to high temperatures, the appliance should belocated out of traffic and away from furniture anddraperies. C) Children and adults should be alerted to the hazardsof high surface...
COMBUSTION AND VENTILATION AIR When installed, this gas appliance must be provided with fresh air for combustion, ventilation, and dilution of hotflue gases. The minimum required volume of the area where the appliance is installed should be 50 cubic feet per1,000 btu/hr. If installed in an area of t...
