COZY VC702A - Manual
COZY VC702A – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 3 – POSSIBLE CAUSES
- Page 4 – VENTING; FIGURE A; UNSAFE; FIGURE 7B
- Page 6 – COMBUSTION AND VENTILATION AIR
- Page 7 – CLEARANCES; VCR50 & VCR70; Floor; Ceiling; Floor; DRAFT DIVERTER
- Page 8 – FOR ALL VCR MODELS; INSTALL GLASS AND RADIANTS AS FOLLOWS:
- Page 9 – FIGURE 3; SERVICE RECORD
- Page 10 – FOR YOUR SAFETY READ BEFORE LIGHTING; WHAT TO DO IF YOU SMELL GAS:; LIGHTING INSTRUCTIONS; STOP! Read the information on the safety label.; TO TURN OFF GAS TO APPLIANCE
- Page 11 – TROUBLE SHOOTING CHART for qualified serviceman - MAIN BURNER
- Page 12 – TROUBLE SHOOTING CHART - AUTOMATIC PILOT & VALVE
- Page 13 – CHB-3 BLOWER INSTALLATION; FIGURE B
- Page 17 – TABLE A; LIMITED WARRANTY; LOUISVILLE TIN AND STOVE COMPANY
Gas-Fired Vented
Room Heater
INSTALLATION AND
OPERATING INSTRUCTIONS
P/N 80900 - REV. 12/03
This appliance is equipped with a safety control system designed to protect against
improper venting of combustion products.
THIS UNIT IS NOT TO BE INSTALLED IN MOBILE HOMES.
WARNING: If the information in this manual is not
followed exactly, a fire or explosion may result
causing property damage, personal injury or loss of
life.
-
Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
-
WHAT TO DO IF YOU SMELL GAS:
•
Do not try to light any appliance.
•
Do not touch any electrical switch; do not use any phone
in your building.
•
Immediately call your gas supplier from a neighbor’s
phone. Follow the gas supplier’s instructions.
•
If you cannot reach your gas supplier, call the fire
department.
-
INSTALLATION AND SERVICE MUST BE
PERFORMED BY A QUALIFIED INSTALLER,
SERVICE AGENCY OR THE GAS SUPPLIER.
WARNING: Operation of this heater when not connected to a properly installed and maintained
venting system or tampering with the vent safety shut-off system can result in Carbon Monoxide
(CO) poisoning and possible death.
RADIANT FRONT
CLOSED FRONT
This unit is not approved for installation in mobile homes, greenhouses, or environments involving
dusty, wet, corrosive, or explosive conditions. Such conditions will invalidate the warranty and may
create unsafe conditions.
The coating selected to provide longer life
to the heat exchanger may smoke slightly
upon initial firing. Provide adequate venti-
lation if this occurs.
NATURAL GAS VC201A VC351A VC501A VC701A VCR351A VCR501A VCR701A
PROPANE GAS VC202A VC352A VC502A VC702A VCR352A VCR502A VCR702A
R
R
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
INTRODUCTION THIS IS A GAS-FIRED, GRAVITY VENTED ROOM HEATER THAT WILL OPERATE SAFELY AND PROVIDE AN EFFICIENTSOURCE OF HEAT WHEN INSTALLED, OPERATED AND MAINTAINED AS RECOMMENDED IN THESE INSTALLATIONAND OPERATING INSTRUCTIONS. READ THESE INSTRCTIONS THOROUGHLY BEFORE INSTALLING, SERVICING, ORUSING...
VENTING 10’ or Less 2’ Min. 3’ Min. Ridge Chimney More than1 0 ’ 10’ 2’ Min. 3’ Min. Ridge Chimney Height above anyroof surfacewithon 10’horizontally FIGURE A FIGURE A Seal around collar & flashings Maintain1” Clearance SupportLaterals Termination of vent must besecurely guyed or braced ifit ext...
COMBUSTION AND VENTILATION AIR When installed, this gas appliance must be provided with fresh air forcombustion, ventilation, and dilution of hot flue gases. The minimum requiredvolume of the area where the appliance is installed should be 50 cubic feet per1,000 btu/hr. If installed in an area of th...
