COZY CF354C-R - Manual
COZY CF354C-R – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – MODELS WITH LOW-BTU STANDING PILOT
- Page 3 – SAFETY RULES; Adequate air for combustion and venting must be provided.; READ CAREFULLY BEFORE INSTALLING UNIT
- Page 4 – FIGURE A
- Page 5 – COMBUSTION AND VENTILATION AIR
- Page 6 – Side Wall; MODEL NUMBER; ” Minimum; FIGURE 2; Header Plate; FIGURE 3
- Page 8 – INSTALLATION; FIGURE 6
- Page 9 – FIGURE B; CONTROLS; NATURAL GAS; SPECIFIC ELEVATIONS; PILOT ADJUSTMENT; STANDING PILOT
- Page 10 – causing property damage, personal injury or loss of life.; LIGHTING INSTRUCTIONS; PILOT BURNER
- Page 11 – TO TURN OFF GAS TO APPLIANCE
- Page 13 – TERMINAL BLOCK WIRING DIAGRAM; AUXILIARY LIMIT SWITCH; the heating season or as often as needed.
- Page 15 – CF357C, CF358C I.I.D. CF557C, CF558C
- Page 16 – ROUGH-INS FOR REAR OR SIDE DISCHARGE; Install plastergrounds as shown in Figure 12 and Figure 13.; OPTIONAL ACCESSORY KITS
- Page 17 – SIDE DISCHARGE ON CASING; OPTIONAL KITS - CONTINUED; MODEL
- Page 18 – TROUBLE SHOOTING CHART - PILOT AND VALVE
- Page 19 – TROUBLE SHOOTING CHART - PILOT AND VALVE - CONTINUED
- Page 20 – COUNTERFLOW WALL FURNACE / STANDING PILOT; CONTROL ASSEMBLY
- Page 23 – 4 VOLT SYSTEM WITH INTERMITTENT
- Page 25 – PARTS LIST FOR ACCESSORIES FOR COUNTERFLOW WALL FURNACE; REPLACEMENT WIRING - STANDING PILOT COUNTERFLOW
- Page 26 – TAMPERING IS DANGEROUS
- Page 27 – LOUISVILLE TIN AND STOVE COMPANY
COUNTERFLOW
WALL FURNACE
INSTALLATION AND
OPERATING INSTRUCTIONS
P/N 78111
REV. 05/03
24 VOLT SYSTEM NATURAL GAS CF353C-R CF503C-R CF653C-R
WITH LOW-BTU
PILOT
L.P. GAS CF354C-R CF504R CF654C-R
MODEL NUMBERS
24 VOLT SYSTEM
NATURAL GAS CF357C-R CF557C-R
WITH INTERMITTENT
IGNITION (I.I.D.)
L.P. GAS CF358C-R CF558C-R
-
Do not store or use gasoline or other flammable vapors and
liquids in the vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS:
Ø
Ø
Ø
Ø
Ø
Do not try to light any appliance.
Ø
Ø
Ø
Ø
Ø
Do not touch any electrical switch; do not use any phone in
your building.
Ø
Ø
Ø
Ø
Ø
Immediately call your gas supplier from a neighbor’s phone.
Follow the gas supplier’s instructions.
Ø
Ø
Ø
Ø
Ø
If you cannot reach your gas supplier, call the fire department.
-
INSTALLATION AND SERVICE MUST BE PERFORMED
BY A QUALIFIED INSTALLER, SERVICE AGENCY OR
THE GAS SUPPLIER.
WARNING: Operation of this furnace when not connected to a properly installed and main-
tained venting system can result in Carbon Monoxide (C.O.) poisoning and possible death. For
your safety, this furnace and the venting system should be inspected at least annually by a quali-
fied service person.
The coating selected to provide longer life to the heat exchanger may smoke slightly upon initial firing. Please
provide adequate ventilation if this occurs.
This unit is not approved for installation in mobile homes, greenhouses, or environments involving dusty, wet, corrosive,
or explosive conditions. Such conditions will invalidate the warranty and may create unsafe conditions.
This appliance is equipped
with a blocked flue switch
designed to protect against
improper venting of
combustion products.
THIS UNIT IS NOT TO
BE INSTALLED IN
MOBILE HOMES.
WARNING: If the information in this manual is not followed exactly, a
fire or explosion may result causing property damage, personal injury or
loss of life.
R
R
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
CONTENTS Contents……………………………………………........... 2Introduction…………………………………………. 2Specifications……………………………………….. 2Safety Rules………………………………………… 3Helpful Installation Information……………….........…. 3Connecting the Vent……………………………....…..… 3,4Combustion and Ventilation Air.......................................
SAFETY RULES 1. Improper installation, adjustment, alteration, service or maintenance can cause property damage, bodily injury or death. If youdo not understand these instructions or your local codes, call local authorities, a qualified installer, service agency, gas supplier,or the manufacturer. 2....
VENTING - CONTINUED This appliance is equipped with a blocked flue switch. WARNING: Do not bypass the blocked flue switch. Todo so could expose the consumer to property damage,personal injury or possible death. This switch, when activated, will interrupt the electrical circuit betweenthe transformer...
