Comfort Glow CHDV41N - Manual

Comfort Glow CHDV41N

Comfort Glow CHDV41N – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
Page: / 38

Table of Contents:

  • Page 2 – WARNING: Any change to; WARNINGS; DANGER: Carbon monoxide; Carbon Monoxide Poisoning:
  • Page 3 – OWNER’S MANUAL; LOCAL CODES; OPERATION
  • Page 4 – CLEARANCES; Figure 2 - Common Fireplace Locations; Flush with a wall; Figure 3 - Fireplace Bottom Dimensions
  • Page 5 – Continued; Figure 6 - Framing Clearances for Corner Installation; Location of Vent Termination; GENERAL VENTING; Figure 7 - Clearances for Combustible Mantels; Mantel Depth
  • Page 6 – Figure 8 - Minimum Clearances for Vent Terminations
  • Page 7 – WARNING: This gas fireplace; INSTALLATION PLANNING; For Horizontal Termination:; Installing Vent System in a Chase; WARNING: Never run the vent; For Vertical Termination:
  • Page 8 – Figure 10 - Snorkel Termination with Drainage Pipe; Adequate drainage; Figure 9 - Snorkel Termination; WARNING: Do not recess vent; Snorkel
  • Page 9 – Vent Opening; Figure 12 - Vent Opening Requirements; Note
  • Page 10 – Elbow; Horizontal Venting; CBVK Vent Kit Shown
  • Page 11 – Venting with Two 90; Elbows
  • Page 12 – Cathedral Ceiling Installation; Figure 22 - Installing Firestop
  • Page 13 – Vertical Termination Configurations; Figure 25 - Vertical Rigid Venting Configuration Using Two 90; Venting with One 90; Figure 26 - Vertical Rigid Venting Configuration Using One 90; finished ceiling
  • Page 14 – Vertical Venting; Figure 27 - Vertical Rigid Venting Configuration Using Two 90; CRVF Kit Shown
  • Page 15 – Number Description; Number Description; Comfort Glow Rigid Venting
  • Page 16 – CHECK GAS TYPE; Your fireplace is designed to be used; Blower Assembly
  • Page 17 – WARNING: Never touch the; Peel off the backing paper and stick the; WARNING: Failure to position; Connect or reconnect gas supply to fire-; b. If your fireplace system installation; Figure 30 - Mounting Blower to Firebox
  • Page 18 – Figure 35 - Gas Connection; Installation Items Needed; Cap Pipe Nipple Tee Joint
  • Page 19 – WARNING: Never use an open; flare union gas connector; Flare Union; Figure 36 - Attaching Flexible Gas Lines Together
  • Page 20 – Figure 37 - Manual Shutoff Valve; Open; Figure 39 - Checking Gas Joints for Natural Gas Fireplace; Gas Valve
  • Page 21 – WARNING: Installation must; The wire may be short-; WARNING: Do not connect; Set the temperature adjustment to the; Figure 41 - Back View of Thermostat Base; Terminal “W”; Figure 42 - Thermostat Base Terminals; Installing Battery into Receiver; Attach the terminal wires to the battery.; Figure 43- Attaching Battery to Receiver; Receiver
  • Page 22 – CAUTION: Do not operate this; Figure 46 - Removing/Replacing Glass Door; Screw
  • Page 23 – WARNING: If fireplace has; Figure 47 - Installing Rear Brick Panel and Retainer Brackets; Rear Brick Panel
  • Page 24 – WARNING: The glass door; Figure 50 - Installing Log Assembly No. 2; Ember Material
  • Page 25 – Figure 53 - Control Valve; Gas Control Knob
  • Page 26 – If you are; Do not leave the selec-
  • Page 27 – Thermocouple; To turn the pilot off, turn; Figure 56 - Pilot Assembly; • turn fireplace off (see To Turn Off Gas to
  • Page 28 – ment Parts on page 32.; VENTING SYSTEM
  • Page 29 – TROUBLESHOOTING; WARNING: Turn off heater; POSSIBLE CAUSE; nance, page 28) or replace pilot assembly; OBSERVED PROBLEM
  • Page 30 – nance, page 28) or replace burner orifice
  • Page 32 – SERVICE HINTS; When Gas Pressure Is Too Low:; WIRING DIAGRAM; CAUTION: Label all wires prior to disconnection when servicing; Use only original replacement parts.; PARTS UNDER WARRANTY
  • Page 33 – ACCESSORIES
  • Page 35 – PARTS LIST; DIRECT-VENT FIREPLACE; PART NUMBER
  • Page 38 – For information about this warranty write:; INTERNATIONAL; KEEP THIS WARRANTY; WARRANTY INFORMATION; Model; NOT A UPC
Loading the manual

DIRECT-VENT FIREPLACE

OWNER’S OPERATION AND INSTALLATION MANUAL

CHDV37N, CHDV37P,

CHDV41N, AND CHDV41P

Save this manual for future reference.

FOR YOUR SAFETY

WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch
• Do not use any phone in your building.
• I m m e d i a t e l y c a l l y o u r g a s s u p p l i e r f r o m a

neighbor’s phone. Follow the gas supplier’s
instructions.

• If you cannot reach your gas supplier, call the fire

department.

WARNING: Improper installa-
tion, adjustment, alteration, ser-
vice, or maintenance can cause
injury or property damage. Re-
fer to this manual for correct
installation and operational pro-
cedures. For assistance or ad-
ditional information consult a
qualified installer, service
agency, or the gas supplier.

*

Aftermarket: Completion of sale, not for purpose of resale, from the manufacturer

WARNING: If the information in this manual is not
followed exactly, a fire or explosion may result caus-
ing property damage, personal injury, or loss of life.

FOR YOUR SAFETY

Do not store or use gasoline or other flammable va-
pors and liquids in the vicinity of this or any other
appliance.

— Installation and service
m u s t b e p e r f o r m e d b y a
qualified installer, service
agency, or the gas supplier.

— This appliance is for use
only with indicated gas type.
It is not convertible for use
with other gases, unless a
certified kit is used.

REMOTE REQUIRES

TWO 9-VOLT

BATTERIES -

NOT INCLUDED

This appliance may be installed in an aftermarket* manufactured (mobile) home,
where not prohibited by state or local codes.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - WARNING: Any change to; WARNINGS; DANGER: Carbon monoxide; Carbon Monoxide Poisoning:

2 104605 DIRECT-VENT FIREPLACE (NATURAL/PROPANE/LP) CHDV37N/P AND CHDV41N/P SAFETYINFORMATION 1. This appliance is only for use with thetype of gas indicated on the rating plate.This appliance is not convertible for usewith other gases unless a certified kitis used. 2. For propane/LP fireplace, do n...

Page 3 - OWNER’S MANUAL; LOCAL CODES; OPERATION

3 104605 OWNER’S MANUAL REMOTE OFF ON PRODUCTIDENTIFICATION Install and use fireplace with care. Followall local codes. In the absence to local codes,use the current National Fuel Gas CodeANS Z223.1, also known as NFPA 54*(USA) or the current CAN/CGA-B149[.1 or.2] Installation Codes (Canada). *Avail...

Page 4 - CLEARANCES; Figure 2 - Common Fireplace Locations; Flush with a wall; Figure 3 - Fireplace Bottom Dimensions

4 104605 DIRECT-VENT FIREPLACE (NATURAL/PROPANE/LP) CHDV37N/P AND CHDV41N/P Fireplace size D x FW x RW 37" 18 1 / 2 " 37" 14" 41" 18 1 / 2 " 41" 18" PRE-INSTALLATIONPREPARATION LOCATION AND SPACEREQUIREMENTS Determine the safest and most efficient loca-tion for your C...

Other Comfort Glow Models

All Comfort Glow Other