Coleman F*FP - Manual
Coleman F*FP – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Unitary Products Group; BRAND LABEL; Rated in accordance with ARI Standard 110, utilization range “A”.
- Page 3 – HORIZONTAL DRAIN PAN CONVERSION
- Page 4 – Filter Access & Drain Pan Conversion / Coil Baffle; RETURN AIR DUCT; CENTER ACCESS PANEL; Dimensions & Duct Sizes; REAR; Dimensions
- Page 5 – DUCT CONNECTIONS; The model number will have the following format:; TXV Metering Device; Equipment should never be operated without filters.; SUSPENSION SUPPORT LOCATIONS FOR HORIZONTAL APPLICATIONS*; Indoor Coil Model
- Page 6 – REFRIGERANT LINE CONNECTION; Do One Breaker At A Time - to make sure wires; FAN RELAY
- Page 8 – LOW VOLTAGE CONTROL CONNECTION; All wiring must comply with local and national electrical code; LINE POWER CONNECTIONS; Line Power Connections; Blower Speed Connections; YEL; BRN
- Page 9 – Total Motor Amps
- Page 13 – Includes Return Air Filter and Largest Electric Heater.; Models
- Page 15 – Optional Dehumidification Humidistat contacts open on rise.; Air Handler Control Wiring; Single Stage Heat Pump Control Wiring; on F4FV model
- Page 16 – TROUBLESHOOTING GUIDE; PROBLEM
292043-UIM-B-0707
SINGLE PIECE
AIR HANDLERS
MODELS: F*FP
INSTALLATION MANUAL
ISO 9001
Certified Quality
Management System
SAFETY
This is a safety alert symbol. When you see this symbol on
labels or in manuals, be alert to the potential for personal
injury.
Understand and pay particular attention to the signal words
DANGER
,
WARNING
, or
CAUTION
.
DANGER
indicates an
imminently
hazardous situation, which, if not
avoided,
will result in death or serious injury
.
WARNING
indicates a
potentially
hazardous situation, which, if not
avoided,
could result in death or serious injury
.
CAUTION
indicates a potentially hazardous situation, which, if not
avoided
may result in minor or moderate injury.
It is also used to
alert against unsafe practices and hazards involving only property dam-
age.
Improper installation may create a condition where the operation of
the product could cause personal injury or property damage.
Improper installation, adjustment, alteration, service or mainte-
nance can cause injury or property damage. Refer to this manual
for assistance or for additional information, consult a qualified con-
tractor, installer or service agency.
This product must be installed in strict compliance with the installa-
tion instructions and any applicable local, state, and national codes
including, but not limited to building, electrical, and mechanical
codes.
TABLE OF CONTENTS
SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
SPECIFIC SAFETY RULES AND PRECAUTIONS . . . . . . . . . . . . . . . 2
SAFETY REQUIREMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
GENERAL INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
INSPECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
LIMITATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
CLEARANCES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
LOCATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
HORIZONTAL DRAIN PAN CONVERSION . . . . . . . . . . . . . . . . . . . . 3
DUCT CONNECTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
AIR FILTERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
SUSPENSION KITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
COIL METERING DEVICES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
REFRIGERANT LINE CONNECTION . . . . . . . . . . . . . . . . . . . . . . . . .6
ELECTRIC HEATERS & OPERATING CONTROLS . . . . . . . . . . . . . .6
LOW VOLTAGE CONTROL CONNECTION . . . . . . . . . . . . . . . . . . . .8
LINE POWER CONNECTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
BLOWER SPEED CONNECTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . .8
DRAIN CONNECTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
MAINTENANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
COIL CLEANING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
LUBRICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
CONDENSATE DRAINS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
LIST OF FIGURES
Plenum Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Typical Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Filter Access & Drain Pan Conversion / Coil Baffle . . . . . . . . . . . . . . . 4
Dimensions & Duct Sizes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Typical Horizontal Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
TXV Bulb Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Bulb Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Control Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Electric Heaters in Horizontal Configuration - Right Hand Air Flow . . .6
Line Power Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Blower Speed Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Cooling Models with Electric Heat Wiring . . . . . . . . . . . . . . . . . . . . . .14
Single Stage Heat Pump Control Wiring . . . . . . . . . . . . . . . . . . . . . . .14
LIST OF TABLES
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Installed TXV Sizes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Physical and Electrical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Electrical Data - Cooling Only (50 & 60 Hz) . . . . . . . . . . . . . . . . . . . . . 9
Conversion Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Electrical Data - 1 Ø - 208/230-1-60 . . . . . . . . . . . . . . . . . . . . . . . . . 10
Electrical Data - (For Single Source Power Supply) -
Copper Wire 1 Ø - 208/230-1-60 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Electrical Data - (For Multi-Source Power Supply) -
Copper Wire 1 Ø - 208/230-1-601 . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Electrical Data - 3 Ø - 208/230-3-60 . . . . . . . . . . . . . . . . . . . . . . . . . .12
Electrical Data - (For Single Source Power Supply) -
Copper Wire 3 Ø - 208/230-3-60 . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
Airflow Data for 230 Volt - Heat Pump Models . . . . . . . . . . . . . . . . . .13
Airflow Data for 208 Volt - Heat Pump Models . . . . . . . . . . . . . . . . . .14
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
292043-UIM-B-0707 2 Unitary Products Group SPECIFIC SAFETY RULES AND PRECAUTIONS 1. Install this air handler only in a location and position as specified inSECTION I of these instructions. 2. Always install the air handler to operate within the air handler’sintended maximum outlet air temperature. O...
292043-UIM-B-0707 Unitary Products Group 3 6. When an evaporator coil is installed in an attic or above a finishedceiling, an auxiliary drain pan should be provided under the coil asis specified by most local building codes. 7. Proper electrical supply must be available. 8. Clearances must also be t...
292043-UIM-B-0707 4 Unitary Products Group FIGURE 3: Filter Access & Drain Pan Conversion / Coil Baffle FILTER 4B - SIDE VIEW "S" BRACKET MUST BE USED TOFASTEN DUCT WORK TO FRONT OF UNIT RETURN AIR DUCT 3/4" PVC SOCKETSFOR HORIZONTALDRAIN APPLICATION HORIZONTALDRAIN PANPOSITION "...
