Champion Power Equipment 71000i - Manual

Safety Rules Rev 71000i-20100401 E 3 Safety Rules WARNING Read this manual thoroughly before operating your generator. Failure to follow instructions could result in serious injury or death. WARNING The engine exhaust from this product contains chemicals known to the state of California to cause can...

Safety Rules 4 Rev 71000i-20100401 E DANGER Fuel and fuel vapors are highly flammable and extremely explosive. Fire or explosion can cause severe burns or death. Unintentional startup can result in entanglement, traumatic amputation or laceration. When adding or removing fuel Turn the generator off ...

Controls and Features Rev 71000i-20100401 E 5 Controls and Features Read this owner’s manual before operating your generator. Familiarize yourself with the location and function of the controls and features. Save this manual for future reference. Generator (1) Fuel Lever Vent – Turn this valve to th...

Controls and Features 6 Rev 71000i-20100401 E Power Panel (1) Smart Throttle Switch (2) Output Indicator Light (green) – Remains ON during normal operating conditions. Shuts OFF when generator is overloaded. (3) Overload Indicator Light (red) –This light turns ON when the generator is overloaded and...

Controls and Features Rev 71000i-20100401 E 7 Parts Included Your 71000i Gasoline Powered Inverter Generator ships with the following parts: Spark Plug Socket Assembly 1 set Oil Container 1 piece DC Accessory Cord 1 piece

Assembly 8 Rev 71000i-20100401 E Assembly This unit ships from our factory without oil. It must be properly serviced with fuel and oil before operation. If you have any questions regarding the assembly of your generator, call our help line at 1-877-338-0999. Please have your serial number and model ...

Assembly Rev 71000i-20100401 E 9 Add Fuel 1. Use clean, fresh, regular unleaded fuel with a minimum octane rating of 85. 2. DO NOT mix oil with fuel. 3. Clean the area around the fuel cap. 4. Remove the fuel cap 5. Slowly add fuel to the tank. DO NOT overfill. Fill to the red level, visible on the f...

Operation 10 Rev 71000i-20100401 E Operation Generator Location Please consult your local authority. In some areas, generators must be registered with the local utility. Generators used at construction sites may be subject to additional rules and regulations. This generator must have at least five f...

Operation Rev 71000i-20100401 E 11 Do Not Overload Generator Capacity Follow these simple steps to calculate the running and starting watts necessary for your purposes. 1. Select the electrical devices you plan on running at the same time. 2. Total the running watts of these items. This is the amoun...

Operation 12 Rev 71000i-20100401 E Wattage Reference Chart Use the chart to determine approximate wattage requirements for your equipment. NOTE Starting watts can exceed three times the running watts. The values in the following table are approximate. Refer to your tool or appliance for actual watta...

Maintenance Rev 71000i-20100401 E 13 Maintenance The owner/operator is responsible for all periodic maintenance. WARNING Never operate a damaged or defective generator. WARNING Tampering with the factory set throttle control will void your warranty. WARNING Improper maintenance will void your warran...

Maintenance 14 Rev 71000i-20100401 E Air Filter 1. Loosen the cover screw and remove the maintenance cover. 2. Press the latch tab on the top of the air cleaner body, remove the air cleaner cover. 3. Remove the foam element. 4. Wash in liquid detergent and water. Squeeze thoroughly dry in a clean cl...

Specifications Rev 71000i-20100401 E 17 Parts Diagram

Specifications 18 Rev 71000i-20100401 E Parts List No. Part Number Description Qty. 1 KGE1000Ti-06610 Rear Case 1 2 KGE1000Ti-06601 Seal Strip of Rear Case 1 3 KGE1000Ti-06115 Inserter 4 4 KGE1000Ti-06310 Right Case 1 5 GB/T9074.4-1988 Cross plug assembly screw M6*12 2 7 KGE1000Ti-06401 Top Cover of...

Specifications 20 Rev 71000i-20100401 E Wiring Diagram

Warranty 22 Rev 71000i-20100401 E Warranty CHAMPION POWER EQUIPMENT 2 YEAR LIMITED WARRANTY Effective September 1, 2006. Replaces all undated warranties and all warranties dated before September 1, 2006. Warranty Qualifications Champion Power Equipment (CPE) will register this warranty upon receipt ...