Page 2 - FCC Statement for Remote Control Device; Have questions or need assistance?; Call our Customer Care Team Toll-Free at:
*We are always working to improve our products. Therefore, the enclosed product may differ slightly from the image on the cover. WARNING: The Engine Exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. FCC Statement ...
Page 3 - Wireless Remote, Electric Start; PORTABLE GENERATOR; TABLE OF CONTENTS
41532 Wireless Remote, Electric Start PORTABLE GENERATOR 9000 Starting Watts/7000 Running Watts TABLE OF CONTENTS Introduction 1 Introduction 1 Portable Power Generator 1 Accessories 1 This Booklet 1 Manual Conventions 2 Safety Rules 3 Controls and Features 5 Generator 5 Power Panel 6 Wireless Remot...
Page 4 - ENGLISH; Introduction; Model Number; INTRODUCTION
1 REV 41532-20140207 ENGLISH 41532 Introduction Congratulations on your purchase of a Champion Power Equipment generator. CPE designs and builds generators to strict specifications. With proper use and maintenance, this generator will bring years of satisfying service. Portable Power Generator This ...
Page 5 - MANUAL CONVENTIONS; CAUTION; DANGER; WARNING
REV 41532-20140207 2 41532 ENGLISH MANUAL CONVENTIONS This manual uses the following symbols to help differentiate between different kinds of information. The safety symbol is used with a key word to alert you to potential hazards in operating and owning power equipment.Follow all safety messages to...
Page 6 - SAFETy RULES; When servicing the generator:
3 REV 41532-20140207 ENGLISH 41532 SAFETy RULES Generator exhaust contains carbon monoxide, a colorless, odorless, poison gas. Breathing carbon monoxide will cause nausea, dizziness, fainting or death. If you start to feel dizzy or weak, get to fresh air immediately. Operate generator outdoors only ...
Page 7 - When adding or removing fuel :
REV 41532-20140207 4 41532 ENGLISH SAFETy RULES Improper treatment or use of the generator can damage it, shorten its life and void your warranty. Use the generator only for intended uses.Operate only on level surfaces.DO NOT expose generator to excessive moisture, dust, or dirt.DO NOT allow any mat...
Page 8 - Generator; CONTROLS AND FEATURES
5 REV 41532-20140207 ENGLISH 41532 Read this owner’s manual before operating your generator. Familiarize yourself with the location and function of the controls and features. Save this manual for future reference. (1) Fuel Tank – 5.9 gallon (22.4 L) capacity fuel tank. (2) Auto-Choke – Used to start...
Page 9 - Power Panel
REV 41532-20140207 6 41532 ENGLISH Power Panel 1 6 5 8 3 (1) Intelligauge™ – Three mode digital meter for displaying running hours, voltage and hertz. (2) Battery Switch – Enables /disables starting electrically – via remotely or by Ignition Switch. (3) Circuit Breakers – Protects the generator agai...
Page 10 - Wireless Remote Control; Remote Control Power Consumption
7 REV 41532-20140207 ENGLISH 41532 CONTROLS AND FEATURES Wireless Remote Control This generator is equipped with a wireless remote control system for starting and stopping. The system consists of (4) main components:1. Receiver Control Module (RCM)2. Wireless Remote3. Battery Switch4. Ignition Switc...
Page 11 - Parts Included; Wheel Kit
REV 41532-20140207 8 41532 ENGLISH Parts Included Your 41532 Gasoline Powered Generator ships with the following parts: Wheel Kit – 10 in. Wheel 2 – Flange Bolt (M10x120 for Wheel) 2 – Bushing 2 – Flat Washer 10 2 – Nut (M10) 2 – Support Leg w/ Vibration Mounts 1 – Flange Bolt (M8x16 for Support Leg...
Page 12 - ASSEMBLy; Remove the Generator from the Shipping Carton; Install the Wheel Kit; Connect the Battery
9 REV 41532-20140207 ENGLISH 41532 ASSEMBLy Your generator requires some assembly. This unit ships from our factory without oil. It must be properly serviced with fuel and oil before operation.If you have any questions regarding the assembly of your generator, call our help line at 1-877-338-0999. P...
Page 13 - Add Engine Oil; NOTE; Add Engine Oil Cont’d.
REV 41532-20140207 10 41532 ENGLISH 1. Place the generator on a flat, level surface. 2. Remove oil fill cap /dipstick to add oil.3. Add 1.16 qt (1.1 L) of oil (included) and replace oil fill cap/dipstick. DO NOT OVERFILL. 4. Check engine oil level daily and add as needed. The recommended oil type is...
Page 14 - Grounding; Add Fuel
11 REV 41532-20140207 ENGLISH 41532 ASSEMBLy Grounding Your generator must be properly connected to an appropriate ground to help prevent electric shock. A ground terminal connected to the frame of the generator has been provided on the power panel. For remote grounding, connect of a length of heavy...
Page 15 - OPERATION; Generator Location; Surge Protection
REV 41532-20140207 12 41532 ENGLISH OPERATION Generator Location NEVER operate the generator inside any building, including garages, basements, crawlspaces and sheds, enclosure or compartment, including the generator compartment of a recreational vehicle. Please consult your local authority. In some...
Page 16 - Recoil Start; Wireless Remote and Electric Start
13 REV 41532-20140207 ENGLISH 41532 OPERATION Recoil Start 1. Make certain the generator is on a flat, level surface.2. Turn off all electrical loads connected to the generator. Never start or stop the generator with electrical devices plugged in and turned on. 3. Turn the Fuel Valve to the “ON” pos...
Page 17 - Connecting Electrical Loads; Stopping the Engine
REV 41532-20140207 14 41532 ENGLISH Connecting Electrical Loads 1. Let the engine stabilize and warm up for a few minutes after starting 2. Plug in and turn on the desired 120/240 Volt AC single phase, 60 Hz electrical loads. – DO NOT connect 3-phase loads to the generator. – DO NOT connect 50 Hz lo...
Page 18 - Do Not Overload Generator; Capacity; Power Management
15 REV 41532-20140207 ENGLISH 41532 Do Not Overload Generator Capacity Follow these simple steps to calculate the running and starting watts necessary for your purposes. 1. Select the electrical devices you plan on running at the same time. 2. Total the running watts of these items. This is the amou...
Page 19 - Engine Maintenance; Oil; Air Filter; MAINTENANCE AND STORAGE
REV 41532-20140207 16 41532 ENGLISH The owner/operator is responsible for all periodic maintenance. Complete all scheduled maintenance in a timely manner. Correct any issue before operating the generator. Never operate a damaged or defective generator. Tampering with the factory set governor will vo...
Page 20 - Adjustments; Spark Arrester; Generator Maintenance
17 REV 41532-20140207 ENGLISH 41532 Adjustments The air-fuel mixture is not adjustable. Tampering with the governor can damage your generator and your electrical devices and will void your warranty. CPE recommends that you contact our service line at1-877-338-0999 for all other service and/or adjust...
Page 21 - Storage; Generator Storage; Remote Control Battery; Disconnect the Battery; Charge the Battery
REV 41532-20140207 18 41532 ENGLISH MAINTENANCE AND STORAGE Storage The generator should be started at least once every 14 days and allowed to run for at least 20 minutes. For longer term storage, please follow these guidelines. Generator Storage 1. Add a properly formulated fuel stabilizer to the t...
Page 22 - SPECIFICATIONS
19 REV 41532-20140207 ENGLISH 41532 Oil Use 10W-30 automotive oil.Oil capacity is up to 1.2 qt. (1.1 L). DO NOT OVERFILL.Please reference the following chart for recommended oil types for use in the generator. Fuel Fuel capacity is 5.9 gal. (22.4 L). Use regular unleaded gasoline with a minimum octa...
Page 23 - Wiring Diagram
REV 41532-20140207 20 41532 ENGLISH Wiring Diagram SPECIFICATIONS
Page 24 - Parts Diagram
21 REV 41532-20140207 ENGLISH 41532 SPECIFICATIONS Parts Diagram 1 2 3 4 5 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 38 43 44 45 37 38 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 6465 66 67 68 69 70 72 73 74 75 76 77 78 79 80 81 82...
Page 25 - Parts List
REV 41532-20140207 22 41532 ENGLISH Parts List # Part Number Description Qty 1 2.06.006 Clamp 3 2 152.070013.01 Pipe,Air Cleaner 1 3 2.05.001 Clamp 2 4 152.070014.03 Pipe,Reversal Valve 1 5 1.16674.0812 Flange Bolt M8 ×12 2 6 152.070702.03 Support Arm 1 7 152.070018.02 Board,Heat Insulation 1 8 1.57...
Page 26 - Engine Parts Diagram
23 REV 41532-20140207 ENGLISH 41532 SPECIFICATIONS Engine Parts Diagram 48 67 43 10 6 10 7 10 8 10 9 95 11 0 11 1 11 4 11 3 11 2 88 10 1 2 3 4 5 6 7 8 9 11 12 13 14 15 16 17 18 19 20 16 24 26 27 28 29 30 31 32 33 34 36 37 38 12 39 33 40 41 23 42 44 45 46 47 49 50 51 52 53 54 55 56 12 57 58 60 61 62 ...
Page 28 - TROUBLESHOOTING; For further technical support :
25 REV 41532-20140207 ENGLISH 41532 TROUBLESHOOTING For further technical support : Technical ServiceMon – Fri 8:30 AM – 5:00 PM (PST/PDT)Toll Free: 1-877-338-0999tech@ championpowerequipment.com Problem Cause Solution Generator will not start No fuel Add fuel Faulty spark plug Replace spark plug Un...
Page 29 - WARRANTy; Installation, Use and Maintenance Cont’d.
REV 41532-20140207 26 41532 ENGLISH WARRANTy WARRANT y CHAMPION POWER EQUIPMENT 2 YEAR LIMITED WARRANTY Warranty Qualifications Champion Power Equipment (CPE) will register this warranty upon receipt of your Warranty Registration Card and a copy of your sales receipt from one of CPE’s retail locatio...
