Burnham MST629 - Manual

Burnham MST629

Burnham MST629 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
49 Page 49
50 Page 50
51 Page 51
52 Page 52
53 Page 53
54 Page 54
55 Page 55
56 Page 56
57 Page 57
58 Page 58
59 Page 59
60 Page 60
61 Page 61
62 Page 62
63 Page 63
64 Page 64
Page: / 64

Table of Contents:

  • Page 3 – servicing or working nearby the appliance.
  • Page 4 – WARNING; fasteners completely when service is completed.; TABLE OF CONTENTS
  • Page 6 – TABLE 1B: RATING DATA
  • Page 8 – NOTICE; PROVIDE COMBUSTION AND VENTILATION; unconfined space; and suitable for use on Beckett AFG with; ii
  • Page 9 – MegaSteamTM Unit-Pak Boiler Assembly Shipment
  • Page 10 – SECURE BURNER SWING DOOR.
  • Page 11 – Figure 4: Boiler Removal from Skid
  • Page 14 – before; CAUTION; Boiler; Pass; Pass; None
  • Page 15 – When securing burner swing door make sure door
  • Page 18 – Do not apply pressure to gauge case, as this may
  • Page 20 – P. AqUASTAT CONTROLLER INSTALLATION; q. SAFETY VALVE AND DRAIN VALVE
  • Page 21 – Figure 10: Oil Burner Installation
  • Page 22 – EVALUATE THE ExISTING STEAM SYSTEM.; SECTION III: STEAM BOILER PIPING & TRIM; B. CONNECT SYSTEM SUPPLY AND RETURN; Maintain minimum 1⁄2 inch clearance from hot; chemistries if dielectric unions are not used.
  • Page 24 – SECTION IV: TANKLESS & INDIRECT WATER HEATER PIPING; CONNECT TANKLESS HEATER PIPING
  • Page 25 – Figure 1: Schematic Tankless Water Heater Piping; Boiler Model
  • Page 26 – as shown in Figure 13.
  • Page 27 – A. Chimney Venting; Chimney venting is an important part of a safe; Do not de-rate the appliance. Failure to fire the; SeCtiOn V: Venting & Air intAke piping; the requirements of NFPA 211.; B. Chimney COnneCtOr; DANGER; failure and force flue gases into the living
  • Page 28 – Figure 15: Proper and Improper Locations of Draft Regulator
  • Page 29 – cannot
  • Page 30 – E. MINIMUM CLEARANCES
  • Page 31 – Intake terminal must be at least 1 inches above; Do not locate air intake where petroleum distillates,
  • Page 32 – GENERAL; SECTION VI: ELECTRICAL; B. INSTALL A ROOM THERMOSTAT; once power is turned off.
  • Page 34 – WCO
  • Page 37 – SECTION VII: OIL PIPING; SINGLE PIPE OIL LINES
  • Page 38 – Maximum Length of Tubing
  • Page 40 – ADJUST OIL BURNER WHILE; Do not loosen or remove any oil line fittings while; Do not attempt to start the burner when excess oil
  • Page 41 – Figure
  • Page 42 – Flashes
  • Page 43 – Figure 6: Cad Cell Location; Jumper must be removed after this check.
  • Page 44 – Warning; AVOID Breathing Fiber Particulates and Dust; Precautionary Measures
  • Page 45 – SECTION Ix: MAINTENANCE AND SERVICE INSTRUCTIONS; MAINTENANCE OF LOW WATER CUT-; Do not attempt to repair mechanisms in the field.; BOILER AND SYSTEM CLEANING
  • Page 46 – Check with local authorities or consult local
  • Page 47 – ExCESSIVE MAKE-UP WATER; IMPORTANT; Our warranty
  • Page 48 – SECTION x: BOILER CLEANING; CLEAN THE FLUEWAYS; Do not start the burner unless the burner swing; Do not overtighten. The rope gasket will provide
  • Page 50 – COMBUSTION; SECTION xI: TROUBLE SHOOTING; OIL PRIMARY CONTROL
  • Page 51 – SECTION xII: REPAIR PARTS; If flame is not established within 15 seconds
  • Page 53 – BARE BOILER ASSEMBLy
  • Page 61 – BECKETT OIL BURNER PART NOS. FOR MEGASTEAMTM SERIES BOILERS; provide the name of the part(s) and part number as listed below.
  • Page 63 – SERVICE RECORD; DATE
  • Page 64 – Limited Warranty; FOR RESIDENTIAL CAST IRON STEAM BOILERS
Loading the manual

100618-01R4-5/08

As an

ENERGY STAR

®

Partner,

Burnham Hydronics

has determined that the

MST288, MST396, MST513 and

MST629 meet the

ENERGY STAR

®

guidelines for Energy

efficiency established by the

United States Environmental

Protection Agency (EPA).

Price - $3.00

D

N

A

G

N

I

T

A

R

E

P

O

,

N

O

I

T

A

L

L

A

T

S

N

I

R

O

F

S

N

O

I

T

C

U

R

T

S

N

I

E

C

I

V

R

E

S

™

m

a

e

t

S

a

g

e

M

R

E

L

I

O

B

L

I

O

S

S

A

P

-

3

g

n

i

k

e

e

s

n

e

h

W

.

r

e

il

p

p

u

s

li

o

r

o

r

o

t

c

a

r

t

n

o

c

g

n

it

a

e

h

r

u

o

y

ll

a

c

,r

e

li

o

b

o

t

s

r

i

a

p

e

r

r

o

e

c

i

v

r

e

s

r

o

F

g

n

it

a

R

n

o

n

w

o

h

s

s

a

r

e

b

m

u

N

l

a

i

r

e

S

d

n

a

r

e

b

m

u

N

l

e

d

o

M

r

e

li

o

B

e

d

i

v

o

r

p

,

r

e

li

o

b

n

o

n

o

it

a

m

r

o

f

n

i

.

r

e

li

o

b

e

h

t

f

o

p

o

t

n

o

d

e

t

a

c

o

l

l

e

b

a

L

r

e

b

m

u

N

l

e

d

o

M

r

e

li

o

B

r

e

b

m

u

N

l

a

i

r

e

S

r

e

li

o

B

e

t

a

D

n

o

it

a

ll

a

t

s

n

I

T

S

M

r

o

t

c

a

r

t

n

o

C

g

n

it

a

e

H

r

e

b

m

u

N

e

n

o

h

P

s

s

e

r

d

d

A

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 3 - servicing or working nearby the appliance.

3 DANGER DO NOT store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance. WARNING Improper installation, adjustment, alteration, service or maintenance can cause property damage, personal injury or loss of life. Failure to follow all instructions in t...

Page 4 - WARNING; fasteners completely when service is completed.; TABLE OF CONTENTS

4 WARNING This boiler contains very hot water under high pressure. Do not unscrew any pipe fittings nor attempt to disconnect any components of this boiler without positively assuring the water is cool and has no pressure. Always wear protective clothing and equipment when installing, starting up or...

Page 6 - TABLE 1B: RATING DATA

6 TABLE 1A: DIMENSIONAL DATA (SEE FIGURE 1) TABLE 1B: RATING DATA Boiler Model No. Dimensions (See Figure 1) Water Content (To Normal Water Line) - Gallons Heat Transfer Surface Area - sq. Ft. Actual Shipping Weight (LB.) "A" "B" "C" With Tankless Heater Non-Heater MST288 22-...

Other Burnham Models

All Burnham Other