Burnham 81433101R16-1/10 - Manual
Burnham 81433101R16-1/10 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – important information concerning product life.; DANGER
- Page 3 – or working nearby the boiler.
- Page 4 – for reference by owner and service technician.
- Page 5 – Figure 1: LEDV Packaged Boiler
- Page 7 – CAUTION; Do not drop boiler. Do not bump boiler jacket
- Page 9 – III. Water Piping and Trim; Design and install boiler and system piping; Absorption through open tanks and fittings.; Do not operate boiler with return water; order to regulate water flow for maintenance of; Safety (relief) valve discharge piping must be; WARNING; contamination of boiler water.
- Page 11 – Figure 6: Recommended Piping for Combination Heating &
- Page 12 – General Guidelines; DO NOT locate vent terminal where exposed to
- Page 13 – roof soffit at least 3 feet from an inside corner of an; Vent Installation; is required to maintain a 1 inch clearance to
- Page 14 – Figure 10: Vent Installation
- Page 15 – Figure 13: Air Intake Installation
- Page 16 – b. Slip appliance adapter over boiler flue collar and; Air Intake Installation; fittings available at most heating distributors.
- Page 17 – Remove the black plastic inlet cover from the right; Attach the Air Intake Terminal directly to the burner
- Page 18 – V. Electrical and Sequence of Operations; Figure 14: L48/L4 Setpoint and Differential
- Page 20 – Figure 1A: Riello BF Burner Schematic Wiring Diagram
- Page 21 – General; opened without disconnecting oil supply.; NOTICE; Single-pipe installations must be absolutely airtight
- Page 22 – Maximum Length of Tubing
- Page 23 – completely when service is completed.; bt
- Page 24 – Operating Sequence; Do not attempt to start the burner when excess; Air Tube; Table 6: Beckett AFII Burner
- Page 25 – Very hot flue gases come out of sight hole when; Delavan Oil; Table 6A: Riello BF Burner Settings
- Page 27 – fuel system and with a 2 foot length of tubing, fire; lower thermostat setting as required to start and stop; FOR HEATING SERVICEMAN; Simulate flame failure:; IMPORTANT; water supplied to the boiler which can significantly
- Page 29 – BURNER SHUTDOWN: Open Service Switch
- Page 30 – Low water cutoff
- Page 31 – Warning; AVOID Breathing Fiber Particulates and Dust; Precautionary Measures
- Page 32 – All LE; Item; Beckett R7184 Oil Primary Control
- Page 37 – BECKETT AFII BURNER REPLACEMENT PARTS; Beckett Part Number
- Page 38 – SERVICE RECORD; DATE
- Page 39 – minimum; connections specifically identified for Low Water Cut Off.
81433101R16-1/10
As an ENERGY STAR
®
Partner, Burnham Hydronics has determined that the LEDV1, fired at the 0.60 GPH rate,
meets the ENERGY STAR guidelines for Energy efficiency established by the United States Environmental Pro
-
tection Agency (EPA).
Price - $3.00
n
o
n
o
it
a
m
r
o
f
n
i
g
n
i
k
e
e
s
n
e
h
W
.r
o
t
c
a
r
t
n
o
c
g
n
it
a
e
h
r
u
o
y
ll
a
c
,
r
e
li
o
b
o
t
s
r
i
a
p
e
r
r
o
e
c
i
v
r
e
s
r
o
F
.l
e
b
a
L
g
n
it
a
R
n
o
n
w
o
h
s
s
a
r
e
b
m
u
N
l
a
i
r
e
S
d
n
a
r
e
b
m
u
N
l
e
d
o
M
r
e
li
o
B
e
d
i
v
o
r
p
,
r
e
li
o
b
r
e
b
m
u
N
l
e
d
o
M
r
e
li
o
B
V
D
E
L
r
e
b
m
u
N
l
a
i
r
e
S
r
e
li
o
B
e
t
a
D
n
o
it
a
ll
a
t
s
n
I
r
o
t
c
a
r
t
n
o
C
g
n
it
a
e
H
r
e
b
m
u
N
e
n
o
h
P
s
s
e
r
d
d
A
D
N
A
G
N
I
T
A
R
E
P
O
,
N
O
I
T
A
L
L
A
T
S
N
I
R
O
F
S
N
O
I
T
C
U
R
T
S
N
I
E
C
I
V
R
E
S
E
L
®
S
E
I
R
E
S
V
D
T
N
E
V
T
C
E
R
I
D
R
E
L
I
O
B
D
E
R
I
F
-
L
I
O
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
The following terms are used throughout this manual to bring attention to the presence of hazards of various risk levels, or to important information concerning product life. DANGER Indicates an imminently hazardous situation which, if not avoided, will result in death, serious injury or substantial...
3 DANGER DO NOT store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance. If you smell gas vapors, DO NOT try to operate any appliance - DO NOT touch any electrical switch or use any phone in the building. Immediately, call the gas supplier from a rem...
4 Table of Contents I. Pre-Installation ............................................................6 II. Unpack Boiler ..............................................................7 III. Water Piping and Trim .................................................9 IV. Venting/Air Intake Piping ...........
