Brinkmann Kettle Grill Manual - Free PDF Download

Page 2 - DANGER; IMPORTANT SAFETY; WARNINGS; Shut off gas to the appliance at the LP cylinder and burners.; WARNING

WE WANT YOU TO ASSEMBLE AND USE YOUR GRILL AS SAFELY AS POSSIBLE. THE PURPOSE OF THIS SAFETY ALERT SYMBOL IS TO ATTRACT YOUR ATTENTION TO POSSIBLE HAZARDS AS YOU ASSEMBLE AND USE YOUR GRILL. WHEN YOU SEE THE SAFETY ALERT SYMBOL PAY CLOSE ATTENTION TO THE INFORMATION WHICH FOLLOWS! READ ALL SAFETY WA...

Page 3 - USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR GAS GRILL.

2 WARNING • Never use natural gas in a unit designed for liquid propane gas. • Never use charcoal briquets or lighter fluid in a gas grill. • Leak test all connections before first use, even if grill was purchased fully assembled and aftereach tank refill. • Never check for leaks using a match or op...

Page 4 - CYLINDER SPECIFICATIONS:; LP GAS CYLINDER; DO NOT connect to a propane cylinder exceeding this capacity.; INSTALLATION INFORMATION:; The installation of this appliance must be in accordance with:; DO NOT install in or on a recreational vehicle and/or boat.

CYLINDER SPECIFICATIONS: When purchasing or exchanging a cylinder for your gas grill, it must be constructed and marked inaccordance with the specifications for LP gas cylinders of the U.S. Department of Transportation(DOT) or the National Standard of Canada, CAN/CSA-B339 as applicable with a listed...

Page 6 - FILLING THE LP GAS CYLINDER:; Check that the cylinder valve is closed by turning the

WARNING FILLING THE LP GAS CYLINDER: • Allow only qualified LP gas dealers to properly fill or repair your LP gas cylinder. • New tanks should be purged prior to filling; inform LP gas dealer if you are using a new tank. • DO NOT allow the cylinder to be filled beyond 80% capacity. Over-filled tanks...

Page 7 - CONNECTING HOSE AND REGULATOR TO AN LP GAS CYLINDER; Insure the tank valve is; Check that the grill’s burner knob is in the proper OFF position.

6 WARNING • Never use your grill without leak testing all gas connections and hoses. See the section on"Leak Testing" in this manual for proper procedures. The pressure regulator and hose assembly supplied with your gas grill is designed to work with anLP gas supply cylinder. • DO NOT attemp...

Page 8 - WHEN TO PERFORM A LEAK TEST:; Any time your grill has been moved.; Insure the burner knob is set to the OFF position.

LEAK TESTING: To prevent fire or explosion hazard: • DO NOT smoke or permit ignition sources in the area while conducting a leak test. • Perform test OUTDOORS only in a well ventilated area. • Never perform a leak test with a match or open flame. • Never perform a leak test while the grill is in use...

Page 9 - Turn OFF gas supply at cylinder valve.

WARNING 8 6. Check each place listed (A -J) for growing bubbles which indicates a leak. 7. Turn OFF gas supply at cylinder valve. 8. Turn on control knob to release gas pressure in hose. 9. Turn control knob to “off” position. 10. Tighten any leaking connections. 11. Repeat soapy water test until no...

Page 10 - LIGHTING INSTRUCTIONS:; Follow the instructions exactly.; MATCH LIGHTING THE BURNER:

Read, understand and follow all warnings and instructions contained in this manual. DO NOT skipany of the warnings and instructions contained in the preceding sections of this manual. LIGHTING INSTRUCTIONS: Follow the instructions exactly. 1. OPEN THE GRILL LID before attempting to light the burner ...

Page 11 - TURNING OFF THE GRILL:; Turn burner control knob to the OFF position.; BREAKING IN YOUR GRILL:

2”1”0” NOTE: Observe flame height when lit: Flame should be a Blue/Yellow color between 1”–2” high. TURNING OFF THE GRILL: 1. Turn OFF the LP tank valve. 2. Turn burner control knob to the OFF position. NOTE: Turn off LP cylinder first to prevent gas from being left in the system under pressure. CAU...

Page 12 - Trim excess fat from meats prior to cooking.; DO NOT extinguish grease fires using water.

CONTROLLING FLARE-UPS: • Flare-ups are a part of cooking meats on a gas grill. This adds to the unique flavor of cooking on agas grill. Excessive flare-ups can over-cook your food and cause a dangerous situation for you oryour grill. Excessive flare-ups result from the build-up of grease in the bott...

Page 13 - TRANSPORTING AND STORAGE:; Follow the instructions listed below.; BEFORE STORING YOUR GRILL:; Ensure that the fuel supply tank valve is fully closed.; CLEANING AND MAINTENANCE:

TRANSPORTING AND STORAGE: • Never move a grill when it is hot or when objects are on the cooking surfaces. • Make sure that cylinder valve is shut off. After moving the grill check that all gas connectionsare free of leaks. Check the venturi tubes to ensure they are properly connected to the valvesa...

Page 16 - GRILL COOKING TIPS; CLEANLINESS; following food items:; HELPFUL HINTS; If you pre-cook meat or poultry, do so immediately before grilling.; PROPER CARE & MAINTENANCE

• To protect your grill from excessive rust, the unit must be kept clean and covered at all times when not inuse. A grill cover may be ordered directly from Brinkmann by calling 1-800-468-5252 or 1-800-527-0717. • Wash cooking grill and heat shield with hot, soapy water, rinse well and dry. Lightly ...

Page 17 - ASSEMBLY INSTRUCTIONS; READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY; Pliers; before operating your grill.

PARTS LIST: 1 Kettle Grill Body 1 Dome lid 1 Heat shield 1 Bottom shelf/Tank support 1 Handle (with bolts and washers) 1 2 3 4 5 ASSEMBLY INSTRUCTIONS READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY BEFORE ASSEMBLING OR OPERATING YOUR GRILL. WE RECOMMEND TWO PEOPLE WORK TOGETHER WHEN ...

Page 18 - PARTS BAG CONTENTS; Your Parts Bag will include:

17 PARTS BAG CONTAINS: 2 Hood Nuts 2 Flat washers 3 #8 X 3/8" Sheet metal screws 2 Hood bolts 3 Wing bolts PARTS BAG CONTENTS Make sure you have all items listed under PARTS LIST and PARTS BAG CONTENTS beforeyou begin the installation process. Your Parts Bag will include: 3 - #8 X 3/8" Sheet...

Page 21 - NOTE: Lock casters to prevent

20 Step 6 With the help of a friend, carefullyturn the the grill to its uprightposition. Try to minimize stressplaced on the legs. NOTE: Lock casters to prevent grill from moving during final assembly. Step 7 Place dome lid on grill body andalign hinges. Step 8 Fasten hinges together using hoodbolts...

Page 24 - Brinkmann Gas Stainless Steel Kettle Grill (Assembled); LP GAS TANK NOT INCLUDED

23 IGNITER LOW OFF HIGH F O R O U T D O O R U S E O N L Y • Read and follow al l warnings an d instruction s in • Tu r n burner knob to HIGH and press igni ter • If burner does not ignite immed iately, turn bur n er knob to OF F, wait 5 min utes to al low gas to d is sipate and r epeat lightin g pro...

Page 25 - ACCESSORIES

PROFESSIONAL SHISH-KABOB SKEWERS These heavy-duty, 18" shish-kabob skewers are extra-long for fabulousrestaurant style kabobs. Made of rust resistant stainlesssteel to last for years. SET OF 12812-2904-0 ACCESSORIES 24 RIB RACK Chrome-plated rack can greatly increase the cookingcapacity of your ...

Page 26 - WHERE SMOKERS ARE SOLD, OR ORDER DIRECT BY CALLING; THE ULTIMATE 5-PIECE BBQ TOOL SET; MARINADE INJECTOR

ACCESSORIES LOOK FOR THESE AND OTHER BRINKMANN ACCESSORIES AT YOUR LOCAL RETAILER WHERE SMOKERS ARE SOLD, OR ORDER DIRECT BY CALLING 1-800-468-5252. THE ULTIMATE 5-PIECE BBQ TOOL SET You’ll be the envy of your fellow outdoor chefs withthis ultimate BBQ tool set. It’s sleek ergonomicdesign combined w...

Page 28 - ONE-YEAR LIMITED WARRANTY

Owner’s Manual for Models 810-3300-0 11/01, 2/02140-3300-0 For one-year from date of purchase, The Brinkmann Corporation warrants the Brinkmann Gas Stainless Steel Kettle Grillagainst defects due to workmanship or materials to the original purchaser. The Brinkmann Corporation’s obligationsunder this...