Vulcan VBP13I ML-126359 - Manuals

Page 2 - IMPORTANT FOR YOUR SAFETY; FOR YOUR SAFETY; IN THE EVENT OF A POWER FAILURE,

V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (09-09) 1 IMPORTANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL ELECTRICAL EQUIPMENT, WHO SHOULD PERFORM THE INITIAL FIELD START-UP AND ADJUSTMENTS OF THE EQUIPMENT COVERED BY THIS MANUAL. FOR YOUR SAF...

Page 3 - TABLE OF CONTENTS

V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (09-09) 2 TABLE OF CONTENTS IMPORTANT FOR YOUR SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

Page 4 - GENERAL; INTRODUCTION

V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (09-09) 3 GENERAL INTRODUCTION Vulcan-Hart Holding & Transport Cabinets and Banquet Carts are produced with quality workmanship and material. Proper installation, usage, and maintenance of your cabinet will result in many years of sat...

Page 5 - ELECTRICAL REQUIREMENTS; In the United States of America:

V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (09-09) 4 The cabinet should be thoroughly cleaned prior to putting into service. CLEANING: Use a mild soap and water solution to clean the interior of the unit. Never use harsh chemicals or abrasive pads to clean the unit. For efficient ...

Page 6 - DO NOT REMOVE THE; Verify that the power; OPERATION; CONTROLS; Power Indicator Light:

V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (09-09) 5 receptacle is not the proper grounding type, contact an electrician. DO NOT REMOVE THE GROUNDING PRONG FROM THIS PLUG. CAUTION: Verify that the power source matches the Serial Data Plate located on the lower back corner of the c...

Page 7 - OPERATING INSTRUCTIONS; . This will cause the heating

V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (09-09) 6 Thermostat Setting Approximate Temperature 1 100⁰F (37⁰C) 2 110⁰F (43⁰C) 3 120⁰F (49⁰C) 4 130⁰F (54⁰C) 5 140⁰F (60⁰C) 6 150⁰F (66⁰C) 7 160⁰F (71⁰C) 8 170⁰F (77⁰C) 9 180⁰F (82⁰C) 10 190⁰F (88⁰C) (Fig. 4) Models: VHFA9, VHFA18 POW...

Page 8 - CLEANING; UNPLUG ELECTRICAL; STAINLESS STEEL CARE

V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (09-09) 7 CLEANING Always UNPLUG ELECTRICAL POWER SUPPLY before cleaning. WARNING: DAILY: 1. Unplug electrical power supply. 2. Allow warmer to cool before cleaning. 3. Clean the interior of the cabinet with a mild soap and water. Never u...

Page 9 - MAINTENANCE; The Cabinet and its parts are; HOT; LOCKOUT / TAGOUT PROCEDURE; WARNING; Always perform the LOCKOUT / TAGOUT; In electrical box, place unit’s circuit breaker into OFF position.

V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (09-09) 8 surface. Then, on a daily basis, apply a high-quality stainless steel polish according to manufacturer’s instructions. Darkened areas, called “heat tint,” may appear on stainless steel exposed to excessive heat. Excessive heat c...

Page 10 - TROUBLESHOOTING; SYMPTOMS; SERVICE & PARTS INFORMATION; Service Parts

V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (09-09) 9 TROUBLESHOOTING SYMPTOMS POSSIBLE CAUSES REMEDY Cabinet not connected to power source. Connect cabinet to power source. ON/OFF switch not ON (VHFA series) Turn ON/OFF switch ON Check circuit breaker Check GFCI Moisture problem. ...

Page 11 - SPECIFICATIONS

V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (09-09) 10 SPECIFICATIONS MODEL NO. HEIGHT IN (mm) DEPTH IN (mm) WIDTH IN (mm) SHIPPING WT. Lb. (kg) VOLTS WATTS AMPS VB90 71.75" (1822) 42.75" (1086) 31.75" (806) 242# (110 kg) 120 2000 16.6 VB96 62" (1575) 29" (737) ...

Page 12 - WIRING DIAGRAMS

V SERIES FOOD HOLDING, TRANSPORT, & BANQUET CARTS F-41140 (09-09) 11 WIRING DIAGRAMS