Traulsen R & A Series - Manuals

Page 2 - TABLE OF CONTENTS

TABLE OF CONTENTS The serial tag is a permanently affixed sticker onwhich is recorded vital electrical and refrigeration dataabout your Traulsen product, as well as the modeland serial number. This tag is located in the upperright interior compartment on all reach-in/pass-thruand roll-in/roll-thru r...

Page 3 - II. RECEIPT INSPECTION

-2- II. RECEIPT INSPECTION All Traulsen products are factory tested for performanceand are free from defects when shipped. The utmostcare has been taken in crating this product to protectagainst damage in transit. All interior fittings have beencarefully secured and the legs or casters are boxed and...

Page 6 - SET; SET; REFRIGERATOR

-5- IV. a - REFRIGERATORS:Both refrigerators and freezers do not require manualdefrosting. During normal operation, a refrigeratorcontinuosly circulates above freezing cabinet air throughthe coil. A compressor “OFF” cycle occurs every hour tomelt any frost which may accumulate on the coil during the...

Page 7 - V. d” is recommended. Use on breaker strips

V. c - REPLACING THE GASKETS:To remove the gasket to be replaced, grasp it firmly byone corner and pull it out. Before attempting to install anew gasket, both the unit and the gasket itself must beat room temperature. Insert the four corners first byusing a rubber mallet (or hammer with a block of w...

Page 9 - Control System

-8- VII. The INTELA-TRAUL ® Control System VII. a - INTELA-TRAUL ® CONTROL FEATURES: 1- Internal Time Clock • Eliminates defrost time clock (refrigerator and freezer models only). • Defrost cycle can be quickly adjusted to suit individual location and use. • Must be set at power-up and reset after a...

Page 11 - LED FOR; DISCHARGE LINE

FREEZER SET ) ) ) INTELA-TRAUL ° F ° C -10- LED FOR ° F LED FOR ° C 3-DIGIT (RED)LED DISPLAY ALARM CANCELBUTTON DEFROST ICONW / LED DOOR OPEN ICONW / LED IRDA - INFRA REDDATA AQUISITION VII. INTELA-TRAUL ® (continued) VII. c - CONTROL PANEL: VII. d - PARTS ASSEMBLY: (Reach-In & Roll-In Cabinets)...

Page 13 - cannot

VII. INTELA-TRAUL ® (continued) -12- Listed below are the available parameters in the order they appear, using the down arrow key on the controller. You can use either the up or down arrow keys to scroll through the options. Thermostat Set Point High* Defrost Lockout 2 Thermostat Set Point Low Defro...

Page 17 - DEFROST ICON

This parameter allows a service technician to start a defrost cycle at any time. This parameterwill override any lockout settings. Follow the instructions to enter the customer access code on page 11. When the control displays Thermostat Set High, press the down arrow key until the control display r...

Page 18 - Setting

The defrost lockout parameters allow the customer to prevent the unit from going into a defrost cycle for two hours during a set timeframe. Customers can set up to four defrost lockout parameters. They are all programmed the same way. The parameters will be set for the time the lockout is to start. ...

Page 22 - VIII. TROUBLE SHOOTING GUIDE; FIND YOUR PROBLEM HERE

VIII. TROUBLE SHOOTING GUIDE -21- FIND YOUR PROBLEM HERE REMEDY 1. Condensing unit fails to start. a. Check if cord & plug has been disconnected. b. Check INTELA-TRAUL ® temperature setting. 2. Condensing unit operates for a. Are doors closing properly? prolonged periods or continuously. b. Dirt...

Page 24 - XII. STAINLESS STEEL OVERVIEW

-23- XII. a - INTRODUCTION:All Traulsen R & A Series Refrigerator, Freezer, Dual-Temp and Heated Cabinet models are constructed witha high quality 430 series, 20 gauge stainless steelexterior finish (front, sides and doors). The interiorfinish on these same R-Series models are constructedusing 3...

Page 26 - XV. WARRANTY INFORMATION; STANDARD DOMESTIC WARRANTY; INTERNATIONAL COMMERCIAL WARRANTY

XV. WARRANTY INFORMATION -25- STANDARD DOMESTIC WARRANTY TRAULSEN warrants new equipment to the original purchaser, when installed within the United States against defective material andworkmanship for one (1) year from the date of original installation. Under this warranty, TRAULSEN will repair or ...

Page 28 - Quality Refrigeration

Traulsen 4401 Blue Mound Road Fort Worth, TX 76106Phone: (800) 825-8220 Fax-Svce: (817) 740-6757Website: www.traulsen.com HOURS OF OPERATION: Monday thru Friday 7:30 am - 4:30 pm CST Quality Refrigeration © 2004 Traulsen - All Rights Reserved