South Bend GB/15PC - Manuals

S PECIFICATIONS M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 6 O PERATOR ’ S M ANUAL 1181887 REV 1 S P E C IFIC ATIO N S EXTERIOR DIMENSIONS Single-Deck Ovens 33" TOP VIEW SIDE VIEW FRONT VIEW 29.25" 42.875" 55" 29" 57.5" 26" 38" 1.25" 2.5&#...

S PECIFICATIONS M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 8 O PERATOR ’ S M ANUAL 1181887 REV 1 S P E C IFIC ATIO N S MINIMUM CLEARANCES ! WARNING There must be adequate clearance between the left side of the ovens and combustible construction. Minimum Clearance from Minimu...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS I NSTALLATION O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 9 IN S TA LLA TI ON I N ST AL L AT I O N NOTICE These installation procedures must be followed by qualified personnel or warranty will be void. Local codes regarding installation var...

I NSTALLATION M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 10 O PERATOR ’ S M ANUAL 1181887 REV 1 IN S TA LLA TI ON Step 2a: Installation of Legs on Single-Deck, SilverStar Models 1. Raise oven sufficiently to allow clearance for the legs to be attached. Use of a lift truck or...

I NSTALLATION M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 12 O PERATOR ’ S M ANUAL 1181887 REV 1 IN S TA LLA TI ON Step 2c: Installation of Legs on Double-Deck Ovens Double-deck oven can be shipped either already bolted together, or as two separate ovens to be boltedtogether ...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS I NSTALLATION O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 13 IN S TA LLA TI ON Step 3: Installation of Restraint (Only for Ovens with Casters) NOTICE For an appliance equipped with casters, (1) the installation shall be made with a connecto...

I NSTALLATION M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 18 O PERATOR ’ S M ANUAL 1181887 REV 1 IN S TA LLA TI ON Step 5: Install Down Draft Diverter (if applicable) NOTICE Installation must use approved CSA International down draft diverter supplied by Southbend. If the ove...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS I NSTALLATION O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 19 IN S TA LLA TI ON Step 6: Installation of Optional Open Rack Storage An option for single-deck Marathoner Gold ovens is to have open rack storage below the oven. Thefollowing desc...

I NSTALLATION M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 22 O PERATOR ’ S M ANUAL 1181887 REV 1 IN S TA LLA TI ON Step 8: Connect Gas Supply NOTICE The installation must conform with local codes, or in the absence of local codes, with the National Fuel Gas Code, ANSI Z223.1,...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS O PERATION O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 23 OPE R ATIO N O PERATION ! DANGER EXPLOSION HAZARD In the event a gas odor is detected, shut down equipment at the main shut off valve. Immediately callthe emergency phone number of y...

O PERATION M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 24 O PERATOR ’ S M ANUAL 1181887 REV 1 OP E R ATIO N Control Panel of STANDARD Models LIGHTS POWER ON OFF FAN MODE COOK COOL FAN SPEED HI LOW COOK TEMPERATURE COOK TIMER (MIN.) HEAT ON Power Switch Switch ON to use the ov...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS O PERATION O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 25 OPE R ATIO N Operation of STANDARD Models Models with Standard Controls operate much like a standard oven: you turn the oven ON and select acooking temperature. Two additional contro...

O PERATION M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 26 O PERATOR ’ S M ANUAL 1181887 REV 1 OP E R ATIO N Control Panel of CYCLE/COOK and HOLD Models LIGHTS POWER ON OFF FAN MODE COOK COOL FAN SPEED HI LOW TIME TEMP HOUR/MIN HEAT ON MIN/SEC HOLD START STOP CYCLE Oven Interi...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS O PERATION O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 27 OPE R ATIO N Operation of CYCLE/COOK and HOLD Models CYCLE/COOK and HOLD models have electronic controls that enable the oven to cook food at a specifiedcook-temperature for a specif...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS O PERATION O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 29 OPE R ATIO N Control Panel of PROGRAMMABLE Models

O PERATION M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 30 O PERATOR ’ S M ANUAL 1181887 REV 1 OP E R ATIO N Operation of Models with PROGRAMMABLE Controls Models with Programmable Controls can follow a recorded sequence of timed cooking periods, with anoption of the last peri...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS O PERATION O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 31 OPE R ATIO N 10. When you are done cooking, switch the Power Switch to OFF. To RECORD a cook program to use later, do the following: 1. Press the Program Mode On/Off button. 2. Selec...

O PERATION M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 32 O PERATOR ’ S M ANUAL 1181887 REV 1 OP E R ATIO N Control Panel of RACK TIMER Models LIGHTS POWER ON OFF HEAT ON TIME TEMP TIMER 4 TIMER 1 TIMER 5 TIMER 2 TIMER 3 RACK 4 RACK 1 RACK 5 RACK 2 RACK 3 ACTUAL TEMP CANCEL F...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS O PERATION O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 33 OPE R ATIO N Operation of RACK TIMER Models Rack Timer models have five independent timers, one for each rack. After loading a rack, you can start atimer for that rack. The control p...

C OOKING H INTS M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 34 O PERATOR ’ S M ANUAL 1181887 REV 1 COO K IN G H INT S C O O KI NG H I NT S In a standard (non-convection) oven, the air is relatively still and an insulating layer of moisture surroundsthe cooking food product. I...

C OOKING H INTS M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 36 O PERATOR ’ S M ANUAL 1181887 REV 1 COO K IN G H INT S Cooking Time Temperature Number of Racks Baked Goods Bread, 2 lb. loaf 35 min. 375°F 3 Biscuits 5-10 min. 400°F 5 Cornbread 18 min. 400°F 5 French Bread 10 mi...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS C LEANING O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 37 CLE ANING C LEANING Southbend equipment is sturdily constructed of the best materials and is designed to provide durableservice when treated with ordinary care. To expect the best per...

C LEANING M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 38 O PERATOR ’ S M ANUAL 1181887 REV 1 CL E ANI NG

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS A DJUSTMENTS O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 39 ADJ UST M E N TS A D J U ST M EN T S ! WARNING ADJUSTMENTS AND SERVICE WORK MAY BE PERFORMED ONLY BY A QUALIFIEDTECHNICIAN WHO IS EXPERIENCED IN, AND KNOW LEDGEABLE WITH, THE OPERA...

A DJUSTMENTS M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 40 O PERATOR ’ S M ANUAL 1181887 REV 1 ADJ UST M E N TS ADJUSTING DOOR CHAIN MECHANISM The door chain mechanism causes the left and right doors to open and close together. To adjust the doorchain mechanism, do the follo...

T ROUBLESHOOTING M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 42 O PERATOR ’ S M ANUAL 1181887 REV 1 TROU BLE S H OOTI N G T ROUBL ESHOOT ING ! WARNING ADJUSTMENTS AND SERVICE WORK MAY BE PERFORMED ONLY BY A QUALIFIEDTECHNICIAN WHO IS EXPERIENCED IN, AND KNOWLEDGEABLE WITH, TH...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS T ROUBLESHOOTING O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 43 TROU BLE S H OOTI N G TROUBLESHOOTING GUIDE The left column of the following table lists symptoms that indicate a problem, while the center and rightcolumns list the possible c...

T ROUBLESHOOTING M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 44 O PERATOR ’ S M ANUAL 1181887 REV 1 TROU BLE S H OOTI N G TROUBLESHOOTING GUIDE (continued) Symptom Possible Cause Check or Replace Bad flame switch. Check in series on micro amps. Minimum is 0.75 amps, no maximu...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS T ROUBLESHOOTING O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 45 TROU BLE S H OOTI N G BLOWER WHEEL REPLACEMENT To replace the blower wheel, do the following: 1. Remove racks and rack guides. 2. Remove rear air baffle in front of blower whee...

T ROUBLESHOOTING M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 46 O PERATOR ’ S M ANUAL 1181887 REV 1 TROU BLE S H OOTI N G Electrical Schematic for 120 Volt Models with Standard Controls

P ARTS M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 52 O PERATOR ’ S M ANUAL 1181887 REV 1 PA RT S P ART S NOTICE INSTALLATION OF OTHER THAN GENUINE SOUTHBEND PARTS WILL VOID THE W ARRANTYON THIS EQUIPMENT. The serial plate with voltage, model, and serial information is locate...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P ARTS O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 53 PARTS Front Panel and Flue Parts 1 2 Key Part Number Qty Description 1 1 1 7 7 8 6 7 1 Panel, front louver, co 2 1 1 8 1 8 3 8 1 Flue box, w/a, co * 4 4 4 0 5 0 2 1 Down draft diverter k...

P ARTS M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 54 O PERATOR ’ S M ANUAL 1181887 REV 1 PA RT S Door Parts

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P ARTS O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 55 PARTS Door Chain Mechanism Parts 1 2 3 4 5 7 9 6 8 Key Part Number Qty Description 1 1 1 6 4 5 2 3 4 Pivot rod 2 1 1 6 4 5 5 1 2 Nut, 3/8-16, hex head, right hand threaded 3 1 1 6 4 5 2 ...

P ARTS M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 58 O PERATOR ’ S M ANUAL 1181887 REV 1 PA RT S Control Panel Parts for Cycle/Cook and Hold Models (CCH Models) See drawing on following page. Key Part Number Qty Description 1-2 0 1 1 8 0 4 0 9 1 Control panel assembly, CCH, ...

P ARTS M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 62 O PERATOR ’ S M ANUAL 1181887 REV 1 PA RT S Control Panel Parts for Models with Rack Timer Controls (RT Models) See drawing on following page. Key Part Number Qty Description 1-2 2 1 1 7 9 6 4 7 1 Control panel assembly, R...

P ARTS M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 64 O PERATOR ’ S M ANUAL 1181887 REV 1 PA RT S Internal Gas Supply Parts 1 2 3 4 5 Key Part Number Qty Description 1 1 1 7 7 5 6 6 1 Switch, shutdown, SPDT, 15 amp 2 1 1 7 7 4 9 5 1 Bracket, shutdown switch mtg. 3 1 1 8 1 9 3...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P ARTS O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 65 PARTS Burner Compartment Parts

P ARTS M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 66 O PERATOR ’ S M ANUAL 1181887 REV 1 PA RT S Oven Interior and Fan Motor Parts 2 3 4 6 7 8 9 10 11 12 13 14 15 16 17 1 5 Key Part Number Qty Description 1 1 1 6 0 2 8 9 2 Thumb screw 1/4-20 x 3/4 2 1 1 7 9 2 2 5 1 Baffle, a...

P ARTS M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 68 O PERATOR ’ S M ANUAL 1181887 REV 1 PA RT S Leg Parts for Single-Deck SilverStar Models 1 2 3 5 4 Key Part Number Qty Description 1 1 1 7 7 8 4 9 4 Single deck leg, SilverStar (for legs with feet) 2 1 1 7 7 8 5 0 4 Single ...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P ARTS O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 69 PARTS Leg Parts for Single-Deck Marathoner Gold Models 1 2 3 5 4 Key Part Number Qty Description 1 1 1 7 5 0 9 0 4 Single deck leg, M-Gold (for legs with feet) 2 1 1 7 5 0 8 9 4 Single d...

P ARTS M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 70 O PERATOR ’ S M ANUAL 1181887 REV 1 PA RT S Storage Rack Parts 1 2 3 4 5 6 7 Key Part Number Qty Description 1-7 1 1 7 5 5 0 6 1 Cooling rack kit, with shelf, shallow depth 1 1 7 5 5 0 7 1 Cooling rack kit, with shelf, bak...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P ARTS O PERATOR ’ S M ANUAL 1181887 REV 1 P AGE 71 PARTS Double-Deck Oven Stacking Parts 1 2 3 4 5 2 6 Key Part Number Qty Description 1 1 1 4 6 9 0 4 1 3/4" elbow 2 1 1 7 5 1 4 9 2 3/4" x 13-1/4" pipe 3 P - 5 2 3 9 - 5 1 3/4...

P ARTS M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 72 O PERATOR ’ S M ANUAL 1181887 REV 1 PA RT S Leg Parts for Double-Deck Ovens 1 2 1 3 4 Key Part Number Qty Description 1 1 1 7 2 7 8 8 4 Leg pad 2 1 1 7 4 2 5 9 4 SS leg, 3/4" stud * 1 1 7 4 2 6 0 1 Leg package (set of ...

M ARATHONER G OLD & S ILVER S TAR G AS C ONVECTION O VENS P AGE 76 O PERATOR ’ S M ANUAL 1181887 REV 1 Marathoner Gold & SilverStar GAS CONVECTION OVENS A product with the Southbend name incorporates the best in durability and low maintenance. Weall recognize, however, that replacement parts...