Senco PC2016 - Manuals - manualsarea.com

Page 2 - TABLE OF CONTENTS

2 Senco ® Electric Air Compressor Manual 2004 TABLE OF CONTENTS INTRODUCTION ......................................................................... 3 SAFETY ALERT ......................................................................... 3 INSPECTION ..................................................

Page 3 - INTRODUCTION

Senco ® Electric Air Compressor Manual 2004 3 SAFETY ALERT! A " DANGER, WARNING or CAUTION " safety warning will be surrounded by a "SAFETY ALERT BOX". This box is used to designate and emphasize Safety Warnings that must be followed when operating this air compressor. Accompanying t...

Page 4 - SAFETY WARNINGS

4 Senco ® Electric Air Compressor Manual 2004 POTENTIAL CONSEQUENCE PREVENTION RISK OF ELECTRIC SHOCK OR ELECTROCUTION Serious injury or death could occur if the air compressor is not properly grounded. Your air compressor is powered by electricity and may cause electric shock or electrocution if no...

Page 8 - PC2016 ELECTRIC AIR COMPRESSOR FEATURES

8 Senco ® Electric Air Compressor Manual 2004 PC2016 ELECTRIC AIR COMPRESSOR FEATURES PDAC047-062304-DLG

Page 10 - CAUTION; or longitudinally more than 10°.; with or without yellow stripes is the grounding wire.; PREPARATION; WARNING

10 Senco ® Electric Air Compressor Manual 2004 INITIAL SET-UP: 1. Read safety warnings before setting-up air compressor. 2. Ensure the oil level in the air compressor pump is adequate. The oil level should be at the center of the oil sight glass. If low, add Senco ® part number PC0344 compressor pum...

Page 11 - OPERATION; pressure is in the air tank!; MAINTENANCE

Senco ® Electric Air Compressor Manual 2004 11 OPERATION PRE-START CHECKLIST: 1. Check oil level. Add if necessary. 2. Remove any moisture in the air compressor air tank. Remove excessive pressure with an air tool, then open the air tank drain valve in the bottom of the air tank. Close tightly when ...

Page 12 - TROUBLESHOOTING; Motor will not run or restart.; REMEDY; SYMPTOM

12 Senco ® Electric Air Compressor Manual 2004 TROUBLESHOOTING 1. Motor will not run or restart. REMEDY Plug cord into grounded outlet. Move switch to "AUTO" position. Turn air compressor off, wait until motor is cool, then press motor thermal overload (red) button ﬁrmly until click is heard...

Page 13 - Air leaks from safety relief valve.

Senco ® Electric Air Compressor Manual 2004 13 TROUBLESHOOTING 3. When in the Start/Stop option, motor runs continuously. REMEDY Move the motor/pressure switch to the "Off" position. If the motor doesn't shut off, unplug the air compressor. If the electrical contacts are welded together, rep...

Page 14 - Insufficient pressure at air tool or accessory.; Oil has milky appearance.; Air compressor not making enough air.; Excessive oil consumption in pump.

14 Senco ® Electric Air Compressor Manual 2004 TROUBLESHOOTING REMEDY Adjust pressure regulator knob to proper setting or replace. Clean or replace. Check for leaks and repair. Replace with larger hose or connectors. Tighten or replace. Check the accessory air requirement. If it is higher than the C...

Page 15 - SPECIFICATIONS

Senco ® Electric Air Compressor Manual 2004 15 SPECIFICATIONS Model # PC2016 Motor Horsepower 1.5 Voltage 115 Amperage 13.2 HZ 60 Phase 1 RPM 1725 S.F. 1.2 Compressor Pump Number of Cylinders 2 Compression Stages 1 Bore/Stroke 2.5" x 1.88" RPM 730 Flywheel 10" Lubrication Splash Oil Quan...

Page 16 - SENCO COMPRESSOR AND PARTS WARRANTY

16 Senco ® Electric Air Compressor Manual 2004 SENCO COMPRESSOR AND PARTS WARRANTY This compressor has been designed and constructed using the highest standards of material and workmanship. COMPRESSOR WARRANTY: The length of this guarantee is one year (two years on the pump) from date of purchase by...