Razor MX650 - Manuals - manualsarea.com

Page 3 - BefOre yOu BegIn; required Tools; MAKE SURE POWER SWITCH IS TURNED “OFF” BEFORE CONDUCTING ANY; estimated assembly and set-up Time

BefOre yOu BegIn 2 warnIng: DO NOT USE NON-RAZOR PRODUCTS WITH YOUR RAZOR DIRT ROCKET. The Dirt Rocket has been built to certain Razor design specifications. The original equipment supplied at the time of sale was selected on the basis of its compatibility with the frame, fork and all other parts. C...

Page 4 - attaching the Handlebars; attaching the front fender

3 asseMBly anD seT-up 1 Using a 6mm hexagonal key wrench, remove bolts from handlebar clamp. Note: Handlebar clamps are located in the plastic bag. 2 Place handlebars in handle- bar clamp and adjust angle parallel to the fork. 3 Insert bolts and tighten securely. When properly tightened, the handleb...

Page 5 - charging the Battery; Inflating the Tires

4 charging the Battery Your electric motorbike may not have a fully charged battery; therefore it is a good idea to charge the battery prior to use. • Initial charge time: 18 hours • Up to 40 minutes of continuous ride time • Recharge time: up to 12 hours, • Average battery life: 250 charge/discharg...

Page 6 - repaIr anD MaInTenance; Installing the front wheel

warnIng: The brake is capable of causing the electric motorbike to skid the tire throwing an unsuspecting rider. Practice in an open area free from obstacles until you are familiar with the brake function. Avoid skidding to a stop as this can cause you to lose control or damage the rear tire. 5 repa...

Page 8 - checking spoke Tension

7 need Help? Visit our web site for replacement parts, product support and a list of authorized service centers at www.razor.com or call toll-free at 866-467-2967 Monday - Friday 8:00 AM - 5:00 PM Pacific Time . 4 Close the fuse cover and reattach the seat fairing. repaIr anD MaInTenance q checking ...

Page 9 - chain and sprocket

repaIr anD MaInTenance q chain and sprocket The chain will typically have a “loose spot” and “tight spot” corresponding with a particular sprocket rotational position. This is normal and common to all chain-driven products due to run-out tolerances of the freewheel and sprocket. The chain should be ...

Page 10 - TrOuBlesHOOTIng guIDe

9 Motor bike does not run Motor bike was running but suddenly stopped Short run time (less than 15 minutes per charge) Motor bike runs sluggishly Sometimes the motor doesn’t run, but other times it does Vehicle does not stop when applying the brake Vehicle makes loud noises or grinding sounds TrOuBl...

Page 12 - PROVIDED, YOU SHOULD CONTACT YOUR INSURANCE COMPANY OR AGENT.

SB 1918 (CALIFORNIA) DECLARATION YOUR INSURANCE POLICIES MAY NOT PROVIDE COVERAGE FOR ACCIDENTS INVOLVING THE USE OF THIS SCOOTER/ELECTRIC VEHICLE. TO DETERMINE IF COVERAGE IS PROVIDED, YOU SHOULD CONTACT YOUR INSURANCE COMPANY OR AGENT. 11

Page 13 - warranTy; loose parts; safeTy reMInDers; DO nOT reTurn TO sTOre; Do not use this product for the first time until you

Tire Inflation Periodically inspect the tires for excess wear and replace as required, and regularly check the tire pressure and re-inflate as necessary. If you get a flat tire, the inner tube can be patched or a new tube can be purchased from Razor or an authorized repair center. safety gear Always...