Razor 15130412 - Manuals - manualsarea.com

Page 2 - SAFETY WARNINGS

WARNING: Riding the Sport Mod can be a hazardous activity. Certain conditions may cause the equipment to fail without fault of the manufacturer. Like other electric vehicles, the Sport Mod can and is intended to move, and it is therefore possible to lose control, fall off and/or get into dangerous s...

Page 3 - Estimated Assembly and Set-Up Time; BEFORE YOU BEGIN; Required Tools; or call toll-free at

Remove contents from box. Remove the foam separators that protect the components from damage during shipping. Inspect the contents of the box for scratches in the paint, dents or kinked cables that may have occurred during shipping. Because the Sport Mod was 95 percent assembled and packed at the fa...

Page 4 - Charging the Battery; Attaching the Handlebars

3 ASSEMBLY AND SET-UP q Charging the Battery Your Sport Mod may not have a fully charged battery; therefore you must charge the battery prior to use. • Initial charge time: 12 hours • Run time: up to 40 minutes • Recharge time: up to 8 hours • Average battery life: 250 charge/discharge cycles • Full...

Page 5 - REPAIR AND MAINTENANCE; Adjusting the Brakes

4 REPAIR AND MAINTENANCE WARNING: The brake is capable of skidding the tire and throwing an unsuspecting rider. Practice in an open area free from obstacles until you are familiar with the brake function. Avoid skidding to a stop as this can cause you to lose control or damage the rear tire. Note: T...

Page 6 - Chain and Rear Tire Replacement

5 REPAIR AND MAINTENANCE q Chain and Rear Tire Replacement Tools required: Phillips screwdriver, 10mm wrench, two (2) 8mm wrenches, and two (2) 17mm wrenches. 1 With a Phillips screwdriver, remove the screws that secure the chainguard. Remove chainguard. 2 With a 10mm wrench, loosen the brake cable ...

Page 7 - Replacing the Fuse

6 q Battery Care and Disposal Do not store the battery in temperatures above 75° or below -10° F. CONTAINS SEALED LEAD BATTERY. BATTERY MUST BE RECYCLED. Disposal: Your Razor product uses sealed lead-acid batteries which must be recycled or disposed of in an environmentally sound manner. Do not disp...

Page 8 - TROUBLESHOOTING GUIDE

7 Vehicle does not run Vehicle was running but suddenly stopped Short run time (less than 30 minutes per charge) Vehicle runs sluggishly Problem Possible Cause Solution Undercharged battery Charger is not working Loose wires or connectors Blown fuse Undercharged battery Battery is old and will not a...

Page 10 - SPORT MOD PARTS

Keep your Sport Mod running for years with genuine Razor parts. Visit our web site or e-mail us for more information on spare part availability. (Specifications subject to change without notice.) SPORT MOD PARTS 9 01 Handlebar grip (right/left) 02 Brake lever assemble complete 03 Handlebar 03-1 6mm ...

Page 13 - WARRANTY; Loose Parts; SAFETY REMINDERS; DO NOT RETURN TO STORE; Do not use this vehicle for the first time until you

Tire Inflation Periodically inspect the tires for excess wear, and regularly check the tire pressure and re-inflate as necessary. If you get a flat tire, the inner tube can be patched or a new tube can be purchased from Razor or an authorized repair center. Safety Gear Always wear proper protective ...