Razor 15120040 - Manuals - manualsarea.com

Page 3 - estimated assembly and set-up Time; BefOre yOu BegIn; required Tools

Remove contents from box. Remove the foam separators that protect the components from damage during shipping. Inspect the contents of the box for scratches in the paint, dents or kinked cables that may have occurred during shipping. Because the Pocket Rocket is 95 percent assembled and packed at the...

Page 4 - attaching the Handlebars; attaching the fairing

3 asseMBly anD seT-up 1 Swing the handlebars outward as shown. You may have to loosen the clamps to allow the bar to pivot on the fork. 2 Using a 6mm hex key wrench, tighten both the left and right side handlebar clamps by turning the screws clockwise. When properly tightened, the handlebars cannot ...

Page 5 - charging the Battery; repaIr anD MaInTenance; adjusting the Brakes

q charging the Battery Your electric motor bike may not have a fully charged battery; therefore it is a good idea to charge the battery prior to use. • Initial charge time: 18 hours • Run time: Up to 40 minutes of continuous ride time • Recharge time: up to 12 hours, • Average battery life: 250 char...

Page 6 - chain and rear Tire replacement

5 repaIr anD MaInTenance q chain and rear Tire replacement Tools required: 10mm wrench, two (2) 8mm wrenches, and two (2) 17mm wrenches. 2 With a 10mm wrench, loosen the brake cable anchor and disconnect the cable. 3 With two 8mm wrenches, loosen brake housing anchor and disconnect. Keep the spacer ...

Page 7 - chain and sprocket

6 repaIr anD MaInTenance q chain and sprocket The chain will typically have a “loose spot” and “tight spot” corresponding with a particular sprocket rotational position. This is normal and common to all chain-driven products due to run-out tolerances of the freewheel and sprocket. The chain should b...

Page 8 - TrOuBlesHOOTIng guIDe

7 Motor bike does not run Motor bike was running but suddenly stopped Short run time (less than 30 minutes per charge) Motor bike runs sluggishly TrOuBlesHOOTIng guIDe problem possible cause solution Undercharged battery Charger is not working Loose wires or connectors Tripped circuit breaker Motor ...

Page 10 - pOckeT rOckeT parTs

9 Keep your Pocket Rocket running for years with genuine Razor parts. Visit our web site or e-mail us for more information on spare part availability. (Specifications subject to change without notice.) pOckeT rOckeT parTs 1. Handlebar Grip (Right/Left) 1-1. Handlebar End Cap/Extender Holder 1-2. Val...

Page 13 - warranTy; loose parts; safeTy reMInDers; DO nOT reTurn TO sTOre; Do not use this product for the first time until you

Tire Inflation Periodically inspect the tires for excess wear and replace as required, and regularly check the tire pressure and re-inflate as necessary. If you get a flat tire, the inner tube can be patched or a new tube can be purchased from Razor or an authorized repair center. safety gear Always...