Page 3 - Safe Operating Practices
3 www.napoleongrills.com WARNING! Failure to follow these instructions could result in property damage, personal injury or death. Read and follow all warnings and instructions in this manual prior to operating this gas patio torch. Safe Operating Practices • Read the entire instruction manual before...
Page 4 - General Information; Propane Cylinder Specifications; Gas Hook-Up Instructions
4 www.napoleongrills.com General Information This gas torch is certified under Canadian and American national standards, CSA 2.37a – 2008 and ANSI Z83.26a - 2008 respectively for outdoor patio heaters and must be installed to conform with local codes.When an appliance is for connection to a fixed pi...
Page 5 - Loop Strapping through slots in
5 www.napoleongrills.com Propane Cylinder Installation : Set cylinder into hole in bottom shelf. Tighten strap over cylinder to secure it in place. Cylinder Connection : Ensure the gas regulator hose is kink free. Remove the cap from the cylinder fuel valve. Insert the black QCC1 regulator nipple on...
Page 6 - Leak Testing Instructions
6 www.napoleongrills.com Leak Testing Instructions WARNING! A leak test must be performed annually and each time a cylinder is hooked up or if a part of the gas system is replaced. WARNING! Never use an open flame to check for gas leaks. Be certain no sparks or open flames are in the area while you ...
Page 7 - Lighting Instructions; Lighting Holes
7 www.napoleongrills.com Lighting Instructions WARNING! Never use the torch while it is raining, the glass tube could crack or break causing serious injury. WARNING! Ensure burner controls are in the off position. Slowly turn on the gas supply valve. 1. Turn burner control to ‘LIGHT’ position. 2. Pr...
Page 8 - Operating The Patio Torch
8 www.napoleongrills.com Operating The Patio Torch Initial Lighting : When lit for the first time, the patio torch emits a slight odor. This is a normal temporary condition caused by the “burn-in” of internal paints and lubricants used in the manufacturing process and does not occur again. Simply ru...
Page 9 - Maintenance / Cleaning Instructions
9 www.napoleongrills.com WARNING! Always wear protective gloves and safety glasses when cleaning your patio torch. WARNING! To avoid the possibility of burns, maintenance should be done only when the patio torch is cool. Avoid unprotected contact with hot surfaces. Ensure burner is turned off. Turn ...
Page 10 - Troubleshooting
10 www.napoleongrills.com Troubleshooting Problem Possible Causes Solution Low heat / Low flame when valve turned to high. For propane - improper lighting procedure. For natural gas - undersized supply line. Ensure lighting procedure is followed carefully. The valve must be in the off position when ...
Page 11 - Getting Started; Pour Commencer; OUTILS REQUIS POUR L’ASSEMBLAGE (outils non inclus)
25 www.napoleongrills.com ATTENTION! Lors du déballage et de l’assemblage, nous vous conseillons de porter des gants de travail et des lunettes de sécurité pour votre protection. Malgré tous nos efforts pour assurer que l’assemblage soit aussi sécuritaire et sans problème que possible, il se peut qu...
Page 17 - Natural Gas Only – Proper Hose Connection
31 www.napoleongrills.com Propane Only – Proper Hose Connection WARNING! Ensure the hose does not contact any high temperature surfaces, or it may melt and leak causing a fire. Propane Seulement - Branchement Adéquat Du Boyau AVERTISSEMENT! Assurez-vous que le boyau ne touche à aucune surface à haut...
Page 19 - Parts List
34 www.napoleongrills.com Item # Description/Part # Qty Picture Comments 1 Middle Plate - LH230-1-3-0 1 2 Control Box Assy - LH200-30 Includes: Burner LP - LH100-3-8-0 Burner NAT - LH200-3A-8-0 Pilot LP - LH100-3-7A-0 Pilot NAT - LH200-3A-7-0 Valve Assy LP - LH200-3-2-0 Valve Assy NAT - LH200-3A-2-0...
Page 21 - KEEP YOUR RECEIPT AS PROOF OF PURCHASE TO VALIDATE YOUR WARRANTY.; Ordering Replacement Parts; Warranty Information
11 www.napoleongrills.com KEEP YOUR RECEIPT AS PROOF OF PURCHASE TO VALIDATE YOUR WARRANTY. Ordering Replacement Parts Warranty Information MODEL: DATE OF PURCHASE: SERIAL NUMBER: (Record information here for easy reference)Before contacting the Customer Care Department, check the NAC Website for mo...
Page 22 - ACCESSORIES & PARTS ORDER FORM
38 www.napoleongrills.com FAX TO: 705 727 4282 CONTACT NAME:______________________________________________________________________ SHIP TO :_____________________________________________________________________________ __________________________________________________________________________________...