Napoleon OS10-3 - Manuals - manualsarea.com

Page 2 - INTRODUCTION; WARNING; PLEASE RETAIN THIS MANUAL FOR FUTURE; TABL OF CONTENTS

INTRODUCTION Document n° 1092-1 EN ~ 04/02/2002 2 WARNING • The stove is an oil-fired stove. Do not burn wood or other materials in this stove.• Adults and especially children should be alerted to the hazards of high surface temperatures and should stay away to avoid burns or clothing ignition. Supe...

Page 3 - NAPOLEON OIL STOVE PRESIDENT’S LIFETIME LIMITED WARRANTY; CONDITIONS AND LIMITATIONS

NAPOLEON oil stoves are manufactured under the strict Standard of the World Recognized ISO9001 Quality Assurance Certificate. NAPOLEON products are designed with superior components and materials, assembled by trained craftsmen who take great pride in their work. The complete stove is thoroughly ins...

Page 4 - General information; Care of enamelled parts; INSTALLATION; Unit and specifications; Figure 1

General information Nominal heat output Oil consumption ** Chimney draft required Weight Flue outlet outside diameter max speed min speed max speed min speed 34.100 BTU/hr .31 US gal/hr .066 US gal/hr .072" w.c.g .032" w.c.g 260 lbs 5 inches 10 kW 1.20 litre/h 1/4 litre/h 18 Pa 8 Pa 118 kg 1...

Page 5 - Figure 2

Location and clearances If the stove is to be installed on a combustible floor, it must be installed on sheet metal or a tile. The oil drip tray, 72636 (not supplied) is a suitable substitute for either of these two pads.Maintain these minimum clearances to combustibles (fig. 2) : A 12 inches (300 m...

Page 6 - Chimney specifications; Chimney installation; Connection to a A-VENT chimney; Connection to a L-VENT chimney; Adding chimney sections; Figure 3

THE TOTAL SMOKE PIPE LENGTH SHOULD NOT EXCEED 40% OF THE CHIMNEY HEIGHT ABOVE THE STOVE TO A MAXIMUM HORIZONTAL RUN OF 10 FEET. All smoke pipe must slope upwards at a minimum of 1/4" per foot (6 mm/0.3m) and all connections must be tight and secured by three sheet metal screws equally spaced. An...

Page 7 - FINISHING; Mounting flue collar; FUEL SUPPLY; Figure 5; Figure 6

FINISHING Mounting flue collar The stove is supplied with a connection flue at rear. Smoke exit on top (figure 12, page 8) : - Remove the internal baffles on top (see page 11). - Fix the sealing rope in the groove on the top (2) and fit the flue spigot (1), ensuring there is a good seal. - Fix the s...

Page 9 - OPERATING INSTRUCTIONS; Understanding your oil stove

OPERATING INSTRUCTIONS Understanding your oil stove Furnace oil is fed from the tank to the burner floor ‘ A ’ where is it ignited by means of a firestarter. The heat produced by this flame brings the burner temperature to the required level to vaporize the fuel. Oil will only burn as a vapour not a...

Page 10 - Shut down; ADJUSTMENTS; Oil flow adjustments; Chimney draft adjustment

Shut down 1. Turn the control knob to “0" setting. 2. Lift the safety lever. 3. Turn off the oil tank fuel supply valve. The oil tank fuel supply valve should always be shut off when the oil stove is not in operation. ADJUSTMENTS Oil flow adjustments The oil flow setting is done by the manufactu...

Page 11 - MAINTENANCE; Seasonal maintenance

MAINTENANCE Seasonal maintenance WEEKLY - DESCALE Push and pull the de-scaling lever in and out as well as turning slightly at the same time completely two or three times. Push in for normal burner operations or before relighting. EVERY 3 TO 4 MONTHS - CLEAN BURNER Remove all three catalyser compone...

Page 12 - REPLACEMENTS; Ordering replacement parts; Replacement parts

REPLACEMENTS Ordering replacement parts Contact your dealer or the factory for questions concerning prices and policies on replacement parts. Normally all parts can be ordered through your Napoleon dealer or distributor. When ordering replacement parts always give the following information: 1. Model...

Page 16 - TROUBLE SHOOTING

Document n° 1092-1 EN ~ 04/02/2002 16 SYMPTOM PROBLEM TEST SOLUTION Flames extinguish during lighting. Very cold chimney. No draft established - leave door ajar until fire has caught. - check air supply in the room Fire extinguishes once firestarter has burnt off. Fuel tank is empty - fill tank Fuel...