Napoleon EPA 1450 - Manuals

Page 2 - PG; HOME; 4 WOOD PILE MAINTENANCE; TABLE of CONTENTS; PLEASE RETAIN THIS MANUAL FOR FUTURE REFERENCE; Specifi cations

2 W415-0512 / D / 07.16.08 PG 2-4 INTRODUCTION Warranty General Information Care of Plated & Enamelled Parts Care of Glass 5-6 INSTALLATION Installing the Legs Alcove Installation Stove Installation Chimney Connection Adding Chimney Sections Outside Air Wall Pass-through 6-7 MOBILE HOME Venting ...

Page 3 - NAPOLEON® WOOD FIREPLACE PRESIDENT’S LIFETIME LIMITED WARRANTY; fl; CONDITIONS AND LIMITATIONS

3 W415-0512 / D / 07.16.08 NAPOLEON® products are manufactured under the strict Standard of the World Recognized ISO 9001 : 2000 Quality Assurance Certi fi cate. NAPOLEON® products are designed with superior components and materials, assembled by trained craftsmen who take great pride in their work....

Page 4 - are; Do not connect this unit to a chimney flue serving another; PEDESTAL MODELS ONLY; LEG MODELS ONLY; DO NOT CLEAN GLASS WHEN HOT!; When the unit is cool, open; FIGURE 1; GENERAL INFORMATION; CARE OF ALL PLATED AND ENAMELED PARTS; CARE OF GLASS

4 W415-0512 / D / 07.16.08 HOT SECONDARY AIRFIBRE BRICKSRÉFRACTAIRES 2 SIDES, BACK& BOTTOM SECONDARY AIR PRIMARY AIR FLUE GLASS CERAMICGLASS DRAFT CONTROL COMBUSTION AIRINTAKE OPEN CLOSED DÉFLECTEUR EN FIBRE Except for their different depths, models 1100, 1150, 1400, 1900, 1450 and the fi replac...

Page 5 - Security DL6; ALCOVE; STOVE INSTALLATION; INSTALLING THE LEGS; FIGURE 2A; FIGURE 4B

5 W415-0512 / D / 07.16.08 If the stove is to be installed on a combustible fl oor, it must be placed on an approved non-combustible hearth pad, that extends 8” (200mm) beyond the stove sides and back, and 18” (455mm) to the front. It must be installed with a minimum height of 7’ between the stove b...

Page 6 - DO NOT USE ANY MAKESHIFT MATERIALS DUR-; FIGURE 5; MOBILE HOME; VENTING; T H E TOTA L H O R I Z O N TA L V E N T L E N G T H; FIGURE 6; FIGURE 9; FIGURE 8

6 W415-0512 / D / 07.16.08 PEDESTAL BASE 4.5" PEDESTAL BASE FLOOR AREA BELOW ST OVE B" A (in.) B(in.) 1100 8 5/8" 9 3/4" 1400 11 1/8" 9 3/4" 1900 14 7/8" 9 3/4" If possible connect the air intake at the pedestal’s back or bottom t o t h e o u t s i d e w i t h a 4 i n...

Page 7 - This minimum recess can; HINT FOR INSTALLING PORCELAIN; Ensure the base of the porcelain side panels; NOT; FIREPLACE INSERT; OUTSIDE AIR; MODEL

7 W415-0512 / D / 07.16.08 It must be installed between ceil-ing joists, with radiation shield and roof flashing, so that the structural strength, insulation and waterproof qualities of the home are not lessened. Seal with sili-cone to maintain a vapour barrier at the chimney and outside air pipe pe...

Page 8 - In the United States:; INSERT MODEL; Use of the blower increases the output of; BLOWER GUARD; INSTALLATION INTO A FACTORY BUILT; OPTIONAL BLOWER; 101 BLOWER SERVICE OR REPLACEMENT; GASKET

8 W415-0512 / D / 07.16.08 In the United States: While it is not required, it is recom- mended that a chimney liner be installed that is continuous from the insert to the top of the chimney, particularly when the insert is installed in a basement. For this type of connection, use the “In Canada” ins...

Page 9 - F I G U R E 1 6; WINGNUT; BLOWER SERVICE OR REPLACEMENT; Wood; LID LIFTER

9 W415-0512 / D / 07.16.08 3. The access panel can be removed by taking out the 8 #10 self taping screws. A 5/16” nut driver will be required to complete this job. Unplug wires from the thermal switch on the panel. See FIGURE 15. 4. Remove the securing wingnut from the blower mounting bracket, slide...

Page 10 - SIZES; FINISHING

10 W415-0512 / D / 07.16.08 1100/1100C/ 1101 1400/1400L 1402/1450 1900 1100L/1150 4-#1 4-#1 4-#1 4-#1 4-#7 * 2-#4 2-#4 2-#4 2-#4 2-#2 8-#1 8-#1 12-#1 12-#1 12-#7 * 2-#3 2-#3 2-#3 2-#4 (notched) 2-#10 2-#10 2-#11 2-#11 2-#12 2-#13 3-#1 4-#1 5-#1 6-#1 7-#7 * 2-#2 2-#2 2-#2 2-#2 2-#2 1-#5 1-#5 1-#5 1-#...

Page 11 - to start or ‘freshen up’ a fire in this heater. Keep all such; OPERATION; BRICKS AND BAFFLES INSTALLATION

11 W415-0512 / D / 07.16.08 With stove and chimney installation completed, move the bricks into place by working as illustrated for your unit on page 10. 1. Install two or three courses of brick on both sides of the unit. Install two courses on the back wall. Install the fi nal course of bricks on t...

Page 12 - DO NOT OVERFIRE THE STOVE!; ACHIEVING PROPER DRAFT; FIRE EXTINGUISHERS / SMOKE DETECTORS; FUEL LOADING AND BURN CYCLE; ASH FENDER

12 W415-0512 / D / 07.16.08 ASH WELL COVER TO CLOSE: ROTATE PULL HANDLE REAR FOLDING HANDLE TO OPEN: PULL AND ROATE You can now add larger pieces of wood and operate the stove normally. Once the stove/insert is entirely hot, it will burn very effi ciently with little smoke from the chimney. There wi...

Page 13 - three; MAINTENANCE; WHAT TO DO IF A RUNAWAY OR CHIMNEY; LEG UNITS WITH ASH PAN; It is recommended to use a; Do not overfill the ash drawer. Ash should not accumulate

13 W415-0512 / D / 07.16.08 A properly installed Napoleon unit should not smoke. If yours does, check the following: Has the chimney had time to get hot? Is the smoke passage blocked anywhere in the stove, chimney connector or chimney? Is the room too airtight and the air intake not connected to the...

Page 14 - DON’TS

14 W415-0512 / D / 07.16.08 Burn only dry, clean unpainted wood that has been seasoned. It produces more heat and less soot or creosote. Freshly cut wood contains about 50% moisture while after proper seasoning only about 20% of the water remains. As wood is burned, this water boils off consuming en...

Page 15 - REPLACEMENTS; REPLACEMENT PARTS

15 W415-0512 / D / 07.16.08 # PART NO. DESCRIPTION 1 W325-0002 SPRING HANDLE - SMALL 2 W325-0007 SPRING HANDLE - LARGE 3* W090-0001 BRICK - # 1 4* W090-0002 BRICK - # 2 5* W090-0004 BRICK - # 4 LEFT 6* W090-0005 BRICK - # 4 RIGHT 7* W090-0015 BRICK - # 7 8* W090-0018 BRICK - # 8 9* W090-0019 BRICK -...

Page 16 - ACCESSORIES

16 W415-0512 / D / 07.16.08 66 GS200-G ORNAMENTAL TRIVET 67 EP62-1 VARIABLE SPEED BLOWER 68* W500-0064 FRESH AIR COVER PLATE 69* 111KT OUTSIDE AIR KIT 70* W470-0002 ENAMEL TOUCH UP & BRUSH ( SPECIFY COLOUR ) ACCESSORIES 73 AK-1 ADAPTER KIT FOR CISK 74 EI-900K10 10” FLASHING KIT C/W BULL NOSE TRI...

Page 18 - This fireplace must be serviced annually depending on usage.

18 W415-0512 / D / 07.16.08 Fir eplace Ser vice Histor y This fireplace must be serviced annually depending on usage. Date Service T echnician Name Service Performed Special Concerns Dealer Name

Page 19 - NOTES