Napoleon 1400L - Manuals - manualsarea.com

Page 2 - PG; INSTALLATION; TABLE of CONTENTS; PLEASE RETAIN THIS MANUAL FOR FUTURE REFERENCE

2 W415-0512 / B / 11.15.05 PG 2-4 INTRODUCTION WarrantyGeneral InformationCare of Plated & Enamelled PartsCare of Glass 5-6 INSTALLATION Installing the LegsAlcove InstallationStove InstallationChimney ConnectionAdding Chimney SectionsOutside AirWall Pass-through 6-7 MOBILE HOME VentingOutside Ai...

Page 4 - PEDESTAL MODELS ONLY; LEG MODELS ONLY; DO NOT CLEAN GLASS WHEN HOT!; FIGURE 1; GENERAL INFORMATION; CARE OF ALL PLATED AND ENAMELED PARTS; CARE OF GLASS

4 W415-0512 / B / 11.15.05 Except for their different depths, models 1100, 1150, 1400, 1900 and the fireplace inserts 1101 and 1401 are identical and use the same burning principles. They were specifi- cally designed over many months of research to meet the 1990 U.S.A. EPA particulate emission stand...

Page 5 - Security DL6; SINGLE WALL CHIMNEY CONNECTOR*; FIGURE 2B; ALCOVE; STOVE INSTALLATION; INSTALLING THE LEGS; FIGURE 2A; F I G U R E 4 B

5 W415-0512 / B / 11.15.05 To avoid being damaged during shipping, the stove has been bolted to the pallet and must be unbolted before the stove can be installed. 1 . R e m o v e t h e 4 n u t s a n d washers from the underside of the pallet. 2. Lift the stove up and away f r o m t h e p a l l e t t...

Page 6 - DO NOT INSTALL IN SLEEPING ROOM.; FIGURE 5; MOBILE HOME; VENTING; All horizontal smoke pipe must slope slightly; FIGURE 6; FIGURE 9

6 W415-0512 / B / 11.15.05 PEDESTAL BASE 4.5" PEDESTAL BASE FLOOR AREA BELOW ST OVE A" B" A (in.) B(in.) 1100 8 5/8" 9 3/4" 1400 11 1/8" 9 3/4" 1900 14 7/8" 9 3/4" If possible connect the air intake at the pedestal's back or bottom t o t h e o u t s i d e w i t h ...

Page 7 - This minimum recess can; NOT; FIREPLACE INSERT; OUTSIDE AIR

7 W415-0512 / B / 11.15.05 It must be installed be- t w e e n c e i l i n g j o i s t s , w i t h r a d i a t i o n s h i e l d and roof flashing, so t h a t t h e s t r u c t u r a l s t r e n g t h , i n s u l a t i o n and waterproof quali- ties of the home are not l e s s e n e d . S e a l w i t...

Page 8 - In the United States:; Use of the blower increases the output of heat.; must; BLOWER GUARD; INSTALLATION INTO A FACTORY; OPTIONAL BLOWER; 101 BLOWER SERVICE OR REPLACEMENT; GASKET

8 W415-0512 / B / 11.15.05 In the United States: While it is not required, it is rec- ommended that a chimney liner be installed that is con- tinuous from the insert to the top of the chimney, particu- larly when the insert is installed in a basement. For this type of connection, use the "In Can...

Page 9 - SECURING; 401 BLOWER SERVICE OR REPLACEMENT; LID LIFTER

9 W415-0512 / B / 11.15.05 3. The access panel can be removed by taking out the 8 #10 self taping screws. A 5/16" nut driver will be required to complete this job. Unplug wires from the thermal switch on the panel. See FIGURE 15. 4. Remove the securing wingnut from the blower mounting bracket, s...

Page 10 - SIZES; FINISHING; BRICK RETAINER DETAIL - TYPICAL

10 W415-0512 / B / 11.15.05 1100/1100C/ 11 0 1 1 4 0 0 / 1 4 0 0 L 1 4 0 1 1 9 0 0 1100L/1150 4-#1 4-#1 4-#1 4-#1 4-#7 * 2-#4 2-#4 2-#4 2-#4 2-#2 8-#1 8-#1 12-#1 12-#1 12-#7 * 2-#3 2-#3 2-#3 2-#4 (notched) 2-#10 2-#10 2-#11 2-#11 2-#12 2-#13 3-#1 4-#1 5-#1 6-#1 7-#7 * 2-#2 2-#2 2-#2 2-#2 2-#2 1-#5 1...

Page 11 - Never use gasoline, gasoline-type lantern; OPERATION; BRICKS AND BAFFLES INSTALLATION

11 W415-0512 / B / 11.15.05 With stove and chimney installation completed, move the bricks into place by working as illustrated for your unit on page 10. 1. Install two or three courses of brick on both sides of the unit. Install two courses on the back wall. Install the final course of bricks on th...

Page 12 - ASH FENDER; ACHIEVING PROPER DRAFT

12 W415-0512 / B / 11.15.05 ASH WELL COVER ROTATE TO CLOSE: FOLDINGHANDLE REAR ROTATE PULL AND TO OPEN: You can now add larger pieces of wood and operate the stove normally. Once the stove/insert is entirely hot, it will burn very efficiently with little smoke from the chimney. There will be a bed o...

Page 13 - MAINTENANCE; WHAT TO DO IF A RUNAWAY OR CHIMNEY FIRE

13 W415-0512 / B / 11.15.05 A properly installed Napoleon unit should not smoke. If yours does, check the following: Has the chimney had time to get hot? Is the smoke passage blocked anywhere in the stove, chimney connector or chimney? Is the room too airtight and the air intake not connected to the...

Page 15 - REPLACEMENTS; REPLACEMENT PARTS

15 W415-0512 / B / 11.15.05 # PART NO. DESCRIPTION 1 W325-0002 SPRING HANDLE - SMALL 2 W325-0007 SPRING HANDLE - LARGE 3* W090-0001 BRICK - # 1 4* W090-0002 BRICK - # 2 5* W090-0004 BRICK - # 4 LEFT 6* W090-0005 BRICK - # 4 RIGHT 7* W090-0015 BRICK - # 7 8* W090-0018 BRICK - # 8 9* W090-0019 BRICK -...

Page 16 - ACCESSORIES

16 W415-0512 / B / 11.15.05 65 GS200-G ORNAMENTAL TRIVET 66 EP62-1 VARIABLE SPEED BLOWER 67* W500-0064 FRESH AIR COVER PLATE 68* 111KT OUTSIDE AIR KIT 69* W470-0002 ENAMEL TOUCH UP & BRUSH ( SPECIFY COLOUR ) ACCESSORIES 72 AK-1 ADAPTER KIT FOR CISK 73 EI-900K10 10" FLASHING KIT C/W BULL NOSE...

Page 18 - This fireplace must be serviced annually depending on usage.

18 W415-0512 / B / 11.15.05 W olf Steel Fir eplace Ser vice Histor y This fireplace must be serviced annually depending on usage. Date Service T echnician Name Service Performed Special Concerns Dealer Name

Page 19 - NOTES