Multiquip CA4HC - Manuals

PAGE 6 — CA4HC WALK-BEHIND TROWEL— OPERATION MANUAL — REV. #0 (09/29/06) CA4HC TROWEL— SPECIFICATIONS 2. Sound pressure is a weighted measure. It is measured atthe operator's ear position while the walk-behind trowel isoperating at full throttle on concrete in a manner most oftenexperienced in “ nor...

CA4HC WALK-BEHIND TROWEL — OPERATION MANUAL — REV. #0 (09/29/06) — PAGE 7 NOTE PAGE

PAGE 8 — CA4HC WALK-BEHIND TROWEL— OPERATION MANUAL — REV. #0 (09/29/06) TRAINING CHECKLIST This checklist will lists some of the minimum requirements formachine maintenance and operation. Please feel free to detachit and make copies. Use this checklist whenever a new operatoris to be trained or it ...

CA4HC WALK-BEHIND TROWEL — OPERATION MANUAL — REV. #0 (09/29/06) — PAGE 9 DAILY PRE-OPERATION CHECKLIST COMMENTS: CA4HC TROWEL— DAILY PRE-OPERATION CHECKLIST T S I L K C E H C N O I T A R E P O - E R P Y L I A D 1 .l e v e L li O e n i g n E 2 d i u l F x o b r a e G l e v e L . 3 s e d a l B f o n ...

PAGE 10 — CA4HC WALK-BEHIND TROWEL— OPERATION MANUAL — REV. #0 (09/29/06) CA4HC TROWEL— SAFETY MESSAGE ALERT SYMBOLS Safety precautions should be followed at all times when operatingthis equipment. Failure to read and understand and comply withthe Safety Messages and Operating Instructions could res...

CA4HC WALK-BEHIND TROWEL — OPERATION MANUAL — REV. #0 (09/29/06) — PAGE 11 Accidental Starting ALWAYS place the engine ON/OFF switch in the OFF position, when the trowel is not in use. Over Speed Conditions NEVER tamper with the factory settings of the engine governor or settings. Personal injuryand...

PAGE 12 — CA4HC WALK-BEHIND TROWEL— OPERATION MANUAL — REV. #0 (09/29/06) CA4HC TROWEL — RULES FOR SAFE OPERATION The following safety guidelines should always be used whenoperating the CA4HC. SAFETY ■ DO NOT operate or service this equipment before reading this entire manual. Themanual must be kept...

PAGE 14 — CA4HC WALK-BEHIND TROWEL— OPERATION MANUAL — REV. #0 (09/29/06) CA4HC TROWEL— OPERATION AND SAFETY DECALS OPERATION AND SAFETY DECALS The CA4HC walk-behind trowel is equipped with a number of operation, safety and maintenance decals. Should any of these decals become unreadable, replacemen...

CA4HC WALK-BEHIND TROWEL — OPERATION MANUAL — REV. #0 (09/29/06) — PAGE 15 CA4HC TROWEL— GENERAL INFORMATION CA4HC Trowel Familiarization This walk-behind trowel is designed for the floating and finishing of concrete slabs. Take a walk around the trowel. Take notice of all the majorcomponents (see F...

PAGE 16 — CA4HC WALK-BEHIND TROWEL— OPERATION MANUAL — REV. #0 (09/29/06) 4 5 6 9 7 10 15 20 16 19 18 17 11 14 12 13 8 1 3 2 CA4HC TROWEL— CONTROLS AND COMPONENTS 1. Standard Handle – Employs a "starwheel" for manually adjusting blade pitch. 2. Foldable Quick Pitch Handle – Employs a lever h...

CA4HC WALK-BEHIND TROWEL — OPERATION MANUAL — REV. #0 (09/29/06) — PAGE 17 Figure 4. Honda GX120 Engine Controls and Components INITIAL SERVICING The engine (Figure 4) must be checked for proper lubrication andfilled with fuel prior to operation. Refer to the manufacturer's enginemanual for instruct...

PAGE 18 — CA4HC WALK-BEHIND TROWEL— OPERATION MANUAL — REV. #0 (09/29/06) Figure 6. Throttle Idle-Run Position (Standard Handle shown) CA4HC TROWEL— HANDLE ASSEMBLIES Assembly and Installation Before the trowel can be put into operation there are somecomponents that must be installed before the trow...

PAGE 20 — CA4HC WALK-BEHIND TROWEL— OPERATION MANUAL — REV. #0 (09/29/06) 4 5 1 3 7 6 2 Quick Pitch ™ Handle Assembly If your CA4HC TROWEL is equipped with a folding upper handle(Figure 12), you will need to unfold and adjust the trowel handleto the upright position prior to operation. It was assemb...

CA4HC WALK-BEHIND TROWEL — OPERATION MANUAL — REV. #0 (09/29/06) — PAGE 21 ALWAYS wear approved eye and hearing protection before operating thetrowel. NEVER place hands or feet inside the guard rings while the engine is running. CA4HC TROWEL— PRE-INSPECTION Figure 13. Engine Oil Dipstick (Removal) 3...

CA4HC WALK-BEHIND TROWEL — OPERATION MANUAL — REV. #0 (09/29/06) — PAGE 23 3. Place the choke lever (Figure 18) in the " CLOSED " position if starting a cold engine. CA4HC TROWEL — INITIAL START-UP This section is intended to assist the operator with the initialstart-up of the walk-behind tr...

CA4HC WALK-BEHIND TROWEL — OPERATION MANUAL — REV. #0 (09/29/06) — PAGE 25 Figure 25. Maneuvering The Trowel The figure illustrates a typical walk-behind trowel application.Practice maneuvering the trowel. The trick is to let the trowel dothe work. NEVER place your feet or hands inside the guard rin...

PAGE 26 — CA4HC WALK-BEHIND TROWEL— OPERATION MANUAL — REV. #0 (09/29/06) 4 1 3 2 Blades Blades should be changed whenthey fail to finish concrete in asatisfactory manner. CA4HC TROWEL — OPERATION - OPTIONS Optional Float Discs (Pans) These round discs (Figure 29) attach to the spiders and allow the...

CA4HC WALK-BEHIND TROWEL — OPERATION MANUAL — REV. #0 (09/29/06) — PAGE 27 See the engine manual suppliedwith your machine for appropriateengine maintenance scheduleand troubleshooting guide forproblems. MAINTENANCE SCHEDULE Daily (8-10 Hours) 1. Check the oil level in the engine crankcase and gear ...

PAGE 28 — CA4HC WALK-BEHIND TROWEL— OPERATION MANUAL — REV. #0 (09/29/06) S 1 2 2 3 4 CA4HC TROWEL — MAINTENANCE a. Remove the zerk fitting and allen head screw desig- nated by the letter " S " (Figure 32). In addition, on the opposite side of the spider block there is another zerkfitting an...

CA4HC WALK-BEHIND TROWEL — OPERATION MANUAL — REV. #0 (09/29/06) — PAGE 31 CA4HC TROWEL — TROUBLESHOOTING (TROWEL) G N I T O O H S E L B U O R T . 5 E L B A T M O T P M Y S M E L B O R P E L B I S S O P N O I T U L O S .l l a t a t o n r o h g u o r g n i n n u r e n i g n E n i h c ti w S F F O / N...

CA4HC WALK-BEHIND TROWEL — OPERATION MANUAL — REV. #0 (09/29/06) — PAGE 35 Effective: February 22, 2006 TERMS AND CONDITIONS OF SALE — PARTS PAYMENT TERMS Terms of payment for parts are net 30 days. FREIGHT POLICY All parts orders will be shipped collect orprepaid with the charges added to the invoi...

OPERATION MANUAL MULTIQUIP INC..... 18910 WILMINGTON AVE.CARSON, CALIFORNIA 90746800-421-1244 • 310-537-3700FAX: 310-537-3927E-mail:[email protected]:multiquip.com Your Local Dealer is: HERE'S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING © COPYRIGHT 2006, MULTI...