Monessen PL20 - Manuals - manualsarea.com

Page 2 - Parlor Vent Free Fireplace; CONTENTS

90D0093 Parlor Vent Free Fireplace CONTENTS Important Safety Information .................................... 3Code Approval ............................................................. 4Product Features ......................................................... 5 Gas Pressures ........................

Page 3 - IMPORTANT SAFETY INFORMATION; Any change to this heater or its controls can be dangerous.; INSTALLER; CARBON MONOXIDE POISONING:

90D0093 3 Parlor Vent Free Fireplace IMPORTANT SAFETY INFORMATION W ARNING • Any change to this heater or its controls can be dangerous. • Improper installation or use of the heater can cause serious injury or death from fire, burns, explosion or carbon monoxide poisoning. • Do not allow fans to blo...

Page 4 - American National Standards Institute, Inc.

4 90D0093 Parlor Vent Free Fireplace IMPORTANT SAFETY INFORMATION 0. Input ratings are shown in BTU per hour and are for elevations up to ,000 feet. For elevations above ,000 feet, input ratings should be reduced 4 percent for each 1,000 feet above sea level. Refer to the National Fuel Gas Code. 1. ...

Page 5 - Model

90D0093 5 Parlor Vent Free Fireplace FP2552PL20 controls PRODUCT FEATURES OPERATION This unvented gas heater requires no outside venting and burns cleanly with high heating efficiency.This zero-clearance unvented gas heater can be installed against (or recessed into) any wall that is accessible to a...

Page 6 - FIREPLACE and FRAMING DIMENSIONS

6 90D0093 Parlor Vent Free Fireplace 32 56 ” (816 mm) 18 56 ” (460 mm) 19 56O ” (495 mm) 25 6 ” (651 mm) 31 (6 ” (810 mm) 4 56 ” (105 mm) 11/16" (17 mm) Rough OpeningHeight 8 56O ” (216 mm) 5 56 ” (130 mm) 20” (508 mm) Rough Opening Width 10 56QE ” (256 mm) 10 6 ” (270 mm) 10 56O " (267 mm) ...

Page 7 - GETTING STARTED; Do not; Gloves are recommended when handling; ARNING; Do not install the heater:

90D0093 7 Parlor Vent Free Fireplace GETTING STARTED Make sure you have received all parts:Check your packing list to verify that all listed parts have been received. You should have the following: • Unvented gas heater • Ceramic fiber logs • Two () anchoring screws • Installation/operating instruct...

Page 8 - ADEQUATE COMBUSTION AND VENTILATION AIR; defines a confined space as a space; COMBUSTION and VENTILATION AIR

8 90D0093 Parlor Vent Free Fireplace ADEQUATE COMBUSTION AND VENTILATION AIR This heater shall not be installed in a confined space or unusually tight construction unless provisions are provided for adequate combustion and ventilation air. The National Fuel Gas Code, (ANSI Z223.1/NFPA54), defines a ...

Page 9 - FIREPLACE INSTALLATION; “Clearances” section on; DO NOT INSTALL THIS MODEL IN A BEDROOM OR BATHROOM.; Minimize modifications to existing construction.

90D0093 9 Parlor Vent Free Fireplace FIREPLACE INSTALLATION FIREPLACE LOCATION Carefully select the best location for installation of your unvented fireplace. The following factors should be taken into consideration. • Clearance to side wall, ceiling, woodwork and window or other combustibles. Refer...

Page 10 - Ensure that minimum clearances shown in; Sidewall Clearances; Ceiling Clearance; Figure 5; Back Wall Clearance; — The appliance may be placed against a combustible back wall.; Floor Clearance; — Must meet the clearance requirements detailed in; The dimensions shown in; Figures 5 and 6; are minimum clearances to

10 90D0093 Parlor Vent Free Fireplace FIREPLACE INSTALLATION CLEARANCE and HEIGHT REQUIREMENTS Ensure that minimum clearances shown in Figures 5 and 6 are maintained. Left and right clearances are determined when facing the front of the firebox.Follow these instructions carefully to ensure safe inst...

Page 11 - Construct fireplace framing; Secure nailing flanges to side of firebox.

90D0093 11 Parlor Vent Free Fireplace FIREPLACE INSTALLATION If unit is to be “built in”, fireplace framing can be built before or after the appliance is set in place. BE SURE THAT ALL PACkING MATERIAL HAS BEEN REMOVED FROM THE UNDERSIDE OF THE UNIT PRIOR TO SETTING THE FIREBOX IN PLACE. Construct f...

Page 12 - “CLEaRanCES and HEiGHt REquiREmEntS”; INSTALL ARCHED BRICk LINER

1 90D0093 Parlor Vent Free Fireplace FIREPLACE INSTALLATION FP2561anchor screws Anchor Screws 3/16" x 1 Z\v " FP561 Figure 10 - Secure Heater to Floor or Hearth SECURE HEATER TO FLOOR OR HEARTH N O T E : C l e a r a n c e r e q u i r e m e n t s a s d e t a i l e d i n “CLEaRanCES and HEiGHt...

Page 13 - Consult all local codes.

90D0093 13 Parlor Vent Free Fireplace FIREPLACE INSTALLATION NOTICE: A qualified gas appliance installer must connect the heater to the gas supply. Consult all local codes. W ARNING Use new black iron or steel pipe. Internally tinned copper or copper tubing can be used per National Fuel Code, sectio...

Page 14 - DO NOT USE AN OPEN FLAME.

14 90D0093 Parlor Vent Free Fireplace FIREPLACE INSTALLATION When tightening the joint to the valve, hold the valve securely to prevent movement. Test all gas joints from the gas meter to the heater valve for leaks using a gas analyzer or soap and water solution after completing connection. DO NOT U...

Page 15 - ELECTRICAL INSTALLATION

90D0093 15 Parlor Vent Free Fireplace ELECTRICAL INSTALLATION FP2112awiring diagram8/09 Figure 15 - Wiring Diagram Switch On/OffSwitch On/OffSwitch Optional Remote or Wall Switch ODS Pilot Valve TH = 3 TP = 1 TP/TH = ODS Pilot Spade Terminal FP11a W ARNING Label all wires prior to disconnection when...

Page 16 - CAUTION; Electrical Grounding Instructions:

16 90D0093 Parlor Vent Free Fireplace ELECTRICAL INSTALLATION CONNECT OPTIONAL REMOTE CONTROL RECEIVER Figure 16 1. Open bottom access door. . Connect the remote wire connectors to the TH, TH/TP connections on the valve. Figure 16 3. Stick Velcro• pads with self-adhesive backing to bottom of remote ...

Page 17 - CHECk SYSTEM OPERATION

90D0093 17 Parlor Vent Free Fireplace CHECk SYSTEM OPERATION The millivolt system and individual components may be checked with a millivolt meter having a 0-1000 mV range. Conduct each check shown in chart below by connection meter test leads to terminals as indicated. A. COMPLETE MILLIVOLT SYSTEM C...

Page 18 - LOG PLACEMENT; Before you begin

18 90D0093 Parlor Vent Free Fireplace LOG PLACEMENT Before you begin — This unit is supplied with four (4) ceramic fiber logs. Do not handle these logs with your bare hands. Always wear gloves to prevent skin irritation from ceramic fibers. After handling the logs, wash your hands gently with soap a...

Page 19 - . Place Log # on burner by aligning hole in bottom; Place Log #1 on burner by aligning

90D0093 19 Parlor Vent Free Fireplace LG720PL20 Log 2 Log # LG70 Figure 20 - Place Log #2 LG719PL20 Log 1 Log #1 LG719 Figure 19 -Place Log #1 LOG PLACEMENT . Place Log # on burner by aligning hole in bottom of log with pin located at front of burner. Gently push log down until it comes in contact w...

Page 20 - Place Log #3 by placing rectangular notch on bottom; Place Log #4 by placing rectangular notch on bottom

0 90D0093 Parlor Vent Free Fireplace LG721PL20 Log 3 Log #3 LG71 Figure 21 - Place Log #3 3. Place Log #3 by placing rectangular notch on bottom of log onto the rectangular protrusion on top of log #. Place the other end of log #3 between the front grate and the small 'L' shaped bracket located on t...

Page 21 - FLAME APPEARANCE; It should just; MILLIVOLT CONTROL; CHECk BURNER FLAME APPEARANCE

90D0093 1 Parlor Vent Free Fireplace FP2273pilot bad flame FP2272pilot correct flame FLAME APPEARANCE Flames from the pilot, front and rear burner should be visually checked as soon as the heater is installed. In addition, periodically check the flames visually during operation. CHECk THE PILOT FLAM...

Page 22 - OPERATING INSTRUCTIONS; Avoid any drafts that alter burner flame patterns.; Do not allow fans to blow directly into

90D0093 Parlor Vent Free Fireplace OPERATING INSTRUCTIONS OPERATING INSTRUCTIONS Avoid any drafts that alter burner flame patterns. Do not allow fans to blow directly into the fireplace. Do not place a blower inside the burn area of the firebox. Ceiling fans may create drafts that alter flame patter...

Page 23 - WHAT TO DO IF YOU SMELL GAS:; • Do not attempt to light any appliance.; FOR YOUR SAFETY READ BEFORE LIGHTING

90D0093 3 Parlor Vent Free Fireplace FP2552PL20 controls OPERATING INSTRUCTIONS A. This appliance is equipped with a piezo ignition device which automatically lights the pilot. If piezo is not working properly, refer to match Lighting instructions, Page 24. B. BEFORE OPERATING smell all around the a...

Page 24 - MILLIVOLT CONTROL LIGHTING INSTRUCTIONS; match Lighting instructions, Page 25; TO TURN OFF GAS TO HEATER

4 90D0093 Parlor Vent Free Fireplace FP2563Piezo OPERATING INSTRUCTIONS MILLIVOLT CONTROL LIGHTING INSTRUCTIONS 1. STOP! Read the safety information label. . Make sure the manual shutoff valve is fully open.3. This gas log set is equipped with an ignition device (piezo) which automatically lights th...

Page 25 - OPERATING INSTRUCTIONS and MAINTENANCE; MATCH LIGHTING INSTRUCTIONS; CLEANING AND SERVICING; Do not use cleaning fluid to clean logs or any part of heater.

90D0093 5 Parlor Vent Free Fireplace OPERATING INSTRUCTIONS and MAINTENANCE MATCH LIGHTING INSTRUCTIONS 1. Remove any items necessary for easy access to the pilot (for example: logs, screens, etc.).. Follow appropriate lighting instructions found previously. Instead of pushing and releasing the piez...

Page 26 - TROUBLESHOOTING

6 90D0093 Parlor Vent Free Fireplace TROUBLESHOOTING W ARNING • Turn appliance OFF and allow to cool before servicing. • Only a qualified service person should service and repair the heater. OBSERVED PROBLEM When ignitor button is pressed, there is no spark at ODS/pilot. Appliance produces unwanted ...

Page 28 - REPLACEMENT PARTS; Description

8 90D0093 Parlor Vent Free Fireplace REPLACEMENT PARTS PL20 Firebox Parts Ref. Description Qty. PL20NV PL20PV 1. Complete Burner Assembly 1 90D0076 90D0095 . Valve 1 14D0467 14D0468 3. 3/16" Tubing Assy. 1 49D0050 49D0050 4. 1/4" Tubing (") 1 01530 01530 5. Pilot Regulator 1 14D0469 14D0...

Page 30 - OPTIONAL ACCESSORIES; DECORATIVE TRIM FRONTS

30 90D0093 Parlor Vent Free Fireplace OPTIONAL ACCESSORIES FIREBRICkS Optional firebrick kits can be installed. Refer to installation instructions provided with kit or Page 12. Adobe Arched Firebrick PLAAFBA Tuscany Arched Firebrick PLTAFBA Cobbled Fieldstone Arched Brick PLCFAFBA REMOTE CONTROLS ON...

Page 31 - DECORATIVE FACE INSTALLATION; slots on the front of the unit. Two on each side.

90D0093 31 Parlor Vent Free Fireplace DECORATIVE FACE INSTALLATION INSTALLATION INSTRUCTIONS 1. Remove face from packaging.. Hold face securely on each side.3. Place the four (4) hooked protrusions on the back of the face into the four (4) rectangular slots on the front of the unit. Two on each side...

Page 32 - LIMITED LIFETIME WARRANTY POLICY; LIFETIME WARRANTY; serial number of your MHSC product.; MHSC

3 90D0093 Parlor Vent Free Fireplace LIMITED LIFETIME WARRANTY POLICY LIFETIME WARRANTY The following components are warranted for life to the original owner, subject to proof of purchase: Firebox, Combustion Chamber, Heat Exchanger, Grate and Stainless Steel Burners. FIVE YEAR WARRANTY The followin...