Page 2 - DANGER; WARNING; STRUCTURAL PROXIMITY AND SAFETY USAGE RECOMMENDATIONS; Before using smoker check wind direction; TRIP HAZARD THAT; which could cause property damage, personal injury, or death.
2 Burning wood chips gives off carbon monoxide, which has no odor and can cause death. DO NOT burn wood chips inside homes, vehicles, tents, garages or any enclosed areas. USE ONLY OUTDOORS where it is well ventilated. CARBON MONOXIDE HAZARD DANGER IF YOU SMELL GAS: 1. Shut off gas to the appliance....
Page 3 - GENERAL WARNINGS AND SAFETY INFORMATION; READ ALL INSTRUCTIONS; WARNINGS & IMPORTANT SAFEGUARDS CONTINUED ON PAGE 4
3 GENERAL WARNINGS AND SAFETY INFORMATION • Always use unit in accordance with all applicable local, state and federal fire codes. • Before each use check all nuts, screws and bolts to make sure they are tight and secure. • Never operate unit under overhead construction such as roof coverings, carpo...
Page 5 - • Cure your smoker periodically to prevent excessive rust.; OPERATING INSTRUCTIONS; When smoking one or two items, use top two racks for best results.; and; • Store only when fire is completely out and all surfaces are cold.; CHECK OUT MASTERBUILT.COM FOR MORE TIPS AND RECIPE VIDEOS.; SMOKER OPERATION - READ & FOLLOW ALL INSTRUCTIONS CAREFULLY
5 GETTING STARTED • Pre-season unit prior to first use. See PRE-SEASON INSTRUCTIONS . • Before starting the unit, see ADDING WOOD CHIPS OR ADDING WOOD CHUNKS . • This smoker is equipped with door stops that will hold the door open during loading and unloading of food. • This smoker is calibrated to ...
Page 6 - SOAPY WATER TEST WARNINGS & PROCEDURES; WARNINGS; • Never use an open flame to test for gas leaks.; PERFORM “SOAPY WATER TEST” BEFORE EACH USE. SEE “SOAPY WATER TEST”; FUMES TO DIMINISH BEFORE LIGHTING SMOKER.; DURING ANY PORTION OF SOAPY WATER TEST IF BUBBLES CONTINUE TO
6 Apply solution to gas cylinder valve Failed test will present bubbles as shown below. Apply solution underneath control panel where burner and hose are connected WARNING SOAPY WATER TEST WARNINGS & PROCEDURES WARNINGS • Soapy Water Test MUST be performed each time gas cylinder is connected to ...
Page 7 - REGULATOR, BURNER AND GAS VALVE CONNECTION & OPERATION; IGNITION INSTRUCTIONS; A clogged tube can lead to a fire beneath unit.
7 REGULATOR, BURNER AND GAS VALVE CONNECTION & OPERATION IGNITION INSTRUCTIONS CLOCKWISE COUNTER CLOCKWISE 17.75” (45cm) APPROX. 12.25” (45cm) APPROX. Fig. 3 Fig. 1 • Inspect hose before each use. If there are signs of abrasion, wear, cuts, or leaks, the hose must be replaced. DO NOT USE. • Insp...
Page 8 - TROUBLESHOOTING GUIDE; Symptom; In the event of a gas leak that cannot be stopped, or if a; MATCH LIGHT INSTRUCTIONS; Read all instructions and warnings before lighting.
8 TROUBLESHOOTING GUIDE Symptom Cause Possible Solution Gas leaking from cracked, cut or burned hose Damaged hose Turn off gas at LP cylinder. Replace hose.Contact Masterbuilt at 1.800.489.1581. Gas leaking from LP cylinder Failure due to rust or mishandled equipment Replace LP cylinder. Gas leaking...
Page 9 - FAQ; PARTS LIST; Actual product may differ from picture shown.
9 TROUBLESHOOTING SOLUTIONS: “CAUSES” LOW OR NO FLOW/VAPOR LOCK/EXCESS FLOW Symptom Cause Possible Solution Burner doesn’t light after pressing ignitor button Low/no gas flow 1. Turn smoker control knob to “Off” position. 2. Turn gas cylinder valve knob to OFF. 3. Disconnect regulator from cylinder ...
Page 10 - HARDWARE LIST
10 PARTS LIST NO QTY DESCRIPTION 1 1 Air Damper 2 1 Top Smoker Body 3 1 Top Smoker Door 4 1 Bottom Smoker Body 5 1 Bottom Smoker Door 6 1 Top Cabinet Temperature Sensor Cover 7 1 Bottom Cabinet Temperature Sensor Cover 8 1 Top Door Handle 9 1 Bottom Door Handle 10 4 Smoking Rack 11 1 Water Bowl Rack...
Page 11 - • BEFORE ASSEMBLY READ ALL INSTRUCTIONS CAREFULLY.; DO NOT RETURN TO RETAILER; for assembly assistance, missing or damaged parts.
11 WARNING • Smoker should only be rolled on smooth surface. • Potential damage to smoker or harm to user may result from failure to follow warnings. • Smoker should never be rolled up/down stairs or uneven surface. • BEFORE ASSEMBLY READ ALL INSTRUCTIONS CAREFULLY. • ASSEMBLE UNIT ON A CLEAN, FLAT ...
Page 12 - ASSEMBLY
12 ASSEMBLY Actual product may differ from picture shown. A x4 23 4 3 2 1 A A 2 3 C C x7 4 2 A A A F x2 x2 4 F F 14 36
Page 17 - ENSAMBLAJE; Take out the racks to
17 10 12 11 4 2 21 20 3 5 1 E E A x1 x1 A 18 ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE 19 Take out the racks to clean after each use.
Page 18 - Take out the grease tray
18 28 5 27 26 23 24 22 13 15 ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE Take out the grease tray to clean after each use.
Page 19 - WARRANTY STATEMENT
19 09/11 WARRANTY STATEMENT GASMATE BARBEQUES AND ACCESSORIES PRODUCT RANGE SITRO GROUP AUSTRALIA (S.G.A.) warrants the purchaser of this product against defects in workmanship and materials for the following periods from the date of purchase: For domestic use, this table applies:- Stainless steel c...
Page 20 - Customer Service; Monday to Friday 8am - 5pm EST
Rest assured, we’re here to help. Do not return to place of purchase. For any queries or assistance call Customer Service (Australia Only) 1300 174 876 Hours of operation: Monday to Friday 8am - 5pm EST Keep your purchase receipt. This will be required to make any claims under the 12 month warranty.
