Lenovo E10-30- Manuals

Lenovo E10-30 Hardware Maintenance Manual 2 Follow these rules below to ensure general safety:• Observe a good housekeeping in the area where the machines are put during and after the maintenance. • When lifting any heavy object: 1. Make sure that you can stand safely without slipping.2. Distribute ...

Safety information 3 Observe the following rules when working on electrical equipments. • Find the room emergency power-off (EPO) switch, disconnecting switch, or electrical outlet. If an electrical accident occurs, you can then operate the switch or unplug the power cord quickly. • Do not work alon...

Safety information 5 The purpose of this inspection guide is to assist you in identifying potential unsafe conditions. As each machine was designed and built, required safety items were installed to protect users and service personnel from injury. This guide addresses only those items. You should us...

Lenovo E10-30 Hardware Maintenance Manual 6 Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electrostatic discharge (ESD). ESD damage can occur when there is a difference in charge between objects. Protect against ESD damage by equalizing the c...

Safety information 7 The safety notices in this section are provided in English, French, German, Hebrew, Italian, Japanese, and Spanish. Safety notices: multilingual translations Safety notice 1 Before the computer is powered on after FRU replacement, make sure all screws, springs, and other small p...

Lenovo E10-30 Hardware Maintenance Manual 8 Safety notice 2 DANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery, recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances or regul...

Safety information 9 Safety notice 3 DANGER The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing wh...

Lenovo E10-30 Hardware Maintenance Manual 10 Safety notice 4 DANGER The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water. Dispose of t...

Safety information 11 Safety notice 5 If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water at least for 15 minutes. Seek medical care if any symptoms caused by the fluid are present after washing.Si le panneau d’affi...

Lenovo E10-30 Hardware Maintenance Manual 12 Safety notice 6 DANGER To avoid shock, do not remove the plastic cover that protects the lower part of the inverter card.Afin d’éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure de la carte d’alime...

Safety information 13 Safety notice 8 DANGER Before removing any FRU, turn off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables.Avant de retirer une unité remplaçable en clientèle, mettez le système hors tension, dé...

Lenovo E10-30 Hardware Maintenance Manual 14 Some models of Lenovo computer are equipped from the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. Such devices are also sold separately as options. If one of these drives is installed, it is certified in the U.S. to co...

Safety information 15 A CD-ROM drive, a DVD-ROM drive, or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode. Note the following: DANGER Emits visible and invisible laser radiation when open. Do not stare into the beam, do not view directly with optical instr...

Lenovo E10-30 Hardware Maintenance Manual 16 This chapter presents the following important service information:• “Strategy for replacing FRUs” on page 16 – “Strategy for replacing a hard disk drive” on page 17– “Important notice for replacing a system board” on page 17 • “Important information about...

Important service information 17 Use the following strategy to prevent unnecessary expense for replacing and servicing FRUs:• If you are instructed to replace an FRU, but the replacement does not solve the problem, reinstall the original FRU before you continue. • Some computers have both a processo...

Lenovo E10-30 Hardware Maintenance Manual 18 RoHS, The Restriction of Hazardous Substances in Electrical and Electronic Equipment Directive (2002/95/EC) is a European Union legal requirement affecting the global electronics industry. RoHS requirements must be implemented on Lenovo products placed on...

General checkout 19 This chapter presents the following information:• “What to do first” on page 20• “Power system checkout” on page 21 Before you go to the checkout, make sure to read the following important notes: General checkout Important notes: • Only certified trained personnel can service the...

Lenovo E10-30 Hardware Maintenance Manual 20 When you do return an FRU, you must include the following information in the parts exchange form or parts return form that you attach to it:1. Name and phone number of servicer2. Date of service3. Date on which the machine failed4. Date of purchase5. Proc...

General checkout 21 To verify a symptom, follow the steps below:1. Turn off the computer.2. Remove the battery pack.3. Connect the AC adapter.4. Make sure that power is supplied when you turn on the computer.5. Turn off the computer.6. Disconnect the AC adapter and install the charged battery pack.7...

Lenovo E10-30 Hardware Maintenance Manual 22 Perform operational charging. If the battery status indicator or icon does not light on, remove the battery pack and let it return to room temperature. Reinstall the battery pack. If the charge indicator or icon is still off, replace the battery pack. If ...

Related service information 23 This chapter presents the following information:• “Restoring the factory contents by using Recovery Disc Set” on page 23• “Passwords” on page 24• “Power management” on page 25 When the hard disk drive or solid state drive is replaced because of a failure, no product re...

Lenovo E10-30 Hardware Maintenance Manual 24 7. When all of the data has been copied from the last disc in the set, remove the disc and restart the computer. 8. When the recovery process is complete, the Welcome to the Microsoft Windows screen is displayed. Follow the instructions on the screen to c...

Related service information 25 Note: Power management modes are not supported for APM operating system. To reduce power consumption, the computer has three power management modes: screen blank, sleep (standby), and hibernation. Screen blank mode If the time set on the “Turn off monitor” timer in the...

Lenovo E10-30 Hardware Maintenance Manual 26 2. Select Power → Shut down . Putting your computer to sleep If you will be away from your computer for only a short time, put the computer to sleep. When the computer is in sleep mode, you can quickly wake it to resume use, bypassing the startup process....

Lenovo E10-30 27 This chapter presents the following product-specific service references and product-specific parts information:• “Specifications” on page 27• “Status indicators” on page 29• “FRU tests” on page 31• “Fn key combinations” on page 31• “FRU replacement notices” on page 32• “Removing and...

Lenovo E10-30 29 The system status indicators below show the computer status: Status indicators a b c

Lenovo E10-30 Hardware Maintenance Manual 30 Table 2. Status indicators Attention: • When the indicator is on, do not put the computer into sleep mode or turn off the computer. • When the indicator is on, do not move the computer. Sudden physical shock might cause drive errors. Indicator Indicator s...

Lenovo E10-30 31 The following table shows the function of each combination of Fn with a function key. Table 3. Fn key combinations The following is a brief introduction to the function key combinations. Fn + Pgup: Activates the pause function. Fn + PgDn: Activates the break function. PgUp: Enables/...

Lenovo E10-30 Hardware Maintenance Manual 32 This section presents notices related to removing and replacing parts. Read this section carefully before replacing any FRU. Screw notices Loose screws can cause a reliability problem. In the Lenovo computer, this problem is addressed with special nylon-c...

Lenovo E10-30 33 This section presents exploded figures with the instructions to indicate how to remove and replace the FRU. Make sure to observe the following general rules:1. Do not attempt to service any computer unless you have been trained and certified. An untrained person runs the risk of dam...

Lenovo E10-30 35 1020 Dummy card Figure 2. Removal steps of dummy card Remove the dummy card in the direction shown by arrows . a b b a

Lenovo E10-30 Hardware Maintenance Manual 36 1030 Keyboard For access, remove this FRU:• “1010 Battery pack” on page 34 Figure 3. Removal steps of keyboard Remove three screws . Loosen the keyboard with fingers in the direction shown by arrow . Step Screw (quantity) Color Torque P/N M2 × 1.7 mm, fla...

Lenovo E10-30 Hardware Maintenance Manual 40 1050 Hard disk drive For access, remove these FRUs in order:• “1010 Battery pack” on page 34• “1020 Dummy card” on page 35• “1030 Keyboard” on page 36• “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover” on page 38 Figure 5. Re...

Lenovo E10-30 Hardware Maintenance Manual 42 1060 PCI Express Mini Card for wireless LAN/WAN For access, remove these FRUs in order:• “1010 Battery pack” on page 34• “1020 Dummy card” on page 35• “1030 Keyboard” on page 36• “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cov...

Lenovo E10-30 Hardware Maintenance Manual 44 1070 Fan assembly and Heat Sink assembly For access, remove these FRUs in order:• “1010 Battery pack” on page 34• “1020 Dummy card” on page 35• “1030 Keyboard” on page 36• “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover” on ...

Lenovo E10-30 Hardware Maintenance Manual 46 1080 System board For access, remove these FRUs in order:• “1010 Battery pack” on page 34• “1020 Dummy card” on page 35• “1030 Keyboard” on page 36• “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover” on page 38 • “1050 Hard di...

Lenovo E10-30 51 1100 Base cover, speakers, power assembly and USB board For access, remove these FRUs in order:• “1010 Battery pack” on page 34• “1020 Dummy card” on page 35• “1030 Keyboard” on page 36• “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover” on page 38 • “10...

Lenovo E10-30 53 Note: Applying labels to the base cover The new base cover FRU is shipped with a kit containing labels of several kinds. When you replace the base cover, you need to apply the following label: The following labels need to be peeled off from the old base cover, and need to be put on ...

Lenovo E10-30 Hardware Maintenance Manual 56 1120 LCD panel, LCD cable and hinges For access, remove these FRUs in order:• “1010 Battery pack” on page 34• “1020 Dummy card” on page 35• “1030 Keyboard” on page 36• “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover” on page...

Lenovo E10-30 59 1130 Integrated camera and power switch board For access, remove these FRUs in order:• “1010 Battery pack” on page 34• “1020 Dummy card” on page 35• “1030 Keyboard” on page 36• “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover” on page 38 • “1050 Hard di...

Lenovo E10-30 61 1140 Antenna assembly and LCD cover For access, remove these FRUs in order:• “1010 Battery pack” on page 34• “1020 Dummy card” on page 35• “1030 Keyboard” on page 36• “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover” on page 38 • “1050 Hard disk drive” ...

Lenovo E10-30 Hardware Maintenance Manual 62 Front view Integrated camera Wireless antennas Display Novo button Power button Built-in microphone System indicators Touch pad Touch pad buttons Memory card slot Locations abcdefghij a b c d f h e g i j

Lenovo E10-30 Hardware Maintenance Manual 64 Bottom and Left-side view AC power adapter jack VGA port Ventilation slots USB 3.0 ports Combo audio jack Battery latch - manual Battery pack Battery latch - spring loaded Ventilation slots Speakers abcdefghij h a b c d e f g i j

Lenovo E10-30 65 This section presents the following service parts:• “Overall” on page 66• “LCD FRUs” on page 70• “Keyboard” on page 72• “Miscellaneous parts” on page 76• “AC adapters” on page 77• “Power cords” on page 78 Parts list Notes: • Each FRU is available for all types or models, unless spec...

Lenovo E10-30 Hardware Maintenance Manual 66 Overall 2 4 16 9 12 1 8 14 a 15 6 7 10 1 3 11 3 c b 5 d

Lenovo E10-30 Hardware Maintenance Manual 70 LCD FRUs In Lenovo E10-30, there are following types of LCDs.• “10.1-in. HD TFT” E10-30 8 2 1 2 5 7 9 8 4 4 3 6

Lenovo E10-30 Hardware Maintenance Manual 72 Keyboard Table 6. Parts list—Keyboard Language P/N CRU ID E10-30 Chicony (Black) English 25216103 ** U.K. English 25216104 ** Italian 25216105 ** Spanish 25216106 ** Turkish 25216107 ** Thai 25216108 ** Portuguese 25216109 ** Latin 25216110 ** Canadian En...

Lenovo E10-30 Hardware Maintenance Manual 76 Miscellaneous parts Table 7. Parts list—Miscellaneous parts Screw Table 8. Parts list—screws FRU P/N CRU ID System miscellaneous parts: • (a) E10-30 HDD Bracket • (b) E10-30 Touchpad Bracket 9020545390205461 N Cable miscellaneous parts: • (c) E10-30 Touch...

Lenovo E10-30 77 AC adapters Table 9. Parts list—3-pin AC adapters FRU P/N CRU ID 45W(3pin), Delta ADLX45NDC3A 20V2.25A adapter Delta BLACK 36200602 N 45W(3pin), Liteon ADLX45NLC3A 20V2.25A adapter Liteon BLACK 36200606 N 45W(3pin), Chicony ADLX45NCC3A 20V2.25A adapter Chicony BLACK 36200610 N

Lenovo E10-30 Hardware Maintenance Manual 78 Power cords A Lenovo power cord for a specific country or region is usually available only in that country or region: Table 10. Parts list—3-pin power cords Region P/N CRU ID CCC • LINETEK PC323+RVV300/300+LS15 1m 145000600 * Argentina • LINETEK LS15+H03V...

Notices 81 Lenovo may not offer the products, services, or features discussed in this document in all countries. Consult your local Lenovo representative for information on the products and services currently available in your area. Any reference to a Lenovo product, program, or service is not inten...

Lenovo E10-30 Hardware Maintenance Manual 82 Any performance data contained herein was determined in a controlled environment. Therefore, the result obtained in other operating environments may vary significantly. Some measurements may have been made on development-level systems and there is no guar...