Lennox SDVCS - Manuals

Lennox SDVCS – Manual in PDF format online.

Manuals:

Manual

Manual Lennox SDVCS

Summary

Page 2 - TABLE OF CONTENTS; USING THIS MANUAL

2 CONGRATULATIONS! When you purchased your new gas stove, you joined the ranks of thousands of individuals whose answer to their home heat-ing needs reflects their concern for aesthetics, efficiency and our environment. We extend our continued support to help you achieve the maximum benefit and enjo...

Page 5 - ). Choisissez la langue qui est principale; COLOCACIóN DE ADVERTENCIAS DE; ) o en el termostato de pared; LENNOX HEARTH PRODUCTS; WARNINGS; ). The warnings should already have been; LENNOX HEARTH PRODUCTS; Figure A

5 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. APPOSITION DES MISES EN GARDE RELATIVES À LA SÉCURITÉ D’UTILISATION Votre foyer a été livré avec des étiquettes de sécurité qui doivent être collées à côté des dispositifs de contrôle du foyer. Une étiquette de sécurité doit être collée sur la p...

Page 7 - Page; appliance; Note: See Page 28 for ordering information.; RATINGS; NATURAL GAS

7 PRE-INSTALLATION Features Installation Options Residential Vented vertical and horizontal Manufactured (mobile) home Natural gas (NG) or propane (LP) Bedrooms Optional wallmounted or remote thermostat Venting This appliance can be vented with Secure Vent™ directvent pipe by Security Chimneys™*. ...

Page 8 - and may create a serious fire, health, or other safety hazard.; Top View; Figure 2; Side View; Figure 1; Pipe Clearances; for allowable pipe configurations.; Flue Collar

8 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Dimensions The gas line screws into the gas valve at the back of the stove 5” in from the right side of the stove and 43/16” up from the base of the unit. Preparing Your Stove For Installation Read all instructions before beginning your install...

Page 9 - Clearances to Combustibles; for pipe clearances.; Floor Protection; Figure 6; Com; Co; Alcove dimensions

9 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Alcove Option 1 Alcove Option 3 Alcove Option 2 Carpet Leg 1-1/2” (38mm) Maximum Corner Installation Clearances to Combustibles Minimum clearances to combustible materials shown here are in inches (millimeters). See Pages 8 and 9 for pipe cleara...

Page 10 - Firebox Accessories / Parts; Description; ). The charred black with white highlights surface of the log; Baffle

10 Firebox Accessories / Parts Cat. No. Description H5861 Log Set H5863 Bag of Embers (volcanic stone) H5864 Bag of Rockwool (glowing embers) H5865 Bag of Steel Wool Log Installation Instructions If logs are not installed according to the log installation in- structions, flame impingement and improp...

Page 11 - Side-Insert Installation; . Complete this step; Tile Inserts

11 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Side-Insert Installation Follow these steps to install the cast iron inserts or your own custom stone inserts in this appliance: 1. Remove the cast iron top and set it aside.2. Remove the cast iron upper piece A see Figure 14 . Complete this ...

Page 12 - Vent Installation; Page 9; Residential and Mobile Home Installations:; Four indentations on female ends of pipes and

12 Vent Installation V enting : This appliance has been tested and listed as a directvent heater system by OMNITest Laboratories, Portland, Oregon and is rec ommended for use with Security™ Secure Vent pipe*. Important: • Read all instructions carefully before starting the installation. Failure t...

Page 13 - Vent Parts List; Part Number

13 Vent Parts List Secure Vent directvent pipe by Security Chimneys* may be used with this appliance. Please see the lists below to verify the components available from each directvent pipe manufacturer. Snorkel terminations are available for applications which may require vertical rise on the bu...

Page 14 - Snorkel Terminations; for restrictor positioning). Follow the same; Vertical Vent Installation

14 Snorkel Terminations For installations requiring a vertical rise on the exterior of the building, 14inch and 36inch tall snorkel terminations are available. When using a snorkel, the stove can be vented directly out the back. There is a vent starter collar fastened to the stove (to vent straig...

Page 15 - Flue Restrictors; amount of combustion air will be delivered.; Flue Restrictor Adjustment Guidelines

15 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. A Flue Opening in the top of the firebox A Restrictor Restrictor Installed Over Flue Opening Figure 23 Figure 25 Figure 24 Flue Restrictors The flue restrictor settings shown in Figures 26 and 27 are for typical installations and may need to be...

Page 16 - Horizontal Terminations; To install the stove with pipe directly out the back (as shown in; Vertical Terminations

16 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. 8’ Max. Restrictor Position # 4 Restrictor Position # 3 Restrictor Position # 3 Restrictor Position # 2 No Restrictor 18” Section of Pipe Horizontal Terminations The shaded areas in the diagram below show all allowable combinations of vent conf...

Page 17 - Exterior Horizontal Vent Termination Clearance Requirements; Minimum Clearances

17 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Exterior Horizontal Vent Termination Clearance Requirements V V V V V F C B B A B H M I X V D V A A A V L B J X E V A G *18” 18” B C C C K X * See Item D in the Text Below. Center Line of Termination Exterior Wall Horizontal Termination Ventila...

Page 19 - ). To properly complete the installation of this; APPOSITION DES MISES EN GARDE; ) ou sur le thermostat; COLOCACIóN DE ADVERTENCIAS DE SEGURIDAD; ) y en el transmisor

19 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. INSTALLER INSTRUCTIONS - ATTACHING SAFETY-IN-OPERATION WARNINGS It is the installers responsibility to ensure these warnings are properly affixed during installation. These warning labels are a critical step in informing consumers of safe opera...

Page 21 - TO TURN OFF GAS TO APPLIANCE; Figure; Burner Flame Appearance; Proper Pilot Flame Appearance

21 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. WARNINGS • Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. For assistance or additional information, consult a qualified installer, ...

Page 24 - WARNING; Turn off gas and electrical power to the fireplace

24 CAUTION: Wear gloves and safety glasses for protection while doing required maintenance. Verify proper operation after servicing. S'assurer que l'appareil fonctionne adéquatement une fois l'entretien terminé. Maintenance Checklist: The following should only be performed by a qualified service tec...

Page 25 - Door Latch; CAUTION

25 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Door Latch Figure 36 Glass Door Only doors certified with the appliance shall be used. Seules des portes certifiées pour cet appareil doivent être utilisées. CAUTION: DO NOT abuse glass door by striking or slamming shut. Do not remove glass doo...

Page 27 - in poor performance and safety hazards.

27 REPLACEMENT PARTS - VINT-DVS-U / SDVCS Cat. No. Description H6031 Cassette Assembly, NG (if LP, also requires 75190 Conversion Kit) H5936 Burner Assembly H5947 Pilot Assembly NG H2830 Pilot Assembly LP H5942 Gas Control Valve, NG (if LP, also requires H5945 LP Regulator) H5943 Regulator, NG H5945...

Page 31 - NOTES

Page 32 - WARRANTY; Natural Gas

32 Printed in U.S.A. © 2007 Lennox Hearth Products P/N 775227M REV. F 09/2011 Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fi...