Lennox GV230 - Manuals

Lennox GV230 – Manual in PDF format online.

Manuals:

Manual

Manual Lennox GV230

Summary

Page 2 - TABLE OF CONTENTS

2 USING THIS MANUAL Please read and carefully follow all of the instructions found in this manual. Please pay special attention to the safety instructions provided in this manual. PRODUCT IS SUBJECT TO CHANGE WITHOUT NOTICE CONGRATULATIONS! When you purchased your new wood stove, you joined the rank...

Page 3 - READ THIS MANUAL IN ITS ENTIRETY AND UNDER-

3 IMPORTANT SAFETY AND WARNING INFORMATION READ THIS MANUAL IN ITS ENTIRETY AND UNDER- STAND THESE RULES TO FOLLOW FOR SAFETY. Pl an ni ng In st al la tio n Sa fe ty a nd G en er al In st al la tio n Op er at io n M ai nt en an ce Tr ou bl es ho ot in g Pa rts / Ac ce ss or ie s 1. When this room he...

Page 4 - A draft test should; TESTING INFORMATION; Overfiring Damage

4 This manual describes the installation and operation of the Grandview™ 230 non-catalytic wood heater. This heater meets the U.S. Environmental Protection Agency’s emissions limits for wood heaters sold on or after July 1, 1990. This heater has been developed, tested and constructed in accordance w...

Page 5 - Ventilation Requirements; CHIMNEY HEIGHT REqUIREMENTS; Figure 1; - Chimney Height Requirements; Less than

5 Pl an ni ng In st al la tio n Sa fe ty a nd G en er al In st al la tio n Op er at io n M ai nt en an ce Tr ou bl es ho ot in g Pa rts / Ac ce ss or ie s This appliance is not designed to be operated in a negative pressure. In very airtight homes with large kitchen exhaust fans, furnace cold air re...

Page 7 - INSTALLATION CLEARANCES - REFER TO FIGURES 2, 3 AND 4; Corner Installation; Elbow; Top View; USA

7 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Figure 4 Figure 3 Pl an ni ng In st al la tio n Sa fe ty a nd G en er al In st al la tio n Op er at io n M ai nt en an ce Tr ou bl es ho ot in g Pa rts / Ac ce ss or ie s Footnotes: 1- These dimensions to the stove body are for reference only. A...

Page 8 - ALCOVE INSTALLATIONS - FLOOR PROTECTION

8 When the Grandview™ 230 is installed in an Alcove, the floor protection must be a thermally rated non-combustible floor protector meeting or exceeding a thermal rating of k=.47 or equivalent with a listed thickness of 1/2" (12.7 mm) minimum in the USA and Canada. The thermal protec- tion must ...

Page 9 - SPECIFICATIONS - GRANDVIEWTM 230; Specifications; The GrandviewTM Model GV230 woodstove; Listing; Figure 5

9 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Pl an ni ng In st al la tio n Sa fe ty a nd G en er al In st al la tio n Op er at io n M ai nt en an ce Tr ou bl es ho ot in g Pa rts / Ac ce ss or ie s SPECIFICATIONS - GRANDVIEW™ 230 Stove Pipe Diameter Single Wall or Double Wall 6” (152 mm) L...

Page 10 - Single Wall Pipe; Using 6” Diameter Single Wall Connector Pipe; Figure 6 - Typical Installation; YOUR CHIMNEY INSTALLATION MUST COMPLY WITH LOCAL

10 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Shown with Tubinox™ Stainless Steel Liner components (see Page 28 for ordering information) Chimney Termination Cap Chimney Termination Rain Cap Masonry Adaptor Length 90° Tee Storm Collar Roof Flashing Flashing Ceiling Support Assembly Slip Ad...

Page 11 - Figure 8 - Typical Installation

11 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Pl an ni ng In st al la tio n Sa fe ty a nd G en er al In st al la tio n Op er at io n M ai nt en an ce Tr ou bl es ho ot in g Pa rts / Ac ce ss or ie s Manufactured Home Installations (ref. Figure 8) This appliance is approved for installation...

Page 12 - Figure 9; thicknesses shall be permitted.

12 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Chimney Connector Systems and Clearances from Combustible Walls for Residential Heating Appliances (NFPA 211) Refer to Figure 9 System A. Minimum 3.5 in. (90 mm) thick brick masonry wall framed into combustible wall with a minimum of 12 in. (30...

Page 13 - You MUST plug

13 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Pl an ni ng In st al la tio n Sa fe ty a nd G en er al In st al la tio n Op er at io n M ai nt en an ce Tr ou bl es ho ot in g Pa rts / Ac ce ss or ie s Figure 10 Residential and Mobile Homes (Tieing down and grounding are required only in mobi...

Page 14 - ATTACHING STOVE TO MANUFACTURED HOME FLOOR; Tie Down Holes

14 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Figure 12 - Securing Pedestal to Floor Figure 13 - Securing Coastal and Lakeview Legs to Floor Figure 14 - Securing Olympic Legs to Floor ATTACHING STOVE TO MANUFACTURED HOME FLOOR Leg Tie Down Kits (Manufactured [mobile] Homes) Order: H7665 Le...

Page 15 - OUTSIDE COMBUSTION AIR KIT INSTALLATION; Figure 16 - Outside Air Connection to Stove; Outside Air Kits; Outside Air Kit Coupler; Figure 17 - Through the Wall, Outside Air Termination; Manufactured Home Through the Floor Outside Air Kit Installa-; Figure 18 - Manufactured Home Installation; In

15 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Pl an ni ng In st al la tio n Sa fe ty a nd G en er al Op er at io n M ai nt en an ce Tr ou bl es ho ot in g Pa rts / Ac ce ss or ie s OUTSIDE COMBUSTION AIR KIT INSTALLATION Figure 16 - Outside Air Connection to Stove Outside Air Kits Order: 1...

Page 16 - Letter A Brick Are Full Size; Back Baffle Board; Assure that brick spacers are pushed to each side until they are in

16 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. CAUTION: Wear gloves during brick installation in case of sharp edges inside the stove. WARNING: IF THE BRICKS ARE NOT INSTALLED EXACTLY AS SHOWN BELOW, THEY COULD FALL OUT OF PLACE DURING REFUELING OR BURNING OF THE STOVE CAUSING SERIOUS INJUR...

Page 18 - Opening Door; Closing Door; Handle; DO NOT; CAUTION; Be careful not to abuse door assembly by striking or; to keep the gasket from adhering to the curing paint.

18 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Opening Door - Lift handle and pull to open door Closing Door - Hold handle lifted, swing door closed then push handle down to engage latch Handle Door Do not operate the appliance with the door open or ajar other than possibly during start up ...

Page 19 - SEE MAINTENANCE SECTION FOR GLASS CLEANING GUIDELINES AND

19 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Place a small amount of crumpled paper in front of the firebox Cover paper with a few pieces of kindling Light paper Pl an ni ng In st al la tio n Sa fe ty a nd G en er al In st al la tio n Op er at io n M ai nt en an ce Tr ou bl es ho ot in g ...

Page 20 - the space required for refueling and ash removal.; OK; Standard; Seasoning Guide

20 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. FUEL This unit is designed and engineered to burn, dry, well-seasoned wood only. Dry, seasoned wood is that which has been cut, split and allowed to dry under a covered area where air is free to flow and circulate under and around the wood (not...

Page 21 - ACHIEVING CLEAN, LONG BURNS; combustion; MAXIMIZING YOUR STOVE’S OVERALL EFFICIENCY; Op

21 To achieve long burn times, after having thoroughly preheated the stove, load the firebox without blocking the small air opening found in the center front of the firebox. At this point, you may need to burn the stove with the draft open for a few minutes to ignite the wood. All Lennox Hearth Prod...

Page 22 - WARNINGS; Figure 28 - Blower Wiring Schematic; Blower Operation Guidelines; NOTE: Turn blower off before opening the door to load the fuel.; Blower Operation

22 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. NOTE: SWITCH CONDITIONS GIVEN AT ROOM TEMPERATURE N/C = NORMALLY CLOSED N/O = NORMALLY OPEN = FEMALE DISCONNECT = MALE DISCONNECT = STUD CONNECTION TWO POSITION SWITCH MANUAL/TEMPERATURE AUTO-RESET TEMPERATURE SWITCH N/O SPEED CONTROL/OFF ROOM ...

Page 23 - Figure 30 - Glass Replacement

23 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Door Gasket Glass Retainer Glass Retainer Hex Head Screws 10 ea. Glass with Gasket Upper Hinge Pin Lower Hinge Pin Back View of Door Back View of Doorframe Pl an ni ng In st al la tio n Sa fe ty a nd G en er al In st al la tio n Op er at io n M...

Page 24 - CREOSOTE FORMATION AND NEED FOR REMOVAL

24 DOOR GASKET: Periodically check gasket to make sure it is not over- compressed. If compressed, replace with a special woven door rope. (Don’t try substituting rope, only use Lennox Hearth Products door rope). PLATED ACCESSORIES: Clean only with household type glass cleaner and a very soft cotton ...

Page 25 - proper draft with the correct size chimney flue.; SMOKES WHEN; ) The draft control must be closed further.; PAINT GIVES OFF; TROUBLESHOOTING

25 Pl an ni ng In st al la tio n Sa fe ty a nd G en er al In st al la tio n Op er at io n M ai nt en an ce Tr ou bl es ho ot in g Pa rts / Ac ce ss or ie s Problem Solution POOR DRAFT: Extend chimney in length or have the chimney realigned to the proper size flue. Oversized chimneys normally have po...

Page 27 - ACCESSORIES - MODEL GRANDVIEWTM 230

27 ACCESSORIES - MODEL GRANDVIEW™ 230 Pl an ni ng In st al la tio n Sa fe ty a nd G en er al In st al la tio n Op er at io n M ai nt en an ce Tr ou bl es ho ot in g Pa rts / Ac ce ss or ie s PEDESTAL (REqUIRED) Item # Cat. No. Model Description 1 H8343 PED-GV Pedestal, Black OR LEGS (REqUIRED) 2 H83...

Page 28 - Secure BlackTM Single Wall Stove Pipe; Security ChimneysTM Pipe; Tubinox Components

28 ACCESSORIES - MODEL GRANDVIEW™ 230 Secure Black™ Single Wall Stove Pipe 6” SW Pipe and Accessories Cat. No. Model Description Pc. / Container 6SWL6 6SWL6 LENGTH 6” X 6” 100 6SWL12 6SWL12 LENGTH 6” X 12” 5 6SWL24 6SWL24 LENGTH 6” X 24” 10 6SWL36 6SWL36 LENGTH 6” X 36” 2 6SWL48 6SWL48 LENGTH 6” X 4...

Page 29 - Secure Temp® Factory-Built Chimney

29 ACCESSORIES - MODEL GRANDVIEW™ 230 Secure Temp® Factory-Built Chimney 6” Secure Temp ASHT and Secure Temp G-ASHT Cat. No. Model Description Pc. / Container Lengths and Fittings 6L8 6L8 LENGTH 6” X 8” 1 6L12 6L12 LENGTH 6” X 12” 1 6L18 6L18 LENGTH 6” X 18” 1 6L24 6L24 LENGTH 6” X 24” 1 6L36 6L36 L...

Page 30 - WARRANTY; LENNOX HEARTH PRODUCTS; PRODUCT REFERENCE INFORMATION

Printed in U.S.A. © 2011 by Lennox Hearth Products P/N 506031-01 Rev. B 11/2011 Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for ...