Lennox EBVSTNM-B - Manuals - manualsarea.com

Page 2 - To order a FREE Lennox; Operation Warnings; All parts of your Lennox; Table of Contents; Safety and Your Fireplace; FREE; SAFETY; OFFER; The Lennox; To receive your FREE; SAFETY GUARD

2 Safety and Your Fireplace  To prevent severe burns and injuries, install a screen or physical barrier to prevent direct contact with the glass. To order a FREE Lennox ® SAFETY GUARD for your fireplace, see details at left.  Follow the safety instructions below and be sure everyone in your househ...

Page 3 - Les surfaces de votre foyer deviennent; Toutes les parties de votre foyer; SAFETY GUARD GRATIS; ¡Las superficies de la chimenea se ponen; ¡Todas las partes de la chimenea; Seguridad y

3  Afin d'éviter de vous brûler gravement ou de vous blesser, installez une grille ou une barrière physique pour empêcher tout contact direct avec la vitre. Pour commander un PANNEAU DE PROTECTION Lennox ® GRATUIT pour votre foyer, consultez les détails dans la partie gauche.  Suivez les instructi...

Page 5 - Figure A

5 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. APPOSITION DES MISES EN GARDE RELATIVES à LA SÉCURITÉ D’UTILISATION Votre foyer a été livré avec des étiquettes de sécurité qui doivent être collées à côté des dispositifs de contrôle du foyer. Une étiquette de sécurité devrait être collée sur l...

Page 6 - General Information; Millivolt; AND MAINTENANCE; Carbon Monoxide Poisoning:; OPERATION

6 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. General Information The fireplace models covered in this manual are b-vented decorative fireplaces designed for residential application. The Millivolt appliances have a millivolt gas control valve with piezo ignition system. If any optional acce...

Page 7 - Table 3; Tables 2 and 3; Table 1

7 BTU Input These fireplaces are designed as supplemental heaters. Therefore, it is advisable to have an alternate primary heat source when installed in a dwelling. Millivolt Models - The millivolt appliances are manually controlled and feature a spark igniter (piezo) that allows the appliance's pil...

Page 8 - OPERATION AND CARE OF YOUR APPLIANCE; WARNING; same room as the appliance. Toddlers, young children and others; AVERTISSEMENT; risque d’avoir accès à la pièce et aux surfaces chaudes.; Gas Controls/Control Compartment; Figure 1

8 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. 8 OPERATION AND CARE OF YOUR APPLIANCE WARNING Young children should be carefully supervised when they are in the same room as the appliance. Toddlers, young children and others may be susceptible to accidental contact burns. A physical barrier ...

Page 9 - Figure 3; Honeywell Electronic; Figure 2; SIT Millivolt Gas Valve; Figure 4

9 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Figure 3 Honeywell Electronic Gas Valve Figure 2 Note: The piezo ignitor is located on the modesty panel - refer to Figure 1. Variable Flame Height Adjustment ( Millivolt Appliances only) 1. All Millivolt appliances are equipped with a variable ...

Page 10 - Do not operate the shutoff lever

10 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. To open the outside air shutter, open the botttom control access panel, reach into the gap between the firebox bottom and the modesty panel, and pull the outside air control lever all the way out. The outside air shutter should be fully open wh...

Page 11 - Note: Improper positioning of logs can create; Turn off gas and electrical power

11 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. MAINTENANCE (See Maintenance Schedule, Page 25) Refer to the maintenance schedule for maintenance tasks, procedures, periodicity and by whom they should be performed. Always verify proper opera- tion of the appliance after servicing. Replacing ...

Page 12 - • Do not attempt to substitute; Removing Glass Enclosure Panels; Figure 6

12 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Front Glass Enclosure Panel, Removal and Installation WARNING Any safety screen or guard removed for servicing the appli- ance must be replaced prior to operating the appliance. AVERTISSEMENT Tout écran ou protecteur retiré pour permettre l’ent...

Page 13 - Glass Enclosure Panel; • DO NOT attempt to install the; REFERENCE

13 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. READ WARNINGS ON THIS PAGE BEFORE PROCEEDING. FOLLOW THE LOG PLACEMENT INSTRUCTIONS EXACTLY 1. Remove the front glass enclosure panel (see Glass Enclosure Panel Removal and Installation Instructions , Page 12 ) . 2. Remove the following from fi...

Page 14 - EBVPF AND EBVST LOG PLACEMENT; Figure 9; Log

14 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. EBVPF AND EBVST LOG PLACEMENT Figure 9 Catalog Number for the entire log set: 55M04 Log Part Number Description Number 1 Log, Corner 55M18 2 Log, Rear/Left 55M19 3 Log, Front/Left 55M20 4 Log, Rear/Right 55M21 5 Log, Front/Center 55M22 6 Log, C...

Page 15 - EBVPF AND EBVST LOG PLACEMENT (CONTINUED)

15 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. EBVPF AND EBVST LOG PLACEMENT (CONTINUED) Catalog Number for the entire log set: 55M04 Log Part Number Description Number 1 Log, Corner 55M18 2 Log, Rear/Left 55M19 3 Log, Front/Left 55M20 4 Log, Rear/Right 55M21 5 Log, Front/Center 55M22 6 Log...

Page 16 - Burner Flame Appearance

16 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. BURNER ADjUSTMENTS (QUALIFIED TECHNICIANS ONLY) Flame Appearance and Sooting Proper flame appearance is a flame which is blue at the base and becomes yellowish-orange in the body of the flame. When the appliance is first lit, the entire flame m...

Page 17 - Light appliance (follow lighting procedure; BURNER FLAME ADjUSTMENTS

17 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. WARNINGS • Air shutter adjustment should only be performed by a quali- fied professional service tech- nician. • Ensure front glass panel are in place and sealed during adjustment. CAUTIONS • Soot will be produced if the air shutter is closed t...

Page 18 - LENNOX HEARTH PRODUCTS; PRODUCT REFERENCE INFORMATION; The installation date of the appliance.; WARRANTY

18 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. ATTENTION: AU MOMENT DE L'ENTRETIEN DES COMMANDES, ÉTIQUETEZ TOUS LES FILS AVANT DE LES DÉBRANCHER. DES ERREURS DE CÁBLAGE PEU-VENT ENTRAÎNER UN FONCTIONNEMENT INADÉQUAT ET DANGEREUX. LENNOX HEARTH PRODUCTS 1508 Elm Hill Pike, Suite 108 Nashvil...

Page 19 - Product Reference Information; ACCESSORY COMPONENTS; Arch Door Kits; ti

19 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Product Reference Information Cat. No. Model Ship. Weight Ship. Volumn H7826 EBVSTNM 282 lbs. (36.2 cu.ft.) H7828 EBVSTNE 282 lbs. (36.2 cu.ft.) H7827 EBVSTPM 282 lbs. (36.2 cu.ft.) H7829 EBVPFNM 270 lbs. (36.2 cu.ft.) H7831 EBVPFNE 270 lbs. (3...

Page 21 - Outside Air Kits Models FOAK-4 and FOAK-4LD; tt

21 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. ACCESSORY COMPONENTS CONTINUED Polished Brass and Brushed Stainless Louvers Kits Decorative louvers are available for use with all Multi-Open Series appliances. These louvers are designed to replace the standard radiant panels that are provided...

Page 22 - ACCESSORY COMPONENTS CONTINUED

22 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. The brickaded liner kits include ceramic panels as shown here. The panels have brick-like features in relief. ACCESSORY COMPONENTS CONTINUED H0779 (Top Vent) H0778 (Top Vent) H0780 & H0781 (Top Vent) H0779 (Rear Vent) H0778 (Rear Vent) H078...

Page 23 - View Doors are not available for the EBVPF models.; Arch Design

23 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. ACCESSORY COMPONENTS CONTINUED Style View Doors -Style View Doors come in 4 beautiful styles. They are easy to install and will not require hardware to attach them to the standard glass door frame. The door includes heavy duty magnet door latch...

Page 24 - Tall Arch Pane Door; available for EBVPF models.; “Crescents” Grille Kits

24 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. ACCESSORY COMPONENTS CONTINUED This screen panel kit can be installed on the glass enclosure panel to prevent direct contact with the hot glass surface. The panel kit adds a new design choice with a handsome textured iron fin- ish. The screen p...

Page 25 - Annually (Before the onset of the Burning Season)

25 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. MAINTENANCE TASK ACCOMPLISHING PERSON PROCEDURE Inspecting/Cleaning Burner, Logs and Controls Qualified Service Technician Inspect valve and ensure it is properly operating. Check piping for leaks. Vacuum the control compartment, fireplace logs...

Page 26 - LIGHTING INSTRUCTIONS – MILLIVOLT GAS VALVE; FOR YOUR SAFETY READ BEFORE LIGHTING; Note: Knob cannot be turned from “PILOT” to “OFF”

26 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLO- SION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INjURY OR LOSS OF LIFE. 6. Wait five (5) minutes to clear out any gas. If you then smell gas, STOP! Follow “B” in the s...

Page 27 - INSTRUCTIONS D’ALLUMAGE – VANNE GAZ MILLIVOLT; INSTRUCTIONS D'ALLUMAGE; POUR FERMER LE GAZ QUI ALIMENTE L’APPAREIL; SIT Vanne Gaz Millivolt

27 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. AVERTISSEMENT : SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS à LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE EXPLOSION CAUSANT DES DOMMAGES MATÉRIELS, DES BLESSURES CORPORELLES OU MÊME DES PERTES DE VIE. INSTRUCTIONS D’ALLUMAGE – VANNE GAZ MI...

Page 28 - LIGHTING INSTRUCTIONS — ELECTRONIC; Front View; RESULT CAUSING PROPERTY DAMAGE, PERSONAL INjURY OR LOSS OF LIFE.

28 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. A. When lighting the appliance, follow these instructions exactly. B. BEFORE OPERATING smell all around the appliance area for gas. Be sure to smell next to the floor because some gas is heavier than air and will settle on the floor. WHAT TO DO...

Page 29 - INSTRUCTIONS D’ALLUMAGE — ELECTRONIC; INSTRUCTIONS D’ALLUMAGE

29 INSTRUCTIONS D’ALLUMAGE — ELECTRONIC INSTRUCTIONS D’ALLUMAGE POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE A. Lorsque vous allumez l’appareil, suivez exactement ces instruc- tions. B. AVANT L’ALLUMAGE: Assurez-vous que vous ne détectez aucune odeur de gaz autour de l’apareil ainsi ...

Page 30 - TROUBLESHOOTING THE MILLIVOLT GAS CONTROL SYSTEM; CORRECTIVE ACTION

30 TROUBLESHOOTING THE MILLIVOLT GAS CONTROL SYSTEM 1. Spark ignitor will not light pilot after repeated triggering of ignitor button. 2. Pilot will not stay lit after carefully following the light- ing instructions. 3. Pilot burning, no gas to burner, Valve knob “ON,” Wall Switch “ON.” 4. Frequent ...

Page 31 - TROUBLESHOOTING THE ELECTRONIC IGNITION SYSTEM; SYMPTOM; connections or broken wires and repair as needed.; Burners come “ON” but

31 TROUBLESHOOTING THE ELECTRONIC IGNITION SYSTEM SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION See Below. Disconnect the two black wires from the wire nuts. Test switch(s) for continu- ity with a multimeter. If continuity is not indicated, switch(s) is defective and must be replaced. Note: Before repla...

Page 32 - REPLACEMENT PARTS LIST

32 REPLACEMENT PARTS LIST . o N N O I T P I R C S E D e n a p o r P d n a l a r u t a N . o N tr a P . y t Q . y t Q T S V B E F P V B E a 1 . n i 4 2 - k c a l B ,t n a i d a R r e p p U Y E 5 8 8 1 9 - B L e n o n 1 b 1 . n i 0 4 - k c a l B ,t n a i d a R r e p p U Y C 5 8 8 1 9 - B L 2 2 a 2 . n...

Page 33 - can result in poor performance and safety hazards.; REPLACEMENT PARTS LIST CONTINUED; GAS CONTROLS — HONEYWELL ELECTRONIC

33 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. WARNING Failure to position the parts in accordance with these diagrams or failure to use only parts specifically approved with this appliance may result in property damage or personal injury. AVERTISSEMENT Risque de dommages ou de blessures si...

Page 34 - REPLACEMENT PARTS

NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. REPLACEMENT PARTS 2b 4b 5b 6b 1b 3b 42 7 10 11 15 31 37 43 41 45 32 33 12 50 14 44 13 35 36 Note: - EBVPF Shown - see the tables on pages 30 and 31 for replacement parts applicable to EBVST fireplaces. 9b 8 34 1a 2a 3a 4a 5a 6a 10 Cabinet Corner P...

Page 35 - Notes